COLOR MONITOR AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS SERVICE Manual COLOR MONITOR CONTENTS 1. Precautions 2. Product Specifications 3. Disassembly & Reassembly 4. Alignment & Adjustments 5. Troubleshooting 6. Exploded View & Parts List 7. Electrical Parts List 8. Block Diagram 9. Wiring Diagram 10.
Samsung Electronics Co.,Ltd. 416, Maetan-3Dong, Paldal-Gu, Suwon City, Kyungki-Do, Korea. Printed in Korea P/N : BH68-00456J-00 http://www.samsungmonitor.com (SyncMaster Worldwide) http://www.samsung-monitor.com (SyncMaster USA) http://www.sec.co.
1 Precautions 1-1 Safety Precautions WARNINGS 1. For continued safety, do not attempt to modify the circuit board. 2. Disconnect the AC power before servicing. 3. When the chassis is operating, semiconductor heatsinks are potential shock hazards. 1-1-1 2. Inspect all protective devices such as nonmetallic control knobs, insulating materials, cabinet backs, adjustment and compartment covers or shields, isolation resistor-capacitor networks, mechanical insulators, etc. 3.
1 Precautions 1-2 Servicing Precautions WARNING1: First read the “Safety Precautions” section of this manual. If unforeseen circumstances create conflict between the servicing precautions and safety precautions, always follow the safety precautions. WARNING2: A high voltage VR replaced in the wrong direction may cause excessive X-ray emissions. WARNING3: An electrolytic capacitor installed with the wrong polarity might explode. 1.
2 Product Specifications 2-1 Specifications Description Item Picture Tube: 17-Inch (43 cm): 16-inch (40.6 cm) viewable, 19-Inch (48.2 cm): 18-inch (45.8 cm) viewable, 17”/19”: 0.
2 Product Specifications Table 2-1. Timing Chart Mode IBM VESA 800/85 Hz 1024/75 Hz 1024/85 Hz 1280/75 Hz 1280/85 Hz 1600/75 Hz 1600/85 Hz 1600 x 1200 1600 x 1200 1024 x 768 800 x 600 (17”only ) 1024 x 768 1280 x 1024 1280 x 1024 (19”only ) (AQ19NS only ) VGA2/70Hz VGA3/60Hz 640/85 Hz 720 x 400 640 x 480 640 x 480 fH (kHz) 31.469 31.469 43.269 53.674 60.023 68.677 79.976 91.146 93.750 106.250 A µsec 31.778 31.778 23.111 18.631 16.660 14.561 12.504 10.971 10.667 9.412 B µsec 3.
3 Disassembly and Reassembly This section of the service manual describes the disassembly and reassembly procedures for the AQ17HS/AQ17IS/AQ17NS/AQ19MS/AQ19IS/AQ19NS/AQ19FS monitor. WARNING: This monitor contains electrostatically sensitive devices. Use with caution when handling these components. 3-1 Disassembly Cautions:1. Disconnect the monitor from the power source before disassembly. 2. To remove the Rear Cover, you must use the special opening jig tool. 3-1-1 Before making Disassembly 1.
3 Disassembly and Reassembly 6. Remove the Shield.(TCO 99) 3-1-4 Removing the Main PCB 1. Complete all previous steps. 2. Disconnect the Degaussing Coil at CN601 on the Main PCB. 3. Disconnect all easily accessible ground wires on the PCB and Bottom Chassis. 4. Disconnect the DY connector at the CN401 connector on the Main . 5. Using the jig, release the snaps (2) connecting the Front Cover and the PCB then lift up the Bottom to separate the two Shield. Figure 5 7.
4 Alignment and Adjustments This section of the service manual explains how to make permanent adjustments to the monitor. 4-1 Adjustment Conditions Caution: Changes made without the Softjig are saved only to the user mode settings. As such, the settings are not permanently stored and may be inadvertently deleted by the user. 4-1-1 Before Making Adjustments 4-1-1 (a) ORIENTATION When servicing, always face the monitor to the east.
4 Alignment and Adjustments 4-2 Display Control Adjustments 4-2-1 Centering 4-2-1 (d) VERTICAL POSITION ADJUSTMENT Centering means to position the center point of the display in the middle of the display area. Horizontal size and position and vertical size and position control the centering of the display. CONDITIONS Scanning frequency: 68 kHz/85 Hz Display image: Crosshatch pattern Brightness: Cut-off Contrast: Maximum Click on the << or >> box next to V_POSI to center the vertical image on the raster.
4 Alignment and Adjustments 4-2-2 (b) VERTICAL LINEARITY ADJUSTMENT CONDITIONS Scanning frequency: 68 kHz/85 Hz Display image: Crosshatch pattern Brightness: Cut-off Contrast: Maximum To adjust the Vertical Linearity, refer to Table 4-1 for the tolerance range. Use control bar after selecting “V_LINEARITY BAL” in left menu to optimize the image.
4 Alignment and Adjustments 4-3 Color Adjustments 4-3-1 Color Coordinates (Temperature) Color temperature is a measurement of the radiant energy transmitted by a color. For computer monitors, the color temperature refers to the radiant energy transmitted by white. Color coordinates are the X and Y coordinates on the chromaticity diagram of wavelengths for the visible spectrum.
4 Alignment and Adjustments Luminance Table (9300K) 4-3 4-3-3 (b) G-GAIN ADJUSTMENT This procedure is the same as that for 9300K, refer to the procedure on page 4-5. 17HS/IS/NS 19MS/NS/FS 19IS Without ABL 40ft-L 36ft-L 36ft-L Without ABL 31ft-L 30ft-L 30ft-L You must adjust the Brightness of Green gain to 39 ± 1ft-L.
4 Alignment and Adjustments CONDITIONS Scanning frequency: Display image: Brightness: Contrast: 68 kHz/85 Hz Full white pattern Cut-off Maximum 1. Click on the << or >> boxes next to R_GAIN and B_GAIN to make the video white. (For 5000K color adjustment: x = 0.346 ± 0.02, y = 0.359 ± 0.02.) 2. Refer to the procedure for 9300K, section 4-3-2 (c) steps 2 and 3. Luminance Table (6000K) 4-5 17HS/IS/NS 19NS/FS/IS Without ABL 38ft-L 33ft-L With ABL 30ft-L 28ft-L PROCEDURE 1.
5 Troubleshooting 5-1 Parts Level Troubleshooting Notes: 1. If a picture does not appear, Click the Brightness and Contrast button on the front panel, and then increase the value of Brightness and Contrast. 2. Check the following circuits. • No raster appears: Power circuit, Horizontal output circuit, H/V control circuit, and H/V output circuit. • High voltage develops but no raster appears: Video output circuits. • High voltage does not develop: Horizontal output circuits.
5 Troubleshooting 5-1-2 PFC Failure Check the Voltage at IC701 Pin5. The Voltage is around 10VDC? No Check and Replace D702, R711, ZD705, ZD706. WAVEFORMS 1 368 V (IC601, #1) Yes 1 Q701 Gate waveform is right? No Replace IC701. Yes Check the Voltage at D701 cathode. The Voltage is about 400VDC? No Replace Q701, D701. Yes Done. 5-1-3 DPMS Failure Check signal source H/V sync. video signal. Make No H/V sync. ( That is power off mode).
