Instruction Manual

SP-MSTR-AU-05A

STR Manual

RD: NOV, 2003

RL: 5

TO BE COMPLETED BY THE LICENSED INSTALLER:

LOW INTENSITY START-UP

TYPE OF GAS: NG LP

DOES BUILDING HAVE A NEGATIVE CONDITION: YES NO

IS THIS A HIGH ALTITUDE AREA - (OVER 2000 FT ABOVE SEA LEVEL) YES NO

IF HIGH ALTITUDE WHAT IS THE ACTUAL ALTITUDE ABOVE SEA LEVEL FEET

DOES ENVIRONMENT REQUIRE FRESH AIR TO BURNER YES NO

IS HEATER EXPOSED TO CHEMICAL OR CORROSIVE ATMOSPHERE: YES NO

MINIMUM CLEARANCES ARE AS RECOMMENDED IN TABLE 3 YES NO

WILL HEATER BE AFFECTED BY OVERHEAD CRANES / VIBRATION YES NO

IS GAS SUPPLY LINE ADEQUATELY SIZED FOR SYSTEM VOLUME YES NO

GAS LINES AND BRANCHES HAVE BEEN PURGED OF AIR: YES NO

THIS HEATER WAS FIELD TEST FIRED WITHOUT ANY MALFUNCTION: YES NO

INLET GAS SUPPLY PRESSURE WITH HEATER OPERATING : WC"

GAS VALVE OUTLET (Manifold) PRESSURE WITH HEATER OPERATING: WC"

WHAT IS THE LINE VOLTAGE READING AT THE HEATER VOLTS

WHAT IS THE VOLTAGE READING AT THE IGNITION MODULE VOLTS

IS IT CONTROLLED BY A THERMOSTAT YES NO

IS THE THERMOSTAT STRATEGICALY LOCATED YES NO

WHAT IS THE TOTAL LENGTH OF THERMOSTAT WIRE FEET

WHAT IS THE GAUGE OF THE THERMOSTAT WIRE GAUGE

WHAT IS THE LENGTH OF THE HEATER (10ft per Tube) FEET

WHAT TOTAL LENGTH IS THE VENTING SYSTEM (add 10ft for each bend) FEET

WHAT LENGTH IS THE COMBUSTION AIR SUPPLY(add 10ft for each bend) FEET

IF REQUIRED....WHAT IS THE LENGTH OF THE TURBULATOR(S) FEET

IF INSTALLED....IS TURBULATOR AT VENT END OF SYTEM YES NO

DOES THE HEATER HAVE GOOD ELECTRICAL GROUNDING YES NO

Page 24