GET IT RIGHT THE FIRST TIME VXT7-B2 INSTRUCTION MANUAL Follow this step-by-step instruction manual to speed up your installation.
WE’RE HERE TO HELP Recommended placement Want to watch a video that shows how easy this DIY project will be? Watch it now at: SANUS.com/2817 Get it right the first time. HeightFinder™ shows you where to drill. Check it out at: SANUS.com/2567 Our install experts are standing by to help.
Before you begin Remove the stand from your TV — if attached. Install any accessories you may have purchased — if they require the TV to be removed from the wall for assembly. The TV is removable for future accessory purchases. Protect the face of your TV when laying it down for installation.
IMPORTANT SAFETY INSTRUCTIONS – PLEASE READ MANUAL PRIOR TO USE – SAVE THESE INSTRUCTIONS Please read through these instructions completely to be sure you’re comfortable with this easy install process. Check your TV owner’s manual to see if there are any special requirements for mounting your TV.
Wall Construction ONLY install on these acceptable wall types. Unsure Call Customer Service wood studs CAUTION: Solid concrete or concrete block DO NOT install in drywall alone Drywall alone will NOT hold the weight of your TV. ACCEPTABLE ACCEPTABLE Tools Needed 1/2 in. (13 mm) Pencil Stud Finder Level Awl Tape 7/32 in. (5.5 mm) Wood Drill Bit Screwdriver Concrete Install Wood Stud Install Tape Measure Electric Drill 3/8 in.
STEP 1 Attach TV Bracket to TV WARNING: This product contains small items that could be a choking hazard if swallowed. Before starting assembly, verify all parts are included and undamaged. If any parts are missing or damaged, do not return the damaged item to your dealer; contact Customer Service. Never use damaged parts! NOTE: Not all hardware included will be used. STEP 1 Parts and Hardware 01 TV Screws (qty. 4 each) [Only one size fits your TV] M6 Washer (qty.
1.1 Select TV Screw Diameter Only one screw size fits your TV. M6 M8 1.2 Select TV Screw Length and Spacers A NO SPACER • Flat Back TV [TV brackets lay flat on your TV] Use short TV screws 01 . Spacers 03 not needed. 01 If your TV included inset spacers or wall mount adapters, see Troubleshooting on PAGE 22.
1.3 Determine Your TV Bracket Configuration Measure the HEIGHT of your TV mounting hole pattern. For height greater than 400mm Skip to STEP 1.4 on PAGE 9 Assemble TV bracket extensions 06 to fit over your TV VESA height. 04 07 08 05 06 06 ≤ 400mm (15 ¾ in.) 8 06 TV VESA Height For Height 400mm or less > 400mm (15 ¾ in.
1.4 Attach TV Brackets to Your TV Center the TV brackets 04 04 and 05 on your TV hole pattern, and install using your screw/washer/spacer. 05 A B NO SPACER 02 01 SPACER NEEDED 03 02 01 Adjust the straps to the bottom of the TV.
STEP 2 Attach Wall Plate to Wall WARNING: This product contains small items that could be a choking hazard if swallowed. Before starting assembly, verify all parts are included and undamaged. If any parts are missing or damaged, do not return the damaged item to your dealer; contact Customer Service. Never use damaged parts! NOTE: Not all hardware included will be used. Parts and Hardware for STEP 2 Tool for Adjustments Wall Plate Template 09 (qty. 1) Hex Key 3/16 in. 5⁄16 in. x 2 ¾ in.
Determine Your Wall Plate Configuration Measure the distance between your TV brackets For TV brackets 700mm or less * Skip to STEP: 2A (wood Stud) on PAGE 12 or 2B (concrete) on PAGE 15 04 / 05 For TV brackets greater than 700mm Extend the wall plate to fit the TV brackets. . Extend your wall plate 10 beyond your TV brackets 04 / 05 , but not past your TV edges. WARNING: Avoid potential personal injuries! These areas could be pinch points when sliding back together. 10 > 700mm (27 ½ in.
STEP 2A Wood Stud Installation CAUTION: Avoid potential personal injury or property damage! Min. 1 ½ in. (3.8 cm) ●● Drywall covering the wall must not exceed 5/8 in. (1.5 cm) ●● Minimum wood stud size: common 2 x 4 in. (5.1 x 10.2 cm) nominal 1 ½ x 3 ½ in. (3.8 x 8.9 cm) ●● Minimum horizontal space between fasteners:16 in. (40.6 cm) ●● Stud centers must be verified 12 Min. 3 ½ in. (8.9 cm) Min. 16 in. (40.6 cm) Max. 5/8 in. (1.
4 POSITION TEMPLATE Visit HeightFinder™ Extended Wall Plate 09 sanus.com /2567 09 Min. 16 in. (406 mm) Min. 16 in. (406 mm) CAUTION: Avoid potential personal injuries and property damage! FOR EXTENDED WALL PLATES: You MUST install 2 lag bolts 11 into the center (top and bottom) of wall plate 10 , then a minimum of 16 in. (406 mm) out from center, for a minimum of 6 lag bolts total. TIP: To calculate your precise wall plate 10 location, check out our HeightFinder at sanus.com [www.sanus.com/2567].
