FOBO ULTRA User Manual Draft (For iOS7.1 and Android 4.
Contents 1 Introduction 2 About FOBO Ultra 3 Importance of Tire Care 4 Product Description of FOBO Ultra 5 4.1 In-Car unit/Repeater 4.2 Tire Sensor unit 4.3 Sensor lock nuts & wrench Using FOBO Ultra 6 5.1 Installing FOBO Ultra App 5.2 Installing FOBO Ultra In-Car unit and sensors 5.3 FOBO SHARE - Setting up multiple users 5.4 Sensor rotation 5.5 Disable sensor and Replace new sensor 5.6 Transfer FOBO Ultra to another user 5.7 How to change profile picture 5.8 Tire Inflation/Deflation 5.
1 Introduction FOBO Ultra is the world‟s most advanced Tire Pressure Monitoring System (TPMS) using Bluetooth Smart (Bluetooth 4.1 or later) technology to monitor your Truck, RV, Caravan tire pressure and temperature. Bluetooth Smart is a very low power wireless technology that could operate on a single coin cell battery for up to Fifteen months (NOTE: Battery life may vary according to usage and climatic temperature. Operating under extreme cold may drastically reduce battery life.
receive alerts and data from your FOBO Ultra on their respective smart phone which is installed with FOBO Ultra App. Refer Details at Section 5.3 FOBO Ultra packaging consists of 4 wireless tire sensors, 1 wireless In-Car unit and a 24V 10 feet power cable with connector to In-Car or Repeater. Replace your vehicle tire valve caps with the sensors and place the In-Car unit inside the cab. The sensors will measure tire pressure of each tire and transmit via Bluetooth to the InCar unit and your smartphone.
On the other hand, an overinflated tire will cause accelerated wear on the center portion of the tire resulting in uneven tire wear. It would also result in a harsher ride and makes the tire more susceptible to damage when going over potholes or debris on the road.. What is the optimum tire pressure? There are a lot of information about this subject in internet forums and web articles.
4 Product Description of FOBO Ultra 4.1 In-Car Unit Antenna Action Buttons Battery cover The functions of three action buttons are to correspond with the instruction that appears on the screen. NOTE: Excessive frequent pressing on the buttons will drain the In-Car unit battery. Status indicator - LED will blink to show Bluetooth pairing mode or battery low status Alert buzzer - buzzer to alert when there is problem with tire AA batteries - In-car unit/Repeater operates with 5AA size batteries.
The In-Car unit is designed with an efficient antenna that can pick up sensor signals better than a usual smartphone, enabling good signal reception from the tire sensors. Keep the In-Car unit in the cab and fix the Repeater in the center of the Trailer for optimal functioning of FOBO Ultra. You may remove it for other sensor operation purposes, such as sensor position rotation and sensor disabling but place it back once the sensor operation is completed. Note that In-Car unit is not waterproof.
4.2 Tire Sensor Unit Knob cover Rf4f4 f4f4f 44f4f Single Internal Battery Knob cover – waterproof cover. Please ensure the red silicon ring is intact to prevent water from getting into electronics compartment. Single internal battery - CR2032 coin cell battery. When replacing battery, please ensure the “+” sign of the battery is facing up, away from PCB.
As a corollary, a tire with a Fobo reading of, say 40 psi at an altitude of 5000ft, will read the same 40 psi when driven to sea-level, given a constant temperature. In reality, it will read higher due to the warmer temperature at sea-level, and may need some air release if the temperature difference is great. Tire pressure generally will increase 1 psi (~7kPa) for every 10 deg F (5.6 deg C) rise in temperature.
A missing or damaged tire sensor can be replaced easily through the In-car unit. You will need to purchase a replacement sensor which you can do so online at www.my-fobo.com. To replace the sensor, first select „Disable Sensor‟ on the In-car unit under sensor Management system and the pop-up will prompt you to tap on the tire position that you want to disable.
4.3 Sensor Lock nuts and wrench FOBO Ultra sensors and In-Car unit are tied to a FOBO account after installation. They are not re-usable or transferable without the owner releasing them from his/her FOBO account. This is a theft deterrent feature to discourage theft. As an additional anti-theft feature, all FOBO Ultra package comes with locknuts and special wrench. FOBO Tire Plus‟s functionality is not affected if you do not use the lock-nuts.
WARNING: Do not apply too much force to tighten the lock-nut. You may face difficulty to loosen the lock nut later on especially for rubber valves that typically doesn’t stay firm on the tire rims. NOTE: If your tire valve is too short, you shouldn’t use the lock nut as this will block the sensors from being completely screwed on the tire valve and causes air leak. Our sensors are designed to work on a tire valve with a minimum of 5 thread counts.