5 Troubleshooting 5-1-4 H_Deflection Failure 2 IC402 Pin 6 waveform is right? No 1. Appear the Voltage 12VDC at IC402 Pin 7 replace R451. 2. Check IC402 Pins 6~5, 7~6. 3. Replace IC402. Yes Q454 drain waveform is right? 3 No Check Q451, Q452, Q453, ZD450, R467, D456. No Check Q250, Q251, IC250 Check +19V line. No Check and replace D402 and Q402. Check DY connector connection.
5 Troubleshooting 5-1-5 S Correction Failure Check S1 ~ S5 signal. Refer to the S-corrction table page? S1~S5 signals are right at each frequency block? No Check and replace IC201. Yes Check and replace C411, C413, C414, C415, C416, C417, C418, Q403 ~ Q407, Q408 ~ Q412 5-1-6 H_Lin. Failure IC201 Pin 3 voltage varies with different H_Lin. DAC values? No Replace IC201. Yes IC403 Pin 7, 8 voltage varies with different H_Lin. DAC values? No Check +12 V line. Check some parts around IC403.
5 Troubleshooting 5-1-8 Abnormal H_Size WAVEFORMS 7 The Voltage waveforms at Q402 Collector are right? No Repeat the troubleshooting Guide of H_deflection failure. 7 Q402, Collector Yes 8 T402 pin 8 wareform is right? No Replace T402. Yes 8 T402, #8 Check some parts around IC250 and IC402 Pin 1 and 2. 5-1-9 Side Pin or Trap Failure 9 IC250 Pin 24 output exists? The waveform is right? No Check and replace IC250. Yes Check and replace IC402. Check some parts IC402 Pin 2 and IC250 Pin 24.
5 Troubleshooting 5-1-11 Tilt Failure Check tilt connector connection IC201 Pin 5 output duty varies with different DAC values? No Check and replace IC201. Yes IC403 Pin 10, 11 output varies with different DAC values? No Check and replace IC403. Yes Check and replace CRT. 5-1-12 V Deflection Failure Is 14V at IC301 Pin 2? Is -14V at IS301 Pin 5? No Check and replace R312, R316. Refer to 5-1-1 No Power supply.
5 Troubleshooting 5-1-13 V Size or Pos. Variation Failure IC250 Pin 23 output varies with different DAC values? No Check some parts around IC250. Check bias voltage. No Check +12 V line. Check and replace Q502, Q503, R511, IC501. Yes Check and replace IC250 and IC301.
5 Troubleshooting 5-1-15 ABL Failure Input full white pattern to monitor. IC102 Pin12 (19”: IC101, Pin15) input exists and varies with different patterns? Yes Check and replace IC102 (19”:IC101). No Check CN102, Q101, Q102, ZD101. T501 Pin 8 Voltage exists? No Check and replace T501. Yes IC103 Pin 16 output exists and varies with different patterns? No Check and replace IC103.
5 Troubleshooting 5-1-17 No Video WAVEFORMS Check signal cable and connection. 15 CRT Socket, Red, Green, Blue IC101 Pins 2, 4 and 6 (19”: IC105, Pins 2, 4 and 6) inputs are right? No Check CN101, IC1, QR51, QG51, QB51, and IC3 on BNC Board. No Check Vcc on IC101 (19”: IC105) and replace IC101 (19”: IC105). No Check +12 V line. Check and replace IC102 (19”: IC101).
5 Troubleshooting 5-1-18 Micom Failure IC201 Pin 13 input is over 4.2V? No WAVEFORMS Check IC650. 16 3.42 V (IC201, #33) Yes 16 17 IC201 Pin 32 and 33 inputs are right? No Check X201, C203 and C204. Yes CH1 P-P = 3.42 V CH1 RMS = 2.500V IC201 Pin 40 input is High Active? No Check and replace IC202. 17 3.16 V (IC201, #32) Yes All in/output values are right? Yes No Replace IC201. CH1 P-P = 3.16 V CH1 RMS = 2.560 V Done.
5 Troubleshooting 5-1-19 OSD Failure WAVEFORMS Check CN102 and connector Ass’y. 18 IC103, #6, 17 IC103 (19”: IC03) Pin 6 and 17 18 19 waveforms are right? Is there 5V on IC103 Pin 5 and 24? No Check and replace Q104, IC201 Pin 20. Check 5V Line. Yes IC102 Pins 1, 2 and 3, 4 (19”: IC101 Pins 1, 4 and 9, 13) input is right? No Check and replace IC103 (19”:IC103). 19 IC103, #5, 24 Yes Does the Voltage Change on IC201 Pins 11, 12 When you push the control Button? No Check CN204 and Assy.
5 Troubleshooting 5-1-20 User Control Failure Check connector Ass’y. IC201 Pins 11 and 12 inputs are right at each function? No Check and replace function key. Yes Check and replace IC201. Done. 5-1-21 Degaussing Failure Check degaussing connector. RL601 operation is right? Yes Check D-Coil, POS601. No Q601 base input is right? Yes Check and replace Q601. No IC201 Pin 31 output is right? No Check and replace IC201. Check user function key. Yes Done.
5 Troubleshooting 5-2 General Troubleshooting 5-2-1 No Picture LED blinks? Yes Go to 5-2-2 Shut down troubleshooting guide. WAVEFORMS 20 R, G, B, Video No G2 Voltage is right? No Check D598, D599 and G2 wire. Also check around FBT circuits. Yes Heater Voltage is right? No Check CN201 Assy and D642, Q672. Yes 20 R, G, B Cathode is right? No Return back the No Video (5-1-16) troubleshooting guide. Yes Check SDA (IC201 Pin 30) and SCL (IC201 Pin 29) Replace IC280, IC201.
5 Troubleshooting 5-2-3 Missing Color Proper Video levels are on CN101 Pin 1, 3 and 5. No Check signal generator and replace BNC Board. Yes Proper AC voltage are on all cathodes? No Refer to 5-1-16 No Video. Yes Proper DC voltage are on all cathodes? No Check IC105 (19”: IC102) Pin 1, 3 and 5. Check and replace IC105 (19”: IC102) and IC104 (19”: IC104). Yes G2 voltage is right? No Check D598, D599 and G2 wire. Check around FBT circuits also. Yes Change the CRT. Done.
5 Troubleshooting 5-2-4 Visible Retrace Check white balance adjustment. G2 voltage is right? No Check G2 control volume and FBT. Yes Blank pulse is on Pin 23 of IC102 (19”: Pin 27 of IC101) on Video board? No Check CN102, Q104 (19”: Q103). Yes Blank pedestal is on Pin 25, 28 and 30 of IC102 (19”: 29, 32 and 35 of IC101)? No Check IC102 (19”: IC101) and related components. No Check Q301, CN102 Assy, Q520, D520, and D521. Yes Is V_FLB and DC_bias on G1 Pin at CRT socket? Yes Done.
5 Troubleshooting 5-2-5 Unsynchronized Image Compare input sync. of IC201 Pin 18 and 19 with output sync. of IC201 20 and 21. Are they all right? No Check and replace IC201. Yes Are H_Out and V_Out of IC250 Pin 23 and 26 right? No Check and replace IC250. Yes Are H_FLYBACK of IC102 Pin 23 (19”: IC101 Pin 27) right? No Check CN102 Assy and Q103. Yes Check clamp pulse of IC102 Pin 22 (19”: IC101 Pin 19) replace IC201 and Q107. Done.
