SCHWINN STINGRAY ELECTRIC WARNING • Age range for use: 10 to 16 years of age. • Maximum loading: 200 lbs. • NEVER carry a passenger on a StingRay Electric. Manufactured for Pacific Cycle, Inc. (A Division of Dorel Industries) Pacific Cycle, Inc. 4902 Hammersley Road Madison, WI 53711 800-666-8813 www.schwinnstingray.com Customer Service/Warranty • 877-741-6154 • service@pacific-cycle.com © 2005 Pacific Cycle, Inc.
TABLE OF CONTENTS Introduction.................................................................. 03-04 Service and Repairs ..........................................................05 Charge the Battery ...................................................... 06-07 Safety Rules ................................................................. 08-10 Get to Know Your StingRay Electric ..........................11-12 Before Every Ride .............................................................
WARNING FOR THE SAFETY OF YOUR CHILD, READ ALL WARNINGS AND ASSEMBLY/USE INSTRUCTIONS. KEEP THIS GUIDE FOR FUTURE REFERENCE. • SEVERE INJURY OR DEATH can result if you do not follow the instructions in this manual. • ADULT ASSEMBLY REQUIRED. The product contains small parts, which are for adult assembly ONLY. Keep small children away when assembling. • ALWAYS remove protective material and plastic bags and dispose of properly before assembly.
KEEP THIS MANUAL This manual should be considered a permanent part of the vehicle and should remain with the vehicle when resold or otherwise transferred to a new owner or operator. The manual contains important safety information and instructions which should be read carefully before operating the StingRay Electric. FOR ALL PARTS NOT COVERED IN THIS MANUAL, SEE STINGRAY BICYCLE OWNERS MANUAL.
SERVICE AND REPAIRS Write the serial number of your StingRay Electric here for future reference. When speaking to Customer Service, you will need to provide the model number (xxxx) and the serial number, found on the front of the frame. MODEL NUMBER _______________________________ SERIAL NUMBER _______________________________ • Complete and return registration card to validate your warranty (see warranty information on page 22).
CHARGE THE BATTERY • The StingRay Electric uses two 12-volt DC batteries to supply power to a 250 watt motor. • Charge batteries for 12 hours before use. • Failure to charge battery according to directions will permanently damage battery and void the warranty. WARNING PREVENT FIRE AND ELECTRIC SHOCK: • NEVER use a different charger to charge the battery. A fire or explosion could occur. ALWAYS use the charger supplied with your Electric StingRay. • NEVER use charger for any other product.
WARNING • ONLY ADULTS may charge battery. NEVER allow a child to charge battery. Serious injury could occur. • DO NOT charge battery if you see wear or damage to the battery, connections and wires, charger and its supply cord. • DO NOT allow battery to drain completely. Permanent damage to battery could occur. Recharge battery after each use. If not used often, recharge once a month. • DO NOT remove batteries from battery case. 1.
SAFETY RULES WARNING SEVERE INJURY OR DEATH can result if you do not follow the instructions in this manual. • Age range for use: 10 to 16 years of age. DO NOT allow children younger than 10 years of age to operate the StingRay Electric. • Maximum loading: 200 lbs. NEVER exceed maximum load capacity for the StingRay Electric. Overloading could cause changes in the way the StingRay Electric handles, and could lead to an accident.
• NEVER attempt wheelies, jumps or other stunts. • ALWAYS inspect the StingRay Electric each time it is used to make sure it is in safe operating condition. Refer to "Before Every Ride" and "Care and Maintenance" sections in this manual. • ALWAYS keep both hands on handlebars and both feel on footrests of the StingRay Electric during operation. • ALWAYS keep both eyes on the terrain ahead. DO NOT look down to work controls. • ALWAYS go slowly and be extra careful when operating on unfamiliar terrain.
• ALWAYS use caution going down hills. ALWAYS use caution when braking while going down hills. Check terrain carefully before you start down any hill. ALWAYS shift weight backward. NEVER go down a hill at the fast speed. DO NOT go down a hill at an angle that would cause the vehicle to lean sharply to one side. Go straight down the hill when possible. • ALWAYS check for obstacles before operating in a new area. NEVER attempt to ride over large obstacles, such as large rocks or fallen trees.
GET TO KNOW YOUR STINGRAY ELECTRIC Throttle Fuse Holder Brake Levers Battery Box Motor 11
3 lights Throttle The Throttle is on the right handlebar. Turn throttle forward to make the StingRay Electric go forward. 2 lights 1 light below low Battery Light The battery light will glow only when the StingRay Electric is powered up. When battery is fully charged, three lights will glow. When battery partially drained, two lights will glow. When battery needs to be recharged, only one light will glow. See "Charge the Battery" section, on pages 8-10.