Step by step diagram to use FOBO Ultra Lock Nut and wrench 13 | P a g e
5 Using FOBO Ultra 5.1 Installing FOBO Ultra App You are required to have a smartphone with Bluetooth 4.0 (Bluetooth Smart) capability in order to use FOBO Ultra. The smartphone must also be running on iOS 7.1 or Android 4.3 and above. Follow the steps below to install your FOBO Ultra: Step 1: Download the FOBO Ultra App onto your smartphone For iPhone users, download from Apple‟s AppStore. For Android users, download from Google Play. Search for “FOBO Ultra”.
the FOBO Ultra App uses to operate properly and to sync with the InCar unit. It will ensure FOBO Ultra functions as designed, mainly for alert functions, and also the gauge pressure feature as required by users living at high altitudes. FOBO Ultra is designed to be a low energy system and does not drain your smartphone battery excessively.
door. You cannot proceed with the pairing without the input of this information into the FOBO Ultra App. 8) Click “Done” on the top right hand corner of the screen. 9) Select “sensor installation” under Main Menu of In-Car unit and follow the instructions on screen of the In-Car unit. 10) You will be prompted that installation is completed and you are now ready to use FOBO Ultra.
5.3 FOBO SHARE- Setting up multiple users FOBO Ultra is easy to share with your family members and friends. You can share FOBO Ultra with up to 100 users by using the App‟s FoboShare function. All that is required is for the other person to download the FOBO Ultra App (they will also need an iOS/Android smartphone with Bluetooth 4.0 that is running on iOS7.1 or Android 4.3 and above). They need to activate their App with their email and login to the App.
need to physically remove the sensors. To correct the position of the sensors in the in-car unit, please select “sensor Rotation” under Main Menu on in-car unit. You will be prompted by the in-car unit to: 1) 2) 3) 4) 5) Select the sensor position to rotate. Move to the desired position to select the sensor by using the arrow key which is in the middle of the incar unit/Repeater. Upon selection, you will be prompted to touch the sensor to the in-car unit /Repeater.
6. Once replaced you will see “Sensor is successfully replaced..”. Please mount the sensor to the physical tire position in accord with the screen message. NOTE: You can only install a replacement sensor after the tire position has been “Disabled”. You can purchase replacement sensors online from www.my-fobo.com. 5.6 Transfer FOBO Ultra to another user Before passing on your FOBO Ultra set to another user, you will have to release the Total system from your FOBO account.
To HOOK a trailer: 1. Select “Hook & Drop” in the Main Menu of In-Car unit. 2. Select “Hook a trailer”. 3. Upon selecting, the in-car unit will scan for available trailers nearby in Bluetooth range. 4. List of available trailers will be displayed on the in-car unit screen. 5. Select the desired trailer from the list which you would like to Hook. 6. To confirm press “Yes”. 7. Once hooked you will see “Hook successful” message will appear on the screen. To DROP a trailer: 1. 2. 3. 4. 5. 6.
A. Soft Alert – In-Car unit will beep 5 tone alert every 5 minutes for 15 minutes – 6.1 Pressure below preset limit You will receive this soft alert when the tire pressure drops below the pre-set lower limit. The pre-set value for the low limit is 8% below the recommended pressure that you have set or below 160kPa, whichever that is higher. You can change this lower limit in the advance setting down to a minimum of 160kPa (1.6 bar/23 psi).
6.4 In-Car unit/Repeater battery level low You will receive this soft alert when the In-Car unit/Repeater reaches a certain low level. Please change the battery immediately after you receive this alert. You will continue to receive this alert every time you start moving your vehicle until the battery is changed. B. Emergency Alert – In-Car unit/Repeater it will beep continuously non-stop with a two tone alert every 3 seconds for 15 minutes. 6.
6.8 Signal low or sensor missing You will receive this emergency alert when the In-Car unit/Repeater fails to communicate with the tire sensor. It could be the sensor signal is blocked, sensor unit damaged or missing from the tire. If confirmed the sensor is damaged or missing, you could disable the sensor in order to continue using FOBO Ultra with remaining working sensors. Please purchase the sensor replacement immediately.
Soft alert – unit will produce “di di di di di” tone once and repeat every 3 minutes. LED will blink for 5 seconds on problematic tire. This alert is for non-emergency situation such as: Tire pressure slightly exceed above or below user pre-set limits. It is not dangerous to continue driving. Sensor battery low. Once notified on low sensor battery, please remember to change the battery as soon as possible. Do not leave the unit to continue operating under low battery for a long time.