5 Troubleshooting 5-2-6 Misconvergence Are the C/G control circuits in the video Board? (AQ17NS, AQ17NS, AQ19FS have the C/G control circuits in the video Board) No Try readjusting convergence. Check the C/G control Assy (CN181). The convergence is now within spec.? Proper voltage are appeared on IC181 Pin 7, 8, 10, and 11 in Video Board. No Yes Yes Change CRT and readjust convergence. Change CRT and readjust convergence. No Check and replace IC181. No Done. Done.
5 Troubleshooting 5-2-7 Poor Focus Adjust focus VR. Improved focus? Yes Aging monitor and check for focus change. No Refer to 5-1-15 Dynamic Focus Failure. No Check focus leads from FBT to CRT Socket. Check the CRT Socket. Dynamic focus circuit is right? Yes Replace the CRT and verify focus. 5-2-8 Purity Failure Degaussing Purity is right? Yes Done. No Degaussing circuit is right? No Refer to 5-1-20 Degaussing Failure. Yes Replace CRT and verify purity.
5 Troubleshooting 5-2-9 No Operating High Light Zone WAVEFORMS Change the video signal to windows pattern. 21 IC101, #14, 15 Does not the High Light Zone appear? No Done. Yes 21 22 Are the waveforms right on IC101 Pin 14 and 15 (19”:IC105 Pin 14 and 15). No Check connection Assy (CN102). 22 IC105, #14, 15 Yes 23 Is the waveform right on IC101 Pin 18 (19”: IC105 Pin 18). No Check and replace IC103 (19”: IC103). Yes Check and replace IC105 (19”: IC101) 23 IC105, #18 Yes Done.
5 Troubleshooting Memo 5-20 AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS
6 Exploded View and Parts List 6-1 AQ17HS & AQ17IS AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS 6-1
6 Exploded View & Parts List 6-2 AQ17NS 6-2 AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS
6 Exploded View & Parts List 6-3 AQ19MS AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS 6-3
6 Exploded View & Parts List 6-4 AQ19IS 6-4 AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS
6 Exploded View & Parts List 6-5 AQ19NS AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS 6-5
6 Exploded View & Parts List 6-6 AQ19FS 6-6 AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS
0 7 Electrical Parts List 7-1-1 AQ17** Main PCB Parts Loc. No. C416 C602 C607 C701 CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CN201 CN201_ASSY CN202 CN204 CN205 CN205_ASSY CN211 CN211+CN212 CN212 CN401 CORE_FBT D402 D505 D507 D601 D647 EY599 FG601 HS301 HS402_1 HS504 IC201 IC201_SOCKET IC250 IC403 IC620 JW01 L402 L403 L503 L601 L701 Code No.
7 Electrical Parts List Loc. No. LC601 M/PCB+SH/BTM OP1 POS601 Q401 Q407 R400 R407 R516 R608 RL601 SH/BNC+SH/BTM SH/LMF+SH/BTM SW1 T401 T402 T501 T502 T601 T620 T701 TH601 VR401 BD201 BD280 BD401 BD532 BD602 BD603 BD604 BD651 BD652 BD653 C201 C202 C203 C204 C208 C209 C210 C211 C212 C213 C214 C216 C220 C250 C251 C252 C253 C254 C255 C256 7-2 Code No.
7 Electrical Parts List Loc. No. C257 C258 C259 C260 C264 C265 C266 C268 C269 C270 C271 C280 C281 C283 C284 C285 C301 C302 C303 C304 C305 C306 C307 C308 C309 C310 C312 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C417 C418 C433 C440 C450 C451 C452 C453 C454 C456 C457 Code No.
7 Electrical Parts List Loc. No. C458 C459 C460 C461 C462 C463 C464 C465 C466 C467 C468 C501 C502 C503 C504 C505 C506 C507 C508 C509 C510 C511 C512 C513 C514 C516 C520 C530 C531 C532 C533 C535 C536 C540 C550 C551 C552 C559 C562 C598 C599 C603 C604 C605 C608 C609 C610 C611 C612 C613 C614 C620 C621 7-4 Code No.
7 Electrical Parts List Loc. No. C622 C624 C625 C627 C628 C629 C641 C642 C643 C644 C645 C646 C649 C650 C651 C652 C653 C654 C655 C656 C702 C703 C705 C706 C708 C710 CIS CIS CIS CN209 CN210 CN409 CN414 CN415 CN420 CN421 CN601 CN602 CN603 CN608 CN609 D201 D202 D250 D251 D254 D282 D301 D302 D303 D401 D405 D406 Code No.
7 Electrical Parts List Loc. No. D407 D408 D450 D451 D452 D453 D454 D456 D478 D501 D503 D504 D508 D509 D510 D520 D521 D522 D523 D530 D532 D540 D551 D552 D553 D561 D598 D599 D602 D604 D605 D606 D620 D621 D640 D642 D644 D646 D650 D670 D702 D703 D704 EY301 EY302 EY401 EY402 EY403 EY404 EY405 EY408 EY409 EY410 7-6 Code No.
7 Electrical Parts List Loc. No. EY411 EY412 EY413 EY415 EY420 EY440 EY441 EY501 EY502 EY503 EY504 EY505 EY506 EY507 EY508 EY509 EY510 EY511 EY512 EY550 EY599 EY6 EY601 EY602 EY603 EY604 EY607 EY608 EY609 EY61 EY610 EY611 EY612 EY613 EY614 EY615 EY616 EY703 EY704 EY705 FH601 IC202 IC280 IC402 IC501 IC621 IC701 JP104 JP106 JP113 JP114 JP116 JP150 Code No.
7 Electrical Parts List Loc. No. JP151 JP153 JP154 JP157 JP158 JP159 JP167 JP178 JP184 JP186 JP187 JP189 JP190 JP191 JP192 JP193 JP194 JP197 JP198 JP204 JP210 JP212 JP213 JP216 JP227 JP239 JP245 JP266 JP267 JP268 JP269 JP275 JP276 JP289 JP294 JP295 JP297 JP302 JP303 JP307 JP308 JP323 JP324 JP327 JP328 JP334 JP335 JP337 JP340 JP344 JP346 JP361 7-8 Code No.
7 Electrical Parts List Loc. No. JP362 JP363 JP364 JP365 JP371 JP372 JP374 JP375 JP376 JP377 JP378 JP379 JP381 JP383 JP390 JP397 JP399 JP402 JP404 JP412 JP415 JP416 JP417 JP418 JP419 JP421 JP425 JP439 JP440 JP441 JP442 JP451 JP453 JP454 JP455 JP460 JP475 JP480 JP481 JP483 JP486 JP487 JP491 JP511 JP516 JP522 JP546 JP547 JP548 JP549 JP569 JP572 JP574 Code No.
7 Electrical Parts List Loc. No. JP578 JP579 JP581 JP585 JP586 JP587 JP588 JP589 JP590 JP591 JP596 JP597 JP598 JP603 JP609 JP615 JP616 JP617 JP619 JP623 JP626 JP629 JP630 JP632 JP633 JP635 JP637 JP638 JP640 JP643 JP644 JP645 JP646 JP647 JP648 JP649 JP650 JP651 JP652 JP653 JP654 JP655 JP656 JP657 JP659 JP660 JP661 JP662 JP663 JP664 JP665 JP666 JP675 7-10 Code No.