BEFORE EVERY RIDE • An adult should ALWAYS perform the following checklist before every ride, for the safety of your child and to keep the StingRay Electric in good working order. • If you find any damaged or worn parts, DO NOT use the StingRay Electric. Refer to "Service and Repairs" on page 5 to order new parts or find an authorized repair center. WARNING • Failure to inspect the StingRay Electric before operating it can be hazardous, increasing chances of an accident or damage to the StingRay Electric.
CARE AND MAINTENANCE Your StingRay Electric will provide years of fun, if properly cared for and maintained. If you find damaged or worn parts, DO NOT use the StingRay Electric. Refer to "Service and Repairs" on page 5 to order new parts or find an authorized repair center. CLEANING Keep your StingRay Electric clean so it will look good and perform at its best. DO NOT allow mud to dry on the StingRay Electric. ALWAYS remove mud, brush, grass or excessive dirt from the StingRay Electric after every ride.
TIRE MAINTENANCE WARNING • ONLY an adult can inflate the tires. NEVER allow a child to inflate tires. • ONLY use bicycle pump to inflate tires. DO NOT inflate tires at a gas station, as the greater pressure of the pumps may cause a blowout. Serious injury or death could occur. • ALWAYS maintain tire pressure at 30 psi. NEVER inflate the tires over 30 psi. • To inflate a tire, remove cap from the valve stem and set aside. Attach bicycle pump and inflate to 30 psi. DO NOT over-inflate tire.
BRAKE LEVER WARNING • NEVER allow the StingRay Electric to be used if the brake lever is not functioning properly. • The brake lever may become loose over time. Tighten screw nut connecting brake cable to brake lever. • Squeeze brake lever and make sure the StingRay Electric cannot be pushed forward. Start motor and make sure brake is working properly. FUSE • If the electrical system or batteries are overloaded, a fuse in the battery will blow, and the StingRay Electric will shut down.
BATTERIES READ ALL WARNINGS ABOUT BATTERY SAFETY. ONLY ADULTS MAY RECHARGE OR HANDLE BATTERIES. • The StingRay Electric uses two 12-volt batteries to supply power to a 250-watt motor. • Recharge batteries after each use. When batteries are fully charged, three lights on the StingRay Electric Throttle will glow. When batteries are partially drained, two lights will glow. When batteries need to be recharged, one light will glow. • Eventually, the batteries will no longer hold a charge.
REPLACING THE BATTERIES ONLY ADULTS MAY REPLACE THE BATTERIES • Replace the batteries with genuine Schwinn parts. Do not use another brand, as this may void your warranty. Refer to "Service and Repairs" on page 5 to order parts or to find an authorized repair center. •Turn off, and unplug battery case • Unscrew the thumbscrew holding the battery box on left side of bicycles. Remove and properly dispose of spent batteries. • Install new batteries and reconnect battery cables.
TROUBLESHOOTING PROBLEM PROBABLE CAUSE WHAT TO DO The StingRay Electric does not run. • Batteries are low • Recharge the batteries • Batteries are dead • Replace the batteries. See page 18. • Fuse has blown • Turn power off, replace fuse. • Wires are loose • Reconnect wires and connectors. • Electrical system has been damaged by water. Dirt or sand has jammed the switch. • Refer to "Service and Repairs" on page 5 to find an authorized repair center. • Motor is damaged.
PROBLEM PROBABLE CAUSE WHAT TO DO Batteries will not recharge • Charging plug is not plugged in all the way into the charging outlet of the StingRay Electric. • Firmly insert plug into outlet. • Charger is not plugged into the wall outlet. • Plug charger into the wall outlet. • Charger is damaged. • Refer to "Service and Repairs" on page 5 to order parts or find an authorized repair center. • Batteries are dead. • Replace batteries. See page 18. • Battery is undercharged.
PROBLEM PROBABLE CAUSE StingRay Electric runs sluggishly. • Batteries need recharging. WHAT TO DO • Recharge batteries. See page 7. • Batteries are old. • Replace batteries. See page 18. • StingRay Electric is overloaded. • Maximum weight: 200 lbs. Reduce weight on StingRay Electric. Do not tow anything with the StingRay Electric.
90 DAY WARRANTY LIMITED WARRANTY - PLEASE SAVE YOUR ORIGINAL SALES RECEIPT The express limited warranty as contained herein is exclusive and in lieu of all other warranties, express or implied, including implied warranties of merchant ability and fitness for a particular purpose. There are no warranties that extend beyond the description in this limited warranty.
