Refrigerator user manual This manual is made with 100 % recycled paper. imagine the possibilities Thank you for purchasing this Samsung product. Free Standing Appliance DA68-03194H (EN)-05.indd 1 2015. 8. 24.
Contents SAFETY INFORMATION ……………………………………………………… 2 SETTING UP YOUR REFRIGERATOR …………………………………… 18 OPERATING YOUR SAMSUNG REFRIGERATOR ……………………… 27 TROUBLESHOOTING ……………………………………………………… 40 Safety information SAFETY INFORMATION • Before operating the appliance, please read this manual thoroughly and retain it for your reference. • Use this appliance only for its intended purpose as described in this instruction manual.
SAFETY INFORMATION refrigerant used. manual do not cover all possible conditions and • Never start up an appliance situations that may occur. showing any signs of It is your responsibility to use damage. common sense, caution, If in doubt, consult your and care when installing, dealer. maintaining, and operating The room must be 1 m³ your appliance. in size for every 8 g of R-600a refrigerant inside the • Because these following appliance.
Important safety symbols and precautions: WARNING CAUTION Hazards or unsafe practices that may result in severe personal injury or death. Hazards or unsafe practices that may result in minor personal injury or property damage. Do NOT attempt. Do NOT disassemble. Do NOT touch.
WARNING SEVERE WARNING SIGNS FOR TRANSPORTATION AND SITE WARNING • • - • • • Deteriorated insulation of electrical parts may cause an electric shock or fire. Do not place this refrigerator in direct sunlight or expose to the heat from stoves, room heaters or other appliance. Do not plug several appliances into the same multiple power board. The refrigerator should always be plugged into its own individual electrical outlet which has a voltage rating that matched the rating plate.
• Do not pull or excessively bend the power cord. • Do not twist or tie the power cord. • Do not hook the power cord over a metal object, place a heavy object on the power cord, insert the power cord between objects, or push the power cord into the space behind the appliance. - When moving the refrigerator, be careful not to roll over or damage the power cord. - This may result in an electric shock or fire. • Do not use aerosols near the refrigerator.
refrigerator to prevent any power leakages or electric shocks caused by current leakage from the refrigerator. - This may result in an electric shock, fire, explosion, or problems with the product. - Never plug the power cord into a socket that is not grounded correctly and make sure that it is in accordance with local and national codes. SAFETY INFORMATION • Do not install this appliance in a humid, oily or dusty location, in a location exposed to direct sunlight and water (rain drops).
CAUTION • • - • • • CAUTION SIGNS FOR INSTALLATION • Keep ventilation opening in the appliance enclosure or mounting structure clear of obstruction. Allow the appliance to stand for 2 hours before loading foods after installation and turning on. The installation or any service of this appliance is recommended by a qualified technician or service company. Failing to do so may result in an electric shock, fire, explosion, problems with the product, or injury.
- - • • • • • • • - • • - any naked flames or potential sources of ignition and air the room in which the appliance is standing for several minutes. Do not use mechanical devices or any other means to accelerate the defrosting process, other than those recommended by the manufacturer. Do not damage the refrigerant circuit. Do not spray volatile material such as insecticide onto the surface of the appliance.
• Do not let children hang on the door. If not, a serious injury may occur. - Risk of children entrapment. Do not let children enter inside the refrigerator. • Do not leave the doors of the refrigerator open while the refrigerator is unattended and do not let children enter inside the refrigerator. • Do not allow babies or children go inside the drawer. - It can cause death from suffocation by entrapment or personal injury. • Do not sit on the Freezer door.
• Do not attempt to repair, disassemble, or modify the appliance yourself. - Do not use any fuse (such as cooper, steel wire, etc.) other than the standard fuse. - When repairing or reinstalling the appliance is required, contact your nearest service center. - Failing to do so may result in an electric shock, fire, problems with the product, or injury.
