ARS-5110P/5110PX Native SATA Duplicator Controller User's Manual Version: 1.1 Attention: Wait over 5 seconds to power on after shutdown to prevent the abnormal operation of the system. Copyright©2011 ACARD Technology Corp.
Copyright and Trademarks The information of the products in this manual is subject to change without prior notice and does not represent a commitment on the part of the vendor, who assumes no liability or responsibility for any errors that appear in this manual. ACARD and SCSIDE are the trademarks of ACARD Technology Corp. This manual contains materials protected under International Copyright Laws. All rights reserved.
Table of Contents Chapter 1 Introduction ............................................................... 6 1.1 Overview ............................................................................ 6 1.2 Features ............................................................................ 6 1.3 Specifications .................................................................... 6 1.4 System Requirement ......................................................... 6 Chapter 2 Installation .........................
5.1.13 USB Option ................................................................ 18 5.1.14 CD-TEXT ................................................................... 18 5.1.15 Password ................................................................... 18 5.1.16 Disc Counter .............................................................. 19 5.1.17 Auto Save Image ....................................................... 20 5.1.18 Update Drive F/W (For supported drive only) ............ 20 5.1.
WEEE Statement English In order to cope with the increasing waste electrical and electronic equipment, reduce the use of landfill and incinerator, and prevent the harmful matter of waste equipment from entering the environment, the European Union (EU) has set the Directive on Waste Electrical and Electronic Equipment (WEEE) asking manufacturers to collect, recycle and treat waste electrical and electronic equipment properly.
WEEE бюлетень Russian ЧтобЫ с ρaвиться с увеличивающимся ненуҗным электрическим и электронным оборудованием, уменъшите использование закапывания мусора и использования установки для сжигания отходов, препятствуйте вредному выбросам загрязнять окружановки среду, Европейский союз (EC) установил Директиву по Ненужному Электрическому и Электронному Оборудованию (WEEE) для того, чтобы изготовителей собрали, перерабатывали и вообще проявили внимание к ненужному электрическому и злектронному оборудованию должны
ARS-5110P/5110PX Manual Chapter 1 Introduction 1.1 Overview ARS-5110P/5110PX is a standalone duplicator controller supporting high speed SATA BD/DVD/CD writers. With ACARD RISC CPU Engine, it doesn't need connecting to a computer or require much learning. Simply through the LCD and the button on the panel you can use the copy controller to back up data, audio or video BD/DVD/CD quickly. It support SATA BD/DVD/CD drives for recording BD/DVD/CD quickly. It is quite fit for general offices. 1.
ARS-5110P/5110PX Manual Chapter 2 Installation Before installing the ARS-5110P/5110PX, please note that the product is provided in 3 types of packages: Stand-alone Duplicator Controller, Complete Duplication System, Duplication System with no BD/DVD Writer. 2.1 Stand-alone Duplicator Controller Open package to check for any problems. Provide BD/DVD-ROM drive. Provide 10 BD/DVD Writers. Provide a 3.5” SATA HDD (optional). 2.2 Complete Duplication System Open package to check for any problems.
ARS-5110P/5110PX Manual 2.4 Installation Instructions 2.4.1 Installing the ARS-5110P/5110PX The diagram and photo below shows an ARS-5110P/5110PX connected with a DVD-ROM, a SATA HDD and 10 DVD writers.
ARS-5110P/5110PX Manual Chapter 3 Basic Operations 3.1 Buttons and LCD Display The ARS-5110P/5110PX duplicator controller panel features 9 buttons and 1 LCD display. 1. It shows a function or a message. 2. It’s used to scroll up function menus. 3. It’s used to scroll down function menus. 4. It’s used to execute selected function. 5. It’s used to return/cancel/Adv Setting (press and hold for 3 seconds). 6. It's a quick launch to enter "Speed Menu". 7. It's a quick launch to enter "Source Menu". 8.
ARS-5110P/5110PX Manual 3.2.2 Without Internal HDD If the ARS-5110P/5110PX does not have a 3.5" SATA HDD installed, its operating instructions are as follows: Insert a source BD/DVD in the BD/DVD-ROM. Press ▲ or ▼ to select Function#1, “Copy". Insert a blank BD/DVD into the BD/DVD writer then press ENT to being duplication. When duplication is complete, the successfully written BD/DVD will automatically eject. By default, the writer is set to auto eject, but this can be changed.
ARS-5110P/5110PX Manual Chapter 4 PCB Layout The layout of the ARS-5110P/5110PX is shown below.
ARS-5110P/5110PX Manual Chapter 5 Functions There are 13 major functions in the duplicator controller as the following figure shows, and there are subfunctions in Function 13. 1. Copy 2. Test 3. Test & Copy 4. Verify 5. Compare 6. Prescan Duplicator Controller 7. Disc Info 8. Select Source 9. Image 10. Edit Track 11. LightScribe 12. Setup * “13. Adv Setup” is a hidden menu. Press ESC for 2 seconds to enter this function.