STEP 2A 5 DRILL (continued) 2 ¾ in. (6.9 cm) 6 SECURELY TIGHTEN Extended Wall Plate 7/32 in. (5.5 mm) 11 10 10 11 09 CAUTION: Avoid potential personal injury or property damage! All lag bolts 11 MUST BE firmly tightened to prevent unwanted movement of the wall plate 10 . Ensure the wall plate is securely fastened to the wall before continuing on to the next step. 14 Go to STEP 3 on PAGE 18.
STEP 2B CAUTION: Avoid potential personal injury or property damage! Solid Concrete or Concrete Block Installation 1 POSITION TEMPLATE 09 ●● Mount the wall plate 10 directly onto the concrete surface (no surface covering) Visit HeightFinder™ sanus.com /2567 ●● Minimum solid concrete thickness: 8 in. (20.3 cm) ●● Minimum concrete block size: 8 x 8 x 16 in. (20.3 x 20.3 x 40.6 cm) ●● Minimum horizontal space between fasteners: 16 in. (40.
STEP 2B 2 DRILL (continued) 3 in. (7.6 cm) 3 INSERT ANCHORS 3/8 in. (10 mm) 12 09 CAUTION: drilldrill intointo the mortar between blocks.blocks. Never the mortar between CAUTION:Never 16 CAUTION: CAUTION: Be sure the anchors 12 are seated flush with the concrete surface.
4 SECURELY TIGHTEN 10 Extended Wall Plate 11 10 11 CAUTION: Avoid potential personal injury or property damage! All lag bolts 11 MUST BE firmly tightened to prevent unwanted movement of the wall plate 10 . Ensure the wall plate is securely fastened to the wall before continuing on to the next step.
Attach TV to Wall Plate STEP 3 1 2 HANG ATTACH HEAVY! You may need assistance with this step. 10 04 05 10 CAUTION: Avoid potential personal injury or property damage! For CONCRETE APPLICATIONS: TV brackets 04 and 05 MUST remain centered in wall plate 10 . For extended wall plates: TV brackets 04 and 05 must only hang on the OUTER sections of wall plate 10 .
Adjustments LEVEL HEIGHT 13 To level your TV, turn the level adjustment screw S on the top of either TV bracket 04 and 05 to raise or lower that respective side of the TV. 05 RAISE LOWER S 04 Adjust the height by turning the level adjustment screw S on the top of both TV brackets 04 and 05 .
TILT TV LATERAL SHIFT CAUTION: Avoid potential personal injury or property damage! For CONCRETE APPLICATIONS: TV brackets 04 and 05 MUST remain centered in wall plate 10 . Your TV should adjust easily when moved, then stay in place. Adjust the tilt tension knob T if your TV naturally tilts up or down. 1 NOTE: If you do not intend to adjust the tilt for different viewing locations, you can tighten the tilt tension knobs T to prevent unwanted movement.
REMOVING THE TV CAUTION: Avoid potential personal injury or property damage! To prevent breaking the locking latch: always pull and hold release tabs R down while pulling the TV away from the wall. NOTE: To rehang the TV, follow the procedures in STEP 3 on PAGE 18.
Troubleshooting If you are uncertain about your hardware selection, contact Customer Service. TV Supplied Spacers TV supplied spacers a: Use your TV supplied spacer/adapter for flat back TVs (AND you want your TV closer to the wall).
Dimensions TV INTERFACE in. [mm] FOR SMALL PARTS PANEL MAX WALL PLATE 52.93 [1344.5] 33.43 [849.1] MIN WALL PLATE 31.50 [800.0] 16.73 [425.0] WALL PLATE 12.00 3-D FRONT VIEW 43.31 [1100.0] 7.87 [200.0] TILT RANGE 24.00 ]609.6[ 23.62 17.72 [600.0] [450.0] 16.00 [406.4] 8.00 8.86 [225.0] [203.2] 12.00 11.81 [304.8] [300.0] ø 0.33 ESTIMATED 55" TV WITH CENTERED 400X400 VESA 32.49 [825.3] 17.53 [445.3] 8.00 [203.2] 7° 6.98 [177.4] [8.
IT’S TIME TO SHOW OFF When you share your handiwork with your friends, tag #sanusspaces for a chance to be featured in the Inspiration Gallery on SANUS.com. SANUS.com SanusSystems pinterest.com/Sanus SanusSystems WE MAKE IT EASY CHAT WITH US BE INSPIRED WATCH AND LEARN Legrand AV Inc. 6436 City West Parkway Eden Prairie, MN 55344 USA US: 800-359-5520 • SANUS.com Legrand AV Netherlands B.V.