• Do not put a container filled with water on the appliance. - If spilled, there is a risk of fire or electric shock. • Never stare directly at the UV LED lamp for long periods of time. - This may result in eye strain due to the ultraviolet rays. • Please observe maximum storage times and expiry dates of frozen goods. • Do not store low temperature-sensitive pharmaceutical products, scientific materials or other low temperature-sensitive products in the refrigerator.
• • - • • • • • • - • - suitably qualified person and connected to a potable water supply only. If you have a long vacation or business trip and won’t use water or ice dispensers, close the water valve. Otherwise, water leakage may occur. Wipe excess moisture from the inside and leave the doors open. Otherwise, odor and mold may develop. When the refrigerator got wet by water, pull out the power plug and contact your Samsung Electronics service center.
in property damage or injury. • Do not clean the appliance by spraying water directly • If the supply cord is onto it. damaged, it must be replaced by the manufacturer, • Do not use benzene, thinner, its service agent or similarly or Clorox, Chloride for qualified persons in order to cleaning. avoid a hazard. - They may damage the surface of the appliance and may cause a fire. CAUTION SIGNS CAUTION FOR CLEANING AND MAINTENANCE • • - • Do not spray cleaning products directly on the display.
• - • • - covers. (For Australia only) When disposing of this or other refrigerator/s, remove the door/door seals, door latch so that children or animals cannot become trapped inside. Children should be supervised to ensure that they do not enter and play with the appliance. If trapped inside, the child may become injury and suffocate to death. Please dispose of the packaging material for this product in an environmentally friendly manner.
ADDITIONAL TIPS FOR PROPER USAGE • In the event of a power failure, call the local office of your Electricity Company and ask how long it is going to last. - Most power failures that are corrected within an hour or two will not affect your refrigerator temperatures. However, you should minimize the number of door openings while the power is off. - But should the power failure last more than 24 hours, remove all frozen food.
of energy, please keep the all inner fittings such as baskets, drawers, shelves on the position supplied by manufacturer. This appliance is intended to be used in household and similar applications such as - staff kitchen areas in shops, offices and other working environments; - farm houses and by clients in hotels, motels and other residential type environments; - bed and breakfast type environments; - catering and similar non-retail applications.
Setting up your refrigerator GETTING READY TO INSTALL THE REFRIGERATOR B A Congratulations on your purchase of the Samsung refrigerator. We hope you enjoy the state-of-art features and efficiencies that this new appliance offers. D C Depth “A” Selecting the best location for the Refrigerator Choose : 908 mm Height “C” 1797 mm Overall Height “D” 1825 mm • • • • 50 mm 300 mm 300 mm 125°° 125 125°° 125 305.5 mm 1519 mm 908 mm 72.
When moving your refrigerator To prevent floor damage, be sure the front leveling legs are in the up position (above the floor). Refer to “HOW TO LEVEL THE REFRIGERATOR” in the manual on page 23. REMOVING THE REFRIGERATOR DOORS If the refrigerator is too large to pass through your doorway easily, you can remove the refrigerator doors. Tools you will need (Not provided) For proper installation, you must place this refrigerator on a level, hard surface that is the same height as the rest of the floor.
4. Remove the Hinge (F). DISASSEMBLING THE FRIDGE DOORS 1. With the door closed, remove the 3 screws holding the Top Cover (A) with a Phillips (+) Screwdriver, and then remove the Top Cover with the entire wire-harnesses attached. F 5. Lift up the Fridge Door and take it off. • While disassembling and reassembling the door, make sure that the electric wires are not peeled off. • Do not let the door fall down. CAUTION A 2.
3. While pushing the door in the direction of the arrow, lift up the Mid Hinge Shaft (D). CAUTION • Be careful not to damage the wires on the bottom of the door. Avoid stepping on them, etc. 2. Insert the Hinge Shaft (C) into the Mid Hinge Hole (D) and put on the Hinge Cap (E). D 4. Being careful that the door does not touch the Mid Hinge (E), tilt the Door forward a little, and then lift it up to remove.