7 Electrical Parts List Loc. No. JP678 JP679 JP680 JP681 JP682 JP683 JP684 JP685 JP686 JP687 JP688 JP690 JP692 JP694 JP695 JP696 JP697 JP698 JP699 JP700 JP701 JP702 JP703 L501 L502 MP1.0 Q250 Q251 Q301 Q408 Q409 Q410 Q411 Q412 Q450 Q451 Q452 Q453 Q502 Q503 Q520 Q521 Q540 Q541 Q553 Q601 Q620 Q670 Q671 Q672 R200 R203 R204 Code No.
7 Electrical Parts List Loc. No. R205 R206 R207 R208 R209 R210 R211 R215 R216 R218 R219 R220 R221 R222 R225 R226 R227 R228 R229 R230 R231 R233 R236 R237 R238 R239 R240 R242 R243 R250 R251 R252 R253 R254 R255 R256 R261 R264 R265 R266 R267 R268 R269 R270 R271 R272 R278 R280 R281 R282 R283 R284 R301 7-12 Code No.
7 Electrical Parts List Loc. No. R302 R303 R304 R305 R306 R307 R308 R309 R310 R311 R312 R313 R314 R315 R316 R402 R403 R404 R405 R406 R408 R409 R410 R412 R413 R414 R420 R421 R422 R423 R424 R425 R426 R427 R428 R429 R430 R431 R432 R433 R434 R435 R440 R441 R444 R450 R451 R452 R453 R454 R455 R456 R459 Code No.
7 Electrical Parts List Loc. No. R460 R461 R462 R463 R464 R465 R466 R467 R468 R490 R501 R502 R503 R504 R505 R506 R507 R508 R509 R510 R511 R512 R515 R520 R521 R522 R523 R524 R525 R526 R527 R531 R532 R541 R542 R543 R545 R546 R547 R550 R551 R552 R553 R555 R556 R557 R558 R560 R561 R563 R564 R565 R567 7-14 Code No.
7 Electrical Parts List Loc. No. R596 R597 R598 R599 R601 R602 R603 R604 R605 R606 R607 R609 R620 R621 R622 R623 R624 R625 R626 R627 R628 R629 R630 R631 R640 R644 R649 R651 R655 R656 R668 R670 R671 R672 R673 R674 R675 R676 R677 R688 R701 R702 R703 R704 R705 R706 R711 R712 R721 SK530 TCO X201 ZD201 Code No.
7 Electrical Parts List Loc. No. Code No. Description Specification Remarks ZD286 ZD450 ZD520 ZD601 ZD705 ZD706 0403-000361 0403-000004 0403-001068 0403-000753 0403-000004 0403-000538 DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-ZENER UZ6.2BSB,6.2V,5.99-6.24V,500mW UZ12BM,12V,11.6-12.4V,500mW,DO UZ4.7BSA,4.7V,4.47-4.65V,500mW MTZJ27D,27V,26.29-27.64V,500mW UZ12BM,12V,11.6-12.4V,500mW,DO MTZ16C,16V,15.69-16.
7 Electrical Parts List Loc. No. Code No. Description Specification Remarks CIS BH62-00051A HEAT SINK-V IC AQ17,SPC-1,T1.0,H60,L13,-,-,- SNA HS509 CIS CIS CIS CIS CIS BH99-00045B 0205-001027 0502-000351 6006-001008 6021-000118 BH62-00051A ASSY HEAT/SINK OIL-SILICON TR-POWER SCREW-ASS’Y MACH NUT-HEXAGON HEAT SINK-V IC HS,SCREW+NUT,TIP30C,-,-,OIL SILICON G746,-,TIP30,PNP,2W,TO-220AB,-,15-75 WSP,BH,+,M3,L10,ZPC(YEL),SWRCH 1C,M3,ZPC(YEL),SM20C AQ17,SPC-1,T1.
7 Electrical Parts List 7-1-2 AQ17** Video PCB Parts Loc. No. CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CN101 CN102 HS102 IC102 SH/VID SH/VID+H/S SK105 BD103 BD104 BD105 BD108 BD109 BD111 C103 C104 C112 C113 C114 C115 C116 C117 C118 C120 C121 C122 C124 C125 C126 C127 C135 C137 C139 C140 C141 C142 C143 CB04 7-18 Code No.
7 Electrical Parts List Loc. No. CB06 CG04 CG06 CIS CIS CN12 CN13 CN14 CR04 CR06 D101 DB01 DB02 DB03 DB04 DB05 DG01 DG02 DG03 DG04 DG05 DR01 DR02 DR03 DR04 DR05 EY1 EY2 EY5 EY6 EY7 EY8 IC104 JP1 JP100 JP101 JP102 JP103 JP104 JP11 JP12 JP13 JP17 JP18 JP19 JP20 JP21 JP22 JP23 JP24 JP27 JP29 JP32 Code No.
7 Electrical Parts List Loc. No. JP36 JP37 JP4 JP44 JP49 JP5 JP50 JP51 JP53 JP54 JP55 JP57 JP6 JP60 JP61 JP62 JP63 JP64 JP65 JP66 JP67 JP68 JP7 JP70 JP74 JP75 JP8 JP82 JP86 JP87 JP88 JP89 JP9 JP90 JP91 JP92 JP93 JP94 JP95 JP96 JP97 JP98 JP99 L100 L101 L103 L104 L106 LB01 LG01 LR01 MP1.0 Q101 7-20 Code No.
7 Electrical Parts List Loc. No. Q102 Q103 Q104 Q105 Q106 R104 R106 R107 R108 R109 R110 R127 RB07 RB09 RB12 RG07 RG09 RG12 RR07 RR09 RR12 SK101 SK102 SK103 SK104 SK108 ZD101 ZD103 C100 C101 C102 C105 C106 C107 C108 C109 C110 C111 C119 C123 C128 C129 C130 C131 C134 C136 CB01 CB02 CB03 CG01 CG02 CG03 CR01 Code No.
7 Electrical Parts List Loc. No. CR02 CR03 IC101 IC103 L102 L105 L107 R101 R102 R103 R105 R111 R112 R113 R114 R116 R117 R118 R119 R120 R121 R122 R124 R125 R126 R128 R129 R130 R131 R132 R133 R134 R135 R136 R139 R140 R141 R142 R143 R144 R151 R152 R153 RB01 RB02 RB03 RB04 RB05 RB06 RB08 RB11 RG01 RG02 7-22 Code No.
7 Electrical Parts List Loc. No. Code No.
7 Electrical Parts List 7-2-1 AQ19** Main PCB Parts Loc. No. C416 C602 C607 C701 CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CN201 CN201_ASSY CN202 CN204 CN205 CN205_ASSY CN211 CN211+CN212 CN212 CN401 CN409 CORE_FBT D402 D505 D507 D601 D647 EY599 FG601 HS301 HS402_1 HS504 IC201 IC201_SOCKET IC250 IC403 IC620 JW01 L402 L403 L503 L601 L701 LC601 7-24 Code No.