ARS-5110P/5110PX Manual In Function#13 there are 22 subfunctions. 13.1 UnderRun Protect 13.2 Overburn 13.3 Read Error Skip 13.4 Format HDD 13.5 Venify HDD 13.6 Burn-in 13.7 Update Firmware 13.8 Compare Firmware 13.9 H/W Diagnostic 13.10 Load Default 13.11 CD+G 13. Adv Setup 13.12 ISRC & MCN 13.13 USB Option * 13.14 CD-TEXT 13.15 Password 13.16 Disc Counter 13.17 Auto Save Image 13.18 Update Drive F/W ^ 13.19 F1 Hotkey Setup 13.20 F2 Hotkey Setup 13.21 Index 13.22 AutoRun Time * This is a special function.
ARS-5110P/5110PX Manual During operation if you don’t understand an LCD message, see Appendix A . Now let’s take ARS5110P to demonstrate. 5.1 Adv Setup Function#13 Adv Setup lets you change the system configuration.
ARS-5110P/5110PX Manual 5.1.4 Format HDD Now press ESC and ▼ to enter the following figure. Format HDD is to partition the hard disk. But after formatting, all data on the hard disk will be deleted. 13-04. Adv Setup Format HDD If your copy controller doesn’t connect with a hard disk, LCD will show the message as follows. No Valid HDD! Select HDD First! If your copy controller is connect with a hard disk, LCD will show the partition size is F_S.
ARS-5110P/5110PX Manual Press ENT to enter the next figure. Test is simply a simulation. And there are Compare and Erase&Copy options can be selected. Burn-in Test Press ENT and use ▲ ▼ to select the time of trayout such as 10sec,30sec,60sec,90sec ...150sec or 180sec. The figure below shows 60sec. Sel Trayout Time 60 sec Press ENT and use ▲ ▼ to select the time of simulation such as 1, 2, 3...1000 or Run Continuous. The figure below shows Run Continuous.
ARS-5110P/5110PX Manual 13-09. Adv Setup H/W Diagnostic Press ENT to enter the next figure, and begin the LCD test. After that, the system will do the button test, self-test of SDRAM, the hardware connection test and flash test. All test results will be shown on LCD. It is the easiest way to know if the system can work well. LCD Test Start When all tests finishes, LCD will show the message as follows Test finished 5.1.10 Load Default Now press ESC and ▼ to enter the following figure.
ARS-5110P/5110PX Manual 5.1.13 USB Option Now press ESC and ▼ to enter the following figure. USB Option lets you switch to the USB mode if your copy controller has connected with a PC. 13-13. Adv Setup USB Option Press ENT to enter the next figure. The default is Off. Press ▼ to select On. USB Option Off When USB option is On, the original “13. Adv Setup” will change to “14. Adv Setup”, and the hidden “13. USB Mode” will appear in the first layer of function menu. 13.USB Mode 5.1.
ARS-5110P/5110PX Manual Use ▲ ▼ to key in the default, 85122290. A password should be composed of 1 to 13 characters. The character can be A, B, C, etc. or 1, 2, 3, etc. or the combination of both. After selecting a desired number or alphabet, remember to press ENT. Old Password 8? After keying in the old password, remember to press ENT to confirm. Then the following figure will appear. New Password ? When it is correct, you will see the following figure. You have 3 chances to enter your password.
ARS-5110P/5110PX Manual Press ▼ to see the following figure. It is to delete the record in job. Use ▲ ▼ to confirm Yes or No. Disc Counter Del Job Counter Press ▼ again to enter the following figure. Dev means the device of DVD writer. Disc Counter Del Dev Counter Press ENT to see the following figure. If you want to delete the record in DVD writer 2, you can press ENT, otherwise press ESC to exit. Del 02 Counter Ent: Del Esc: Exit 5.1.17 Auto Save Image Now press ESC and ▼ to enter the following figure.
ARS-5110P/5110PX Manual Press ▼ could select as 1. Copy, 2. Test, 3. Test&Copy, 4. Verify, 5. Compare, 6. Prescan, 7. Disc Info, 8. Select Source, 9. Image, 10. Edit Track, 11. LightScribe, 12. Setup and 13. Adv Setup. Please press ENT to confirm the selection. 5.1.20 F2 Hot Key Setting Now press ESC and ▼ to enter the following figure. This function let you change the F2 Hot Key function. 13-20. Adv Setup F2 Hot Key Setting Press ENT to enter the next figure. The default is Select Source.
ARS-5110P/5110PX Manual Chapter 6 Troubleshooting 6.1 About LCD After you power up, if there is no display on the LCD, check if the connection of power cord is firm and the environment of power outlet is normal. 6.2 About Error Messages During Copy, Test, Compare and Verify, etc. if you press ESC to abort, an error message will appear on LCD. Abortion may cause the copy controller to hang up,therefore you have to power on again. If reading fails, an error message will appear on LCD.
ARS-5110P/5110PX Manual Appendix A LCD Messages 1. Normal Conditions: All data will be lost, erase?.................All data on the disc will be lost. Confirm the erasing of data. Analyzing.....................................................................................................Analyze the source disc. Audio Disc!!! Can’t compare!................................... The system cannot compare the audio discs. Cannot read TOC......................................................
ARS-5110P/5110PX Manual No Image in Partition xx.......................................................There is no data image in partition xx. No Valid HDD!.......................................................................... The system cannot find a hard disk. Partition Damage.....................................................................................The partition is damaged. Select HD First!.......................................................................
ARS-5110P/5110PX Manual Technical Support Form Email address: support@acard.com Website: http://www.acard.