How to Re-Attach the Fridge Door 1. Attach the detached Fridge Door to the Mid Hinge. 5. Connect the Water Tube (C). Connect the two connectors on the left door and the one connector (E) on the right door. E E C 2. Slide the Fridge Hinge (A) into the fixing slot, and then press it down so that it is aligned with the hole in the door. 6. Attach the front of the Top Cover, and then press down on its back until it lies flat. Re-attach the screws. A 3.
LEVELING THE REFRIGERATOR AND ADJUSTING HEIGHT AND GAP OF THE DOORS • Insert a Flat-Head (-) Screwdriver into the slot in the Leveling Leg Control Lever and adjust the level by turning the Control Lever clockwise or counter-clockwise. When you rotate the Lever clockwise, you raise the refrigerator. When you rotate the Lever counter-clockwise, you lower the refrigerator.
Snap Rings included with the refrigerator: HOW TO ADJUST THE DOOR HEIGHT If any one of the doors is lower than the other: 1 mm 1.5 mm 2 mm 2.5 mm • Check if the Refrigerator is level before adjusting the door. • Adjust the door height difference by inserting a Snap Ring (1) as shown between the door and the hinge. You can use the rings on the right side door of the fresh food compartment and both sides of the freezer compartment.
Connecting to the water supply line INSTALLING THE WATER DISPENSER LINE • Water line installation kits are available at extra cost from your dealer. We recommend using a water line installation kit that contains copper tubing and 6 mm (¼”) compression nut. • The new hose-sets supplied with the appliance are to be used and that old hose-sets should not be reused. 1. First, shut off the main water supply. 2. Locate the nearest cold water drinking line and install the pipe clamp and shut off valve.
5. After you turn on the refrigerator, let the ice maker make ice for 1 to 2 days. Over that period of time, throw out the first 1 or 2 buckets of ice the freezer makes to ensure all impurities have been removed from the water line.
Operating your Samsung refrigerator USING THE CONTROL PANEL (4) (2) (5) (7) (3) (8) (6) (1) OPERATING (1) Freezer (Hold 3 sec for Power Freeze) (2) Touch this button to set the freezer to your desired temperature. You can set the temperature between -23 °C and -15 °C. Touch and hold this button for 3 seconds to decrease the time needed to freeze products in the Freezer.
(3) Energy Saver (Hold 3 sec for Control Lock) (5) Touching this button turns Energy Saver mode on and off. When you turn Energy Saver on, the Energy Saver icon lights. Turn Energy Saver off and the icon goes off. The Energy Saver function is set to “ON” in the factory. If condensation or water drops appear on the doors, turn the Energy Saver mode off. Also, touching this button for 3 seconds turns on Control Lock which locks the display panel and dispenser buttons so the buttons can not be used.
(6) Ice Type (8) Water filter usage This icon will light up when you need to change the filter. After you use about 300 gallons of water, the filter indicator lights up. (in about 6 months) The icon will blink red for several seconds when you open or close the door. After you install the new water filter, touch and hold the Crushed Ice button for 3 Seconds to reset the filter. - If water is not dispensing or dispensing slowly, you need to replace the water filter because the water filter is clogged.
CHANGING THE WATER FILTER WARNING 2 • To reduce risk of water damage to your property DO NOT use generic brands of water filters in your SAMSUNG Refrigerator. USE ONLY SAMSUNG BRAND WATER FILTERS. SAMSUNG will not be legally responsible for any damage, including, but not limited to, property damage caused by water leakage from the use of a generic water filter. 3 3. Insert the new filter into the filter case ( 4 ). (Red) 4 SAMSUNG Refrigerators are designed to work ONLY WITH SAMSUNG Water Filter.
Removing any residual matter inside the water supply line after installing the water filter. 1. Turn ON the main water supply and supply water from water supply line. 3. Additional flushing may be required in some households. 4. Open the Refrigerator door and make sure there are no water leaks coming from the water filter. The pressure of the water supply coming out of a reverse osmosis system going to the water inlet valve of the refrigerator needs to be between 241 and 827 kPa.