7 Electrical Parts List Loc. No. M/PCB OP1 POS601 Q401 Q407 R400 R407 R516 R608 RL601 SH/BNC+SH/BTM SH/BTM+M/PCB SH/LMF+B/BTM SW1 T401 T402 T501 T502 T601 T620 T701 TH601 VR401 BD201 BD280 BD401 BD532 BD602 BD603 BD604 BD651 BD652 BD653 C201 C202 C203 C204 C208 C209 C210 C211 C212 C213 C214 C216 C220 C250 C251 C252 C253 C254 C255 C256 Code No.
7 Electrical Parts List Loc. No. C257 C258 C259 C260 C264 C265 C266 C268 C269 C270 C271 C280 C281 C283 C284 C285 C301 C302 C303 C304 C305 C306 C307 C308 C309 C310 C312 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C417 C418 C433 C440 C450 C451 C452 C453 C454 C456 C457 7-26 Code No.
7 Electrical Parts List Loc. No. C458 C459 C460 C461 C462 C463 C464 C465 C466 C467 C468 C501 C502 C503 C504 C505 C506 C507 C508 C509 C510 C511 C512 C513 C514 C516 C520 C530 C531 C532 C533 C535 C536 C540 C550 C551 C552 C559 C562 C598 C599 C603 C604 C605 C608 C609 C610 C611 C612 C613 C614 C620 C621 Code No.
7 Electrical Parts List Loc. No. C622 C624 C625 C627 C628 C629 C641 C642 C643 C644 C645 C646 C649 C650 C651 C652 C653 C654 C655 C656 C702 C703 C705 C706 C708 C710 CIS CIS CIS CN209 CN210 CN414 CN415 CN420 CN421 CN601 CN602 CN603 CN608 CN609 D201 D202 D250 D251 D254 D282 D301 D302 D303 D401 D405 D406 D407 7-28 Code No.
7 Electrical Parts List Loc. No. D408 D450 D451 D452 D453 D454 D456 D478 D501 D503 D504 D508 D509 D510 D520 D521 D522 D523 D530 D532 D540 D551 D552 D553 D561 D598 D599 D602 D604 D605 D606 D620 D621 D640 D642 D644 D646 D650 D670 D702 D703 D704 EY301 EY302 EY401 EY402 EY403 EY404 EY405 EY408 EY409 EY410 EY411 Code No.
7 Electrical Parts List Loc. No. EY412 EY413 EY415 EY420 EY440 EY441 EY501 EY502 EY503 EY504 EY505 EY506 EY507 EY508 EY509 EY510 EY511 EY512 EY550 EY599 EY6 EY601 EY602 EY603 EY604 EY607 EY608 EY609 EY61 EY610 EY611 EY612 EY613 EY614 EY615 EY616 EY703 EY704 EY705 FH601 IC202 IC280 IC402 IC501 IC621 IC701 JP104 JP106 JP113 JP114 JP116 JP150 JP151 7-30 Code No.
7 Electrical Parts List Loc. No. JP153 JP154 JP157 JP158 JP159 JP167 JP178 JP184 JP186 JP187 JP189 JP190 JP191 JP192 JP193 JP194 JP197 JP198 JP204 JP210 JP212 JP213 JP216 JP227 JP239 JP245 JP266 JP267 JP268 JP269 JP275 JP276 JP289 JP294 JP295 JP297 JP302 JP303 JP307 JP308 JP323 JP324 JP327 JP328 JP334 JP335 JP337 JP340 JP344 JP346 JP361 JP362 JP363 Code No.
7 Electrical Parts List Loc. No. JP364 JP365 JP371 JP372 JP374 JP375 JP376 JP377 JP378 JP379 JP381 JP383 JP390 JP397 JP399 JP402 JP404 JP412 JP415 JP416 JP417 JP418 JP419 JP421 JP425 JP439 JP440 JP441 JP442 JP451 JP453 JP454 JP455 JP460 JP475 JP480 JP481 JP483 JP486 JP487 JP491 JP511 JP516 JP522 JP546 JP547 JP548 JP549 JP569 JP572 JP574 JP578 JP579 7-32 Code No.
7 Electrical Parts List Loc. No. JP581 JP585 JP586 JP587 JP588 JP589 JP590 JP591 JP596 JP597 JP598 JP603 JP609 JP615 JP616 JP617 JP619 JP623 JP626 JP629 JP630 JP632 JP633 JP635 JP637 JP638 JP640 JP643 JP644 JP645 JP646 JP647 JP648 JP649 JP650 JP651 JP652 JP653 JP654 JP655 JP656 JP657 JP659 JP660 JP661 JP662 JP663 JP664 JP665 JP666 JP675 JP678 JP679 Code No.
7 Electrical Parts List Loc. No. JP680 JP681 JP682 JP683 JP684 JP685 JP686 JP687 JP688 JP690 JP692 JP694 JP695 JP696 JP697 JP698 JP699 JP700 JP701 JP702 JP703 L501 L502 MP1.0 Q250 Q251 Q301 Q408 Q409 Q410 Q411 Q412 Q450 Q451 Q452 Q453 Q502 Q503 Q520 Q521 Q540 Q541 Q553 Q601 Q620 Q670 Q671 Q672 R200 R203 R204 R205 R206 7-34 Code No.
7 Electrical Parts List Loc. No. R207 R208 R209 R210 R211 R215 R216 R218 R219 R220 R221 R222 R225 R226 R227 R228 R229 R230 R231 R233 R236 R237 R238 R239 R240 R242 R243 R250 R251 R252 R253 R254 R255 R256 R261 R264 R265 R266 R267 R268 R269 R270 R271 R272 R278 R280 R281 R282 R283 R284 R301 R302 R303 Code No.
7 Electrical Parts List Loc. No. R304 R305 R306 R307 R308 R309 R310 R311 R312 R313 R314 R315 R316 R402 R403 R404 R405 R406 R408 R409 R410 R412 R413 R414 R420 R421 R422 R423 R424 R425 R426 R427 R428 R429 R430 R431 R432 R433 R434 R435 R440 R441 R444 R450 R451 R452 R453 R454 R455 R456 R459 R460 R461 7-36 Code No.
7 Electrical Parts List Loc. No. R462 R463 R464 R465 R466 R467 R468 R490 R501 R502 R503 R504 R505 R506 R507 R508 R509 R510 R511 R512 R515 R520 R521 R522 R523 R524 R525 R526 R527 R531 R532 R541 R542 R543 R545 R546 R547 R550 R551 R552 R553 R555 R556 R557 R558 R560 R561 R563 R564 R565 R567 R596 R597 Code No.
7 Electrical Parts List Loc. No. R598 R599 R601 R602 R603 R604 R605 R606 R607 R609 R620 R621 R622 R623 R624 R625 R626 R627 R628 R629 R630 R631 R640 R644 R649 R651 R655 R656 R668 R670 R671 R672 R673 R674 R675 R676 R677 R688 R701 R702 R703 R704 R705 R706 R711 R712 R721 SK530 TCO X201 ZD201 ZD286 ZD450 7-38 Code No.
7 Electrical Parts List Loc. No. Code No. Description Specification Remarks ZD520 ZD601 ZD705 ZD706 0403-001068 0403-000753 0403-000004 0403-000538 DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-ZENER UZ4.7BSA,4.7V,4.47-4.65V,500mW MTZJ27D,27V,26.29-27.64V,500mW UZ12BM,12V,11.6-12.4V,500mW,DO MTZ16C,16V,15.69-16.51V,500mW, HS301 CIS CIS CIS CIS CIS BH99-00002G 0205-001027 1204-001508 6006-001097 6021-000118 BH62-00047A ASSY HEAT/SINK OIL-SILICON IC-VERTICAL DEF.