8 Replacing Battery The coin cell battery (CR2032) used in the FOBO Ultra sensors could last up to fifteen months based on normal operating condition. Operating in extreme cold or hot temperatures may reduce battery operating life for both the tire sensors and the In-Car unit. You will receive an alert on the smartphone and In-Car unit/Repeater when the sensor or In-Car unit/Repeater battery levels are low. You will be alerted every time you start to drive your vehicle until the battery is replaced.
Unable to Login after signing up to FOBO App o Make sure your e-mail address is typed correctly o A verification mail will be sent to your e-mail address o Follow the instruction in the mail to activate your account before you can Login o Check if internet connection is available on your smartphone Unable to pair FOBO Ultra In-Car unit/Repeater o Make sure the battery is installed correctly and battery tab is removed. o Make sure your smartphone has Bluetooth 4.0 or later (Smart Ready) capability.
10 FOBO Ultra Specifications Sensor Specifications: • • • • • • • • • • • Maximum Pressure 1296 Kpa (188 psi) Pressure Accuracy: 1 σ = +/- 0.79 psi (0 to + 50 °C) 1 σ = +/- 1.06 psi (-40 to + 85°C) Temperature Accuracy: 1 σ = +/- 1 °C (0 to + 50 °C) 1 σ = +1.33 / - 1°C (-40 to + 85°C) Operational temperature range: -40 to 85°C Up to 15 months battery life CR2032 Dust protected & Waterproof : IP57 Light weight sensors. Only 12.
Mechanical & Environmental Reliability Testing Standards: IEC 60068-2-2, IEC 60068-2-1, IEC 60068-2-29, IEC 60068-2-5, IEC 60068-2-32, ISO 15184, ISO 2409, SAE J2848 , SAE J1455 Bluetooth 4.1 (Compatible with Bluetooth 4.0 or later) Compatible with iOS 7.1 or Android 4.3 or later NFC • • • • 11 Warning Take note that FOBO Ultra is not meant to function as anti-accident or anti-injury device. FOBO Ultra is not a substitute for safe tire maintenance practices.
12 Regulatory Information Federal Communication Commission Interference Statement This device (FCC ID: PTP-TU1601) complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.
can be achieved if the product can be kept as far as possible from the user body or set the device to lower output power if such function is available. Industry Canada statement: This device (IC: 10617A-TU1601) complies with ISED‟s licence-exempt RSSs. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.
Federal Communication Commission Interference Statement This device (FCC ID: PTP-TU1602) complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules.
Radiation Exposure Statement: This equipment (FCC ID: PTP-TU1602) complies with FCC radiation exposure limits set forth for an uncontrolled environment. This equipment should be installed and operated with minimum distance 20cm between the radiator & your body. Industry Canada statement: This device (IC: 10617A-TU1602) complies with ISED‟s licence-exempt RSSs.
EN 300 328, EN62479, EN 301 489-1&17, EN 60950-1 EU Declaration of Conformity Hereby, Salutica Allied Solutions Sdn. Bhd. declares that this Bluetooth device is in compliance with the essential requirements and other relevant provision of Directive 1999/5/EC. Caution: Changes or modifications to this FOBO device not expressly Approved by the party responsible for compliance could void the user‟s authority to operate it.
13 Intellectual Properties FOBO™ is a trademark of Salutica Allied Solutions Sdn Bhd. All rights reserved. FOBO™ Ultra incorporates a few patent pending technologies solely owned by Salutica Allied Solutions Sdn Bhd. Bluetooth® is a registered trademark owned by Bluetooth SIG Inc. IPhone® is a registered trademark of Apple Inc. 14 Limited Warranty & Disclaimer 14.1 Warranty FOBO Ultra comes with a 12 months limited warranty.
14.2 Disclaimer SALUTICA MAKES NO OTHER EXPRESS WARRANTY WHETHER WRITTEN OR ORAL AND SALUTICA EXPRESSLY DISCLAIMS ALL WARRANTIES AND CONDITIONS NOT STATED IN THIS LIMITED WARRANTY. TO THE EXTENT ALLOWED BY THE LOCAL LAW OF JURISDICTIONS OUTSIDE MALAYSIA, SALUTICA DISCLAIMS ALL IMPLIED WARRANTIES OR CONDITIONS, INCLUDING ANY IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE.
LIABILITY, HOWEVER, WILL NOT APPLY TO CLAIMS FOR PERSONAL INJURY. 14.4 What Law Governs This Warranty THIS LIMITED WARRANTY IS GOVERNED BY AND CONSTRUED UNDER THE LAWS OF MALAYSIA.