• The Freezer or Fridge temp indicator will blink when the temperature in the fridge or freezer compartment goes up dramatically. (Freezer or Fridge temperature indicator will stop blinking when temperature in the Freezer or Fridge becomes normal. If temperature indicator does not stop blinking after several hours, please contact your service center.
CONTROLLING THE FRIDGE TEMPERATURE USING THE ICE AND COLD WATER DISPENSERS Push the appropriate ice type button to select what you want dispensed Using the ice lever ( 1 ) Recommend Temp (Fridge) : 3 °C (37 °F ) Press the Fridge button to set the fridge to desired temperature from the range between 1 °C and 7 °C. Default set temperature is set on 3 °C and each time you press the Fridge button, temperature will change in following order and temperature indicator will display the desired temperature.
Using the Ice & Water Dispenser together To get Ice and water, push the Ice lever ( 1 ) first for ice, then move your glass down and press the water dispenser lever ( 2 ) for water. • To test the ice maker, press the Test button on the ice maker. You will hear the refrigerator chime (ding-dong). When the chime sounds, release the Test button. • The chime sounds automatically again to let you know the ice maker is working well.
GOING ON VACATION... When you select the Ice Off mode, remove all ice cubes from the bucket. If you leave the ice cubes in the bucket, the ice cubes may clump together, making it difficult to remove them. To remove the ice bucket safely and avoid injury, hold the bottom of the bucket with one hand and the side of the bucket with the other. Then, lift up on the ice bucket, and pull it straight out. To put the ice bucket back in, push it firmly straight back.
PARTS AND FEATURES Use this page to become more familiar with the parts and features of the Refrigerator.
ADDITIONAL PART - ASSY SHELF FRE To get more space, you can remove each Middle drawer of freezer and Cool Select Room. And then, locate the ‘ASSY SHELF FRE’ between middle and bottom drawers of the freezer and Cool Select Room, since it does not affect thermal and mechanical characteristics. • The ASSY SHELF FRE shall be used only to the designated location with the Middle drawer removed. • Do not place and use the ASSY SHELF FRE on the EZ Freezer Slide-Shelf.
REMOVING THE REFRIGERATOR ACCESSORIES 1. Door Bins or Guards Compartment • To remove - Simply lift the bin up and pull straight out. • To relocate - Slide it in above the desired location and push down until it stops. CAUTION • Injuries can occur if the door bins are not firmly attached to the doors. Do not allow children to play with longer. Sharp corners of the bins may cause injury. 2.
CLEANING THE REFRIGERATOR • Do not use benzene, thinner, Clorox, or car detergent to clean the refrigerator. They can damage the surface of the appliance and may cause a fire. • Do not spray the refrigerator with water while it is plugged in, This can cause an electric shock. WARNING OPERATING • To clean the refrigerator, follow these steps: 1. Unplug the power code of the refrigerator. 2. Slightly dampen a soft lint-free cloth or paper towel with water.
Troubleshooting PROBLEM SOLUTION The refrigerator does not work at all or it does not chill sufficiently. • Check if the power plug is properly connected. • Check if the set temperature on the digital display is warmer than the freezer or fridge inner temperature. If it is, set the freezer or fridge to a colder temperature. • Is the refrigerator in direct sunlight or located near a heat source? If so, it may not be able to cool sufficiently.
SOLUTION You can hear water bubbling in the refrigerator. • This is normal. The bubbling comes from refrigerant circulating through the refrigerator. There is a bad smell in the refrigerator. • Check for spoiled food. • Foods with strong odors (for example, fish) should be tightly covered. • Clean out your freezer periodically and throw away any spoiled or suspicious food. Frost forms on the walls of the freezer. • Is the air vent blocked? Remove any obstructions so air can circulate freely.
Circuit diagram DA68-03194H (EN)-05.indd 42 2015. 8. 24.
Memo DA68-03194H (EN)-05.indd 43 2015. 8. 24.
Ambient Room Temperature Limits This refrigerator is designed to operate in ambient temperatures specified by its temperature class marked on the rating plate.