7 Electrical Parts List Loc. No. Code No. Description Specification Remarks HS509 CIS CIS CIS CIS CIS BH99-00045B 0205-001027 0502-000351 6006-001008 6021-000118 BH62-00051A ASSY HEAT/SINK OIL-SILICON TR-POWER SCREW-ASS’Y MACH NUT-HEXAGON HEAT SINK-V IC HS,SCREW+NUT,TIP30C,-,-,OIL SILICON G746,-,TIP30,PNP,2W,TO-220AB,-,15-75 WSP,BH,+,M3,L10,ZPC(YEL),SWRCH 1C,M3,ZPC(YEL),SM20C AQ17,SPC-1,T1.
7 Electrical Parts List 7-2-2 AQ19** Video PCB Parts Loc. No. CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CLAMP CN101 CN102 HS3 IC101 SH/VID SH/VID+H/S SK105 BD104 C102 C103 C105 C106 C107 C109 C118 C119 C120 C122 C123 C127 C154 C158 C161 C166 C171 C172 C182 C182_1 C186 C187 C188 C189 CB01 CB03 CB21 CG01 CG03 CG21 Code No.
7 Electrical Parts List Loc. No. CR01 CR03 CR21 D104 DB01 DB05 DG01 DG05 DR01 DR05 IC103 IC105 L103 L104 L105 L106 R101 R102 R103 R105 R106 R107 R108 R111 R112 R113 R115 R118 R119 R120 R124 R125 R151 R152 R153 R157 R158 R161 R162 R164 R165 R175 R176 R177 R178 R180 R188 R189 R190 R191 R193 R194 R196 7-42 Code No.
7 Electrical Parts List Loc. No. R197 R198 R199 RB01 RB02 RB04 RB05 RB06 RB09 RB18 RB26 RB31 RG01 RG02 RG04 RG05 RG06 RG09 RG18 RG26 RG31 RR01 RR02 RR04 RR05 RR06 RR09 RR31 BD101 BD102 BD103 BD105 BD106 BD152 BD155 BD181 BD182 C101 C104 C108 C110 C111 C112 C113 C114 C115 C116 C117 C124 C125 C126 C153 C155 Code No.
7 Electrical Parts List Loc. No. C156 C157 C167 C180 C181 C183 CB14 CB16 CB20 CG02 CG14 CG16 CG20 CIS CIS CIS CN12 CN13 CN14 CR02 CR14 CR16 CR20 D105 DB03 DB04 DG03 DG04 DR03 DR04 EY1 EY2 EY3 EY5 EY7 EY8 IC104 JP102 JP105 JP124 JP133 JP134 JP135 JP136 JP137 JP138 JP139 JP140 JP141 JP142 JP143 JP144 JP145 7-44 Code No.
7 Electrical Parts List Loc. No. JP146 JP147 JP148 JP149 JP173 JP182 JP188 JP200 JP218 JP220 JP222 JP223 JP224 JP225 JP226 JP228 JP230 JP235 JP238 JP242 JP247 JP252 JP254 JP263 JP265 JP277 JP283 JP291 JP298 JP305 JP306 JP309 JP310 JP312 JP313 JP314 JP317 JP318 JP321 JP326 JP329 JP330 JP331 JP332 JP333 JP336 JP339 JP341 JP343 JP345 JP347 JP348 L101 Code No.
7 Electrical Parts List Loc. No. Code No. Description Specification Remarks L102 L107 LB03 LG03 LR03 MP1.
7 Electrical Parts List 7-3 BNC PCB Parts Loc. No. CIS CIS CIS CIS CIS CIS CIS CIS CN103 CN104 CN105 IC1 UPSTREAM BD150 BD151 C132 C133 C151 C152 C159 C160 C95 C96 C97 C98 CB51 CB52 CB53 CG51 CG52 CG53 CIS CIS CR51 CR52 CR53 DB51 DB52 DB53 DB54 DG51 DG52 DG53 DG54 DR51 DR52 DR53 DR54 EY101 EY102 EY103 EY104 EY105 Code No.
7 Electrical Parts List Loc. No. IC3 JP107 JP108 JP109 JP110 JP111 JP112 JP115 JP117 JP118 JP119 JP120 JP121 JP122 JP123 JP125 JP126 JP127 JP128 JP131 JP132 JP160 JP161 JP162 JP163 JP164 JP165 JP166 JP168 JP170 JP171 MP1.0 QB52 QG52 QR52 R100 R137 R154 R155 R159 R160 R95 R96 R97 R98 R99 RB51 RB52 RB53 RB54 RB55 RG51 RG52 7-48 Code No.
7 Electrical Parts List Loc. No. RG53 RG54 RG55 RR51 RR52 RR53 RR54 RR55 ZD151 ZD152 ZD153 ZD154 ZD155 ZD156 ZD157 ZD158 ZD159 ZD160 ZD161 Code No.
7 Electrical Parts List 7-4 Purity Assy PCB Parts (AQ19NS) Loc. No. CIS CIS CIS CIS CIS CN801 CN802 CN803 CN807 CN882 IC801 IC801_SOCK IC803 IC804 P/U-PCB+B/CG PU/PCB TH801 C801 C802 C803 C804 C809 C811 C812 C813 C814 C815 C816 C818 C819 C820 C821 C822 C823 C824 C825 C826 C830 C831 C832 C833 C834 C835 C836 C837 C838 C839 C840 C841 C842 C843 C844 C845 7-50 Code No.
7 Electrical Parts List Loc. No. CIS CIS D801 D803 D804 IC805 JP11 JP12 JP14 JP15 JP16 JP17 JP20 JP21 JP22 JP24 JP25 JP26 JP27 JP28 JP3 JP30 JP31 JP32 JP34 JP35 JP39 JP8 MP1.0 Q801 Q802 R801 R802 R803 R804 R805 R806 R807 R811 R812 R813 R814 R815 R816 R817 R818 R819 R820 R821 R822 R823 R824 R825 Code No.
7 Electrical Parts List Loc. No. R826 R827 R828 R829 R831 R832 R833 R834 R835 R837 R838 R841 R842 R843 R844 R846 R847 R849 R850 R851 X801 ZD801 7-52 Code No.
7 Electrical Parts List 7-5 Sensor PCB Parts (AQ19NS) Loc. No. C881 C882 C883 C884 CIS CIS CIS CIS CIS CIS CIS CIS CN881 IC881 JP11 MP1.0 R881 R882 R883 Code No. 2401-001548 2202-000654 2401-000025 2401-000025 0202-001044 0202-001046 0202-001172 0204-001095 0205-001027 6045-001010 0203-001199 0203-001200 3711-000992 BH32-00002A BH39-40305U BH41-00182A 2001-000019 2004-000970 2004-000970 AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS Description C-AL C-CERAMIC,MLC-RADIAL C-AL C-AL SOLDER-WIRE.
