Owner`s manual

ECO-X 36-52 / IL-X 150-200 Manual

IM100116

RD: MAY 2009

RL: 05A - BA

TO BE COMPLETED BY THE LICENSED INSTALLER:

HIGH INTENSITY COMMISSIONING REPORT

TYPE OF GAS: NG LP

DOES BUILDING HAVE A NEGATIVE CONDITION: YES NO

WILL HEATER BE EXPOSED TO WELDING FUMES: YES NO

IS HEATER EXPOSED TO CHEMICAL OR CORROSIVE ATMOSPHERE: YES NO

IS AN OPEN FLAME COMPATIBLE WITH THE INSTALLED LOCATION: YES NO

MINIMUM CLEARANCES CONFORM AS PER I&O MANUAL: YES NO

IF THIS IS A HIGH ALTITUDE AREA WHAT IS THE ALTITUDE ABOVE SEA LEVEL

IS HEATER SHORT AXIS HORIZONTAL WITH THE VENTURI ON TOP: YES NO

IS HEATER INTERLOCKED WITH AN EXHAUST FAN SYSTEM: YES NO

IS FAN SYSTEM 3 CFM PER 1000Btu/hr OF THE TOTAL HEAT LOAD: YES NO

WILL HEATER BE AFFECTED BY OVERHEAD CRANES / VIBRATION: YES NO

IS GAS SUPPLY LINE ADEQUATELY SIZED FOR SYSTEM VOLUME: YES NO

HAVE GAS LINES AND BRANCHES BEEN PURGED OF AIR: YES NO

THIS HEATER WAS FIELD TEST FIRED WITHOUT ANY MALFUNCTION: YES NO

INLET GAS SUPPLY PRESSURE WITH HEATER OPERATING: WC"

GAS VALVE OUTLET (Manifold) PRESSURE WITH HEATER OPERATING: WC"

HAS THE WIRING POLARITY BEEN MAINTAINED THROUGHOUT: YES NO

WHAT IS THE VOLTAGE READING AT THE IGNITION MODULE: VOLTS

WHAT IS THE FLAME SIGNAL STRENGTH IN uA FROM SENSOR: uA (microamps)

IS THE HEATER CONTROLLED BY A THERMOSTAT: YES NO

IS THE THERMOSTAT STRATEGICALY LOCATED: YES NO

TOTAL HEATERS SUPPLIED FROM ONE SINGLE TRANSFORMER: TOTAL

WHAT IS THE RATING OF THE TRANSFORMER IN VA: V.A.

WHAT IS THE TOTAL LENGTH OF THE LOW VOLTAGE WIRING: FEET

WHAT IS THE GAUGE OF THE LOW VOLTAGE WIRING: GAUGE

THIS HEATER MUST HAVE GOOD ELECTRICAL GROUNDING:

* FAX COMPLETED FORM TO TECHNICAL SERVICES: CANADA - 905-712-8336 USA - 706-554-9390

Feet

1-866-361-0523

LUMINOUS HEATER COMMISSIONING REPORT

IS HEATER LONG AXIS HORIZONTAL (LEVEL)

IS FAN SYSTEM CAPACITY (4 cfm /1000 Btuh USA; 300 cfm / 100,000 Btuh

Canada) CORRECT FOR THE TOTAL HEAT LOAD: