User Guide

ManualsBrandsSanta Fe ManualsDehumidifier4031470

TS-1156 08/20 Rev B

Installation & Operation Instructions

IMPACT SERIES | I MPACT105

IMPACT155

Santa-Fe-Products.com | 800.533.7533

Serial Number

Install Date

Sold By

The Santa Fe Impact105 and Impact155

dehumidiers feature dual exhaust outlets for

air distribution to multiple locations.The Impact

Series is engineered for extremely quiet

operation and optimized for low heat load.

These dehumidiers have a horizontal

conguration, making them optimal for

basements or crawl space applications.

Patent: thermastor.com/patents

Summary of content (16 pages)

PAGE 1
I M PACT SERIES | I MPACT10 5 I MPACT 155 Installation & Operation Instructions The Santa Fe Impact105 and Impact155 Serial Number dehumidifiers feature dual exhaust outlets for Install Date air distribution to multiple locations.The Impact Series is engineered for extremely quiet Sold By operation and optimized for low heat load. These dehumidifiers have a horizontal configuration, making them optimal for basements or crawl space applications. Patent: thermastor.com/patents Santa-Fe-Products.
PAGE 2
Table of Contents Safety Instructions...................................................................................3 Intended Applications.................................................................................3 Registrations...............................................................................................3 Dehumidifier Set Up..................................................................................4 Items Included In Box....................................................
PAGE 3
Safety Instructions READ THE INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS CAREFULLY BEFORE INSTALLING AND OPERATING THIS DEVICE. PROPER ADHERENCE TO THESE INSTRUCTIONS IS ESSENTIAL TO OBTAIN MAXIMUM BENEFIT FROM YOUR SANTA FE DEHUMIDIFIER. WARNING! THIS SYMBOL MEANS IMPORTANT INSTRUCTIONS. FAILURE TO HEED THEM CAN RESULT IN SERIOUS INJURY OR DEATH. CAUTION! THIS SYMBOL MEANS IMPORTANT INSTRUCTIONS. FAILURE TO HEED THEM CAN RESULT IN INJURY OR MATERIAL PROPERTY DAMAGE.
PAGE 4
Dehumidifier Set Up CAUTION! REMOVE COMPRESSOR SHIPPING TIE FROM THE UNIT. FAILURE TO REMOVE SHIPPING TIE WILL CAUSE EXCESS VIBRATION TO BE TRANSMITTED TO THE FRAME. The Santa Fe Impact dehumidifier uses a compressor to power the refrigeration system. To protect the compressor and refrigeration system during shipping a plastic tie wrap secures it to the units frame. Remove the tie wrap by cutting the tie wrap and pulling from the unit as shown.
PAGE 5
Drain Installation The Santa Fe Impact dehumidifier generates condensate. Place a secondary drain pan under the dehumidifier if it is suspended above a finished area or above an area where water leakage could cause damage. A drain trap is required for the dehumidifier to run properly. Install a 3/4" threaded male NPT adapter to the drain port or drain pan if one is being used. Install a drain pipe assembly utilizing 3/4" PVC pipe to transport the condensate to a drain.
PAGE 6
Operation Humidity Control Adjustment The humidity control is an adjustable switch that turns the dehumidifier on and off. It turns on when the relative humidity (RH) rises to the dial set point. It turns off when the RH is within ±5% of the set point.
PAGE 7
Air Filtration The Santa Fe Impact dehumidifier is equipped with a MERV-13 filter (89-90% ASHRAE dust spot). An optional MERV-11 filter is available at www.ThermastorFilters.com. The filter should be checked and replaced every three to six months. Operating the unit with a dirty filter will reduce dehumidifier capacity and efficiency. DO NOT operate the unit without the standard MERV-13 filter or optional MERV-11 filter. Filter non-compliance voids the product warranty.
PAGE 8
Ducting To Finished Areas (Optional) Attaching Duct Collars Return Air Inlet An 12” diameter duct collar and a front panel are attached to the unit. Supply Air Outlet Two 10” diameter duct collars attach to the outlets on each side of the unit. CAUTION! BOTH EXHAUST OUTLETS MUST BE LEFT OPEN OR DUCTED USING THE TWO 10” DUCT COLLARS. DO NOT BLOCK OFF ONE SIDE. FAILURE TO DO SO WILL RESULT IN DAMAGE OF THE UNIT.
PAGE 9
Ducting To Finished Areas (Optional) Recommended Installations 1 Installation of a Supply Kit Only 2 3 ish n i nf d Area 4 1 a 1 Finish e Installation of a Supply and Return Duct Kit e re A d U Finish e d Area 3 2 4 5 a 6 ini nf sh e re A d U 1 Passive Return Vent 3 Supply Grill 1 Return Grill 4 Supply Grill 2 Optional Wall 4 Supply/Discharge 2 Passive Return Vent* 5 Supply/Discharge Duct Work Mount Dehumidistat (mounts on opposite wall in finished area) • Place the Sa
PAGE 10
Service - Troubleshooting CAUTION! TROUBLESHOOTING SHOULD BE PERFORMED BY A QUALIFIED HVAC TECHNICIAN. Symptom Possible Reason Fan is not running. Dehumidification or fan is being called for. 1. L oose connection in fan circuit. 2. O bstruction prevents fan impeller rotation. 3. Defective fan. 4. Defective fan relay. Low dehumidification 1. D efrost thermostat loose capacity (evaporator or defective. is frosted 2. Low refrigerant charge. continuously).
PAGE 11
Service - Troubleshooting WARNING! CAUTION! TROUBLESHOOTING SHOULD BE PERFORMED BY A QUALIFIED HVAC TECHNICIAN. Symptom Possible Reason Neither fan nor compressor running. Dehumidification is being called for. 1. D ehumidifier unplugged or no power to outlet. 2. H umidity control set too high. 3. Loose connection in internal or control wiring. 4. D efective compressor relay. Compressor is not running. Dehumidification is being called for. Fan is running. 1.
PAGE 12
Electrical Requirements The Santa Fe Impact dehumidifier plugs into a common grounded 115VAC outlet. The Impact105 draws 4.9 Amps at 80°F and 60% RH. The Impact155 draws 8.0 Amps at 80°F and 60% RH. Locate the dehumidifier in an area where the cord’s length (9') easily reaches a 115 VAC electrical outlet with a minimum of 15 Amp circuit capacity. If used in an area that may become wet, a GFCI protected circuit is recommended. The unit should not be used in areas prone to flooding.
PAGE 13
Warranty Limited Warranty.
PAGE 14
Santa Fe Impact105 / Impact155 Installation & Operation Instructions Santa-Fe-Products.com | 800.533.
PAGE 15
800.533.7533 | Santa-Fe-Products.
PAGE 16
DEHUMIDIFIERS Santa-Fe-Products.com 800.533.