Use and Care Guide
Table Of Contents
- TOC-Important-Installation-Guidelines
- TOC-Model-Differences
- TOC-Check-Contents-of-Box
- TOC-Do-Not-Remove-Paper-Mat
- TOC-Important-Notices
- TOC-Ready-to-Go-
- TOC-90-Bends-in-Vent
- TOC-1.-Position-Toilet
- TOC-1
- TOC-2.-Cut-Vent-Hole-in-Roof-Ceiling
- TOC-2
- TOC-3.-Vent-Roof-Stack-Installation
- TOC-3
- TOC-4.-Insert-Vent-Pipe-into-System
- TOC-4
- TOC-5.-Attach-Union-Coupling-Optional-
- TOC-5
- TOC-6.-Connect-Remaining-Vent-Pipe
- TOC-7.-Install-Drain
- TOC-8.-Seal-All-Vent-Connections
- TOC-9.-Insulate-Exposed-Pipe
- TOC-6
- TOC-10.-Attach-Rain-Cap-or-Wind-Turbine
- TOC-Protect-from-the-Elements
- TOC-Install-Rigid-Vent-Pipe-not-supplie
- TOC-Connect-Flexible-Vent-and-Rigid-Pip
- TOC-Attach-Wind-Turbine-Ventilator-
- TOC-Seal-All-Vent-Connections
- TOC-Install-Vacuum-Toilet
- TOC-Install-Drain
- TOC-Connect-Three-Components-of-System
- TOC-Start-Here
- TOC-Position-the-System
- TOC-Connect-Vacuum-Toilet-to-Vacuum-Gen
- TOC-Connect-Vacuum-Generator-to-Compost
- TOC-Fasten-Vacuum-Generator-Unit-and-Co
- TOC-Connect-Vacuum-Generator-to-12v-Pow
- TOC-Connect-Composting-System-to-AC-Ele
- TOC-Plug-Play-Wiring-Connection
- TOC_Do_Not_Add__3175881415145758
- TOC_Rated_Capacity_4164048674046512
- TOC_Operation_is_Easy_8826685531918387
- 1_System_Operation_09638061436967571
- TOC_1_Initial_System_Start_Up_1095042459
- TOC-1.-Initial-System-Start-Up
- TOC_2_Power_Control_42472747931111743
- TOC-2.-Power-Control
- Non_Electric_SystemsNot_applic_933833838
- FlushSmart_VF_models_Always_tu_554945394
- TOC_12VDC_Systems_12964841970897056
- TOC-12VDC-Systems
- FlushSmart_VF_models_Always_tu
- 5_Weekly_Operation_5923775715714038
- TOC-Typical-Emptying-Times
- TOC-Indications-of-Emptying-Required
- TOC-Before-you-Empty
- TOC_Introduction_3353822634090_525738961
- Proper_System_Operation_1312612757753413
- TOC_Outside_Odour_901114465392_444162368
Use as directed. To ensure proper performance, please be sure to contact us if you have installation or operation questions.
ENVIROLET®/SG INSTALLATION & OPERATION MANUAL (7MINS11D 12.15) • Envirolet® is a registered trademark. ©2016, Sancor Industries Ltd.
56
Rated Capacity
• Your Envirolet®/SG Composting Toilet System has a maximum rated capacity.
• Do not use above these rated capacities.
• Refer to Rated Capacity section for list of models and capacities.
Operation is Easy
• Your Envirolet®/SG Composting Toilet System is easy to operate
• Please follow all directions for proper performance.
• Be sure to follow all safety precautions listed in this manual. Refer to Safety Guidelines section for more information.
• Familiarize yourself with basic operation steps before use.
Contents
A. System Use & Care Overview
B. Start of Season: System Start-Up
C. Composting Unit Power Control
D. Daily Operation
E. Weekly Operation
F. Mid-Season
G. Pre-Winter
H. End of Season
I. Aerator & Rake Bar Operation
1. System Use & Care Overview
This chart is an overview of proper system operation. Specific details follow this section.
System Use & Care Chart
#
Task
Start of
Season
Daily
Weekly
Mid-
Season
Pre-Winter
Season
End of
Season
1
Add Starter Mix
X
2
Add Daily Mix
X
3
Add Daily Mix (Weekly Use)
X
4
Add Compost Accelerator
X
X
X
X
X
5
Use Aerator Bar
X
X
X
6
Clean drain line and filters
X
X
7
Check electric components
X
8
Empty System
X
9
Check all air and liquid seals
X
X
10
Winterize system
X
• Start of Season refers to the “starting point” for your Envirolet®/SG. Typically for cottage-type use this is in the spring.
• Daily refers to any day when the system is in use.
• Mid-Season refers to the approximate half-way point of system use. For typical cottage use this will often be mid-summer.
• Other additives can be substituted for Daily Mix when required. Acceptable additives include dark soil, peat moss, coffee
grounds, cocoa shells, coconut husks, wood shavings (not cedar) and sawdust.
• Any winterizing precautions that are required should be completed well before winter season begins (Pre-Winter Season),
i.e., fall season.