7 Electrical Parts List 7-6 USB Assy PCB Parts (AQ17IS) NO DESCRIPTION 1 USB PCB ASS`Y CODE NO SPECIFICATIONS BH59-00238A Q`TY LOCATION VENDOR 1 SEONG JI DAE DUCK 1 P.C.B BH41-00187A FR1,1.6T,247*247 mm 1 2 ZENER-DIODE 0403-000361 UZ, 6.2 BSB, 6.2V 3 ZD157ZD158,ZD159 3 C-CERAMIC 2202-000654 100nF,10%,50V,X7R 1 C167 SEM,SAMHWA 4 USB JACK 3722-001519 1 UPSTERAM ACON,LEOCO 5 CONNECTOR 3711-004068 SMAW200-05(ANGLE) 1 CN102 YEONHO 2 BRAKET BH71-00149A SECC-C,T1.
7 Electrical Parts List 7-7 AQ17** Main Different Part List AQ17IS AQ17HS LOC code spec code C305 C411 C413 C414 C415 C451 C457 C701 CN201_ASSY CN409 D601 EY599 HS301 L402 OP1(OP201-NF) POS601 R238 R302 R311 R314 R315 R596 R598 R599 JP690 JP691 JP221 JP332 JP538 JP539 JP540 JP541 JP551 JP552 JP557 JP558 JP559 JP560 JP561 JP562 JP575 JP584 JP669 JP670 JP671 JP672 JP673 JP674 CISCIS- 2301-000148 2301-001259 2301-001259 2306-000137 2301-001194 2401-002299 2201-000602 2301-001314 BH39-00060A 3711-000197
7 Electrical Parts List 7-8 AQ19** Main Different Part List AQ19MS AQ19IS AQ19NS LOC code spec code spec code spec C305 C207 C272 C273 C408 C409 C411 C413 C415 C416 C417 C451 C457 C701 CISCISCN201_ASSY CN206 CN207 CN409 D402 D456 D601 EY599 HS409 HS504 JP221 JP332 JP538 JP538 JP539 JP540 JP541 JP551 JP552 JP553 JP554 JP557 JP558 JP559 JP560 JP561 JP562 JP575 JP580 JP584 JP594 JP661 JP669 JP670 2301-000013 2303-001022 2303-001022 2306-000127 2306-000127 2301-001194 2306-000147 2306-000125 2401-00
7 Electrical Parts List AQ19MS AQ19IS AQ19NS LOC code spec code spec code spec JP671 JP672 JP673 JP674 JP690 JP691 L402 L403 OP1(OP201-NF) POS601 Q252 Q253 Q254 R214 R218 R238 R273 R274 R275 R276 R277 R302 R314 R315 R400 R401 R405 R409 R457 R459 R520 R522 R596 R597 R598 R599 T401 T601 ZD287 BH27-20345J BH26-00001A 0601-001147 1404-000135 2001-000613 2001-000734 2004-001136 2004-000458 2004-000334 2003-000724 2001-001163 2003-000423 2004-000616 2001-000084 2004-000515 BH39-40305U 2002-001075 2001
7 Electrical Parts List 7-9 AQ17** Video Different Part List AQ17IS LOC code C132 C133 C138 CN103 IC106 JP69 R137 R138 R145 R146 R147 R148 SK105 SK106CIS(AQ17IS) 3704-001142 BH39-00084A AQ17HS spec 10P,22.5PI,25.6PI,NI,3704-001158 CBF HARNESS 100MM code 2401-000603 2401-000603 2401-000031 3711-000058 BH13-00009A BH39-40305U 2007-000300 2007-000300 2001-000019 2001-000019 2003-000744 2003-000744 10P,22.5PI,26.
7 Electrical Parts List 7-11-1 BNC Different Part List LOC / ASSY BNC ASSY/USB ASSY R137 Apply to BNC BOARC Not Apply to BNC BOARC, Apply to USB ASY BH98-00257B ASSY PCB/MISC-SN(BNC) AQ17IS/HS BH98-00252C ASSY PCB/MISC-BNC AQ19MS/IS BH75-00365A UNIT-BRKT USB AQ17HS/IS,AQ19MS/IS BH98-00270A ASSY PCB/MISC-SN(BNC) AQ17NS BH98-00284A ASSY PCB/MISC-BNC AQ19NS AQ17NS/AQ19NS BH39-40305U 52MM,AWG22(0.
7 Electrical Parts List 7-11-2 BNC Different Part List Apply to PFC LOC R701 D703 C607 BD652 BD653 C701 C702 C703 C705 C706 C708 C710 D702 D704 HSD701 IC701 L701 R702 R703 R705 R706 R711 R712 R721 R704 HSQ701 T701 ZD705 ZD706 JP295 EY703 EY704 EY705 7-60 code 2005-001170 0402-001111 2401-003391 2301-001314 2305-001049 2305-001041 2201-000602 2301-000188 2202-002009 2401-000970 2201-000019 0402-000546 0401-000005 BH99-10019X 0402-001191 1203-002081 BH27-00053A 2001-001013 2001-000302 2004-001863 2004-00
7 Electrical Parts List 7-12 PFC FET Different Part List FUJI 2SK2761 LOC HSQ701 D704 R703 code BH99-10047E 0505-001266 0401-000005 2001-000302 Infineon SSP7N60 spec ASSYHEAT/SINK;2SK2761 FET;2SK2761-01MR,N,600V,10A, DIODE-SWITCHING;1N4148,100V R-CARBON;10OHM,5%,1/8W code BH99-10054C 0505-001493 2001-000281 spec ASSY HEAT/SINK SPP07N60S5,N,600V,7.3A, R-CARBON;100OHM,5%,1/8W 7-13 FBT Different Part List SEMCO LOC R524 code 2004-001254 HITACHI spec R-METAL;8.
7 Electrical Parts List 7-16 S-Corretion Table AQ17HS Khz AQ17IS S1 S2 S3 S4 S5 ~110 ~99.9 ~94.9 ~91.9 ~84.9 ~80.9 ~77.9 ~75.9 ~69.9 ~67.9 ~64.9 ~60.9 ~58.9 ~52.9 ~48.9 ~45.9 ~39.9 ~36.9 ~34.9 ~33 H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H AQ19MS Khz ~110 ~99.9 ~94.9 ~91.9 ~84.9 ~80.9 ~77.9 ~71.9 ~69.9 ~67.9 ~64.9 ~60.9 ~58.9 ~52.9 ~48.9 ~45.9 ~39.9 ~36.9 ~34.9 ~33 7-62 Khz ~110 ~99.9 ~94.9 ~91.9 ~84.9 ~80.9 ~77.9 ~75.9 ~69.9 ~67.9 ~64.9 ~60.9 ~58.9 ~52.9 ~48.
AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS S-CORRECTION SOG LED H-SYNC V-SYNC AC INPUT 90-264VAC 60/50Hz AC INLET SOCKET H-SYNC TRIGGER MENU KEY MICROPROCESSOR ST72T774 CRYSTAL 24MHz D-COIL DEGAUSS OPERATION ACL CLAMP TILT MOIRE H_LIN. RECTIFIER D3SBA60 SWITCHING TRANS POWER OFF CONTROL POWER SYNC PWM CONTROL & SWITCHING FET DP408 LINE FILTER PFC CONTROL BNC/D-SUB R.G.B H-SYNC V-SYNC INPUT SDA/SCL H-SYNC/ V-SYNC OUT S-RASTER DDC-DATA DDC-CLK DEGAUSS -14V_I -14V +6.
8 Block Diagrams Memo 8-2 AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS
9 Wiring Diagram H_CG H_CG V_CG V_CG CN103 Video PCB 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 H_SYNC_OUT +5V +12V +80V 6.
9 Wiring Diagram Memo 9-2 AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS
10 Schematic Diagrams 10-1-1 AQ17** & AQ19** Main Part Schematic Diagram CN201 slcon15p 1 2 +5V 1 2 3 +12V IC202 KIA7042AP C281 10uF 50V C280 100nF 50V MO 3 R284 100 1/6W IC280 KS24C080 1 8 2 7 3 6 4 5 BD280 B +80V 4 5 +6.3V 6 W_PROTECT SCL 7 G1 R280 100 1/6W 8 R282 R220 12K 1/6W RESET R203 220 1/6W +5V_1 +12V C207 100nF 50V MO 2 BNC/DSUB R215 4.7K 1/8W R218 19NS 2.2K OTHER 1/6W 3.
10 Schematic Diagrams 9 IC250, #24 10-2 10 IC250, #23 13 2.20 V (IC250, #11, 32) 16 3.42 V (IC201, #33) 17 3.16 V (IC201, #32) CH1 P-P = 2.20 V CH1 RMS = 2.776 V CH1 P-P = 3.42 V CH1 RMS = 2.500V CH1 P-P = 3.16 V CH1 RMS = 2.
10 Schematic Diagrams 10-1-2 AQ17** & AQ19** Main Part Schematic Diagram +12V 14 +80V +350V +30V HIGH_VOLTAGE SCREEN FOCUS(RED) FOCUS(WHT) L502 4.7uH C503 470uF 16V 105C D505 GUR460L-5700 IC501 TL494CN R523 1M 1/2W R524 8.2K 1/4W MF R525 1.2K 1/4W MF D532 1N4148 B C H_SIZE +12V R402 2.
10 Schematic Diagrams 2 IC402, #6 3 Q454, drain CH1 P-P = 10.96 V CH1 RMS = 6.180 V 7 Q402, Collector 4 Q401, Gate 5 Q401, Drain 6 Q402, Base 12 Q504, Gate 14 580 V (T501, #1) CH1 P-P = 11.6 V CH1 RMS = 6.944V 8 T402, #8 11 IC301, #6 CH1 P-P = 580 V CH1 RMS = 278.
10 Schematic Diagrams 10-1-3 AQ17** & AQ19** Main Part Schematic Diagram AQUILA PROJECT POWER CIRCUIT WARING: BEFORE SERVICING THIS CHASSIS, CAUTION READ "X-RAY RADIATION PRECAUTION,SAFETY WARNING: "THIS EQUIPMENT CONTAINS SAFETY CRITICAL COMPONTS ALL PARTS SHOWN IN THE SHADED AREAS OF THE SCHEMATICARE SAFETY REPLACE SAFETY CRITICAL COMPONENTS ONLY WITH MANUFACTURERS RECOMENDED PARTS LIST FOR EXACT REPLACEMENTS". 1.
10 Schematic Diagrams 1 368 V (IC601, #1) 10-6 AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS
10 Schematic Diagrams 10-2 AQ17** Video Part Schematic Diagram 1.2UH,3.5_5.7MM L106 4.7uH B 2E 2H 1E 2I R132 1K 7 1/10W 8 SDA 1F 2J 1G 2K 1H 2L 1I 2M 10 1J 2N C129 100PF 50V MO R133 1K 1/10W 12 1K 1N 20 R140 330 1/10W 19 R141 330 1/10W 18R142 330 ZD103 BZX79C5V6 1L R144 3.9K 1/10W R137 C137 4.7uF 50V 2 3 8 5 11 3 R148 56 2W MO V_CG 9 4 6 slcon4p CN103 H_FLB1 C124 10nF 100V P R125 2.
10 Schematic Diagrams 15 CRT Socket, Red, Green, Blue 10-8 19 IC103, #5, 24 20 R, G, B, Video 21 IC101, #14, 15 23 IC105, #18 AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS
10 Schematic Diagrams 10-3 AQ19** Video Part Schematic Diagram B 12V 80V C103 100nF 50V MO BD101 1.2uH 1.2UH,3.5*5.7MM +5V L101 150uH 12V R102 82K 1/10W L106 1.5uH 3 MMBD4148SE 3 GIN GIN GND GND ROUT RIN TEST 6 7 CB01 100nF 50V 6 2 RB01 75 1/10W VSSA FBLK VCOIN VSS 1 DB01 3 MMBD4148SE 9 VREF 10 11 12 C180 100UF 16V C122 6.
10 Schematic Diagrams 15 CRT Socket, Red, Green, Blue 10-10 18 IC103, #6, 17 20 R, G, B, Video 22 IC105, #14, 15 23 IC105, #18 AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS
10 Schematic Diagrams 10-4 Purity Part Schematic Diagram CN801 slcon13p +5V +12V +14V_II +14V_II 14V_I TEMP SENSOR PCB IC801 ST72E75_3 CN802 slcon3p 13 R833 100K 1/4W MF 1 12 2 11 TH801 47UF 16V +12V 5 4 3 10 9 R834 10K 1/4W MF R827 8 56 7 SCL R828 1/8W 3 V/Y 2 Q802 KSD1616-Y IC805-1 LM358N VX VY REF 3 C R807 1 1/4W B 8 VCC E 1 Q1 56 1 Q0 2 1 Q2 4 1/8W 6 E VEE slcon5p CN882 RESET2 1/8W 2 C804 3.
10 Schematic Diagrams 10-5 Sensor Part Schematic Diagram R881 10 1/2W C881 47uF 25V C882 100nF 50V MO IC881 TMC3000NF 2 3 R882 470 1/4W MF 5 4 4 5 NC7 14 Vcc NC6 13 GND1 NC5 12 NC4 11 X-OUT NC3 10 Y-OUT NC2 9 NC1 8 IC 3 6 2 1 slcon5p CN881 C883 100uF 16V C884 100uF 16V 7 R883 470 1/4W MF GND2 DIRECTION SENSOR PCB IC881_1 TMC3000NF_1 4 V_REF 5 6 7 10-12 X-OUT Vcc Y-OUT GND1 2 3 MANUAL PR : RCA JACK GND2 IN, NO, MAX, 2-8KG AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/A
10 Schematic Diagrams 10-6 BNC Part Schematic Diagram +5V DB51 1N4148 +5V_DDC +5V DG51 1N4148 +3.3V +5V C151 100nF 50V MO DR51 1N4148 C159 10uF 25V UPSTREAM slcon6p C160 100nF 50V MO ZD159 UZ-6.2BM CN104 slcon5p 1 SELECTOR 5 2 USB_DM 4 3 4 3 ZD160 UZ-6.
10 Schematic Diagrams 10-7 USB Part Schematic Diagram +3.3V ZD157 C167 100nF 50V UZ-6.2BM MO CN102 slcon5p UPSTREAM slcon6p 1 5 2 USB_DM 4 USB_DP 3 USB_DP 3 USB_DM 4 2 5 6 10-14 +3.3V ZD158 UZ-6.2BM 1 ZD159 UZ-6.