Specifications

ManualsBrandsScion ManualsAutomotive2005 tC

SCION tC 2005 - VSE SUBWOOFER (BAZOOKA

)

Preparation

Part Number: PTS20-21050

NOTE: Part number of this accessory may not be

the same as the part number shown.

Kit Contents

Item # Quantity Reqd. Description

1 1 Vehicle Specific Enclosure

(VSE) Subwoofer

2 1 Wire Harness

3 1 Hardware Bag

4 1 Installation Instructions

5 1 Product Feature Placard

6 1 Service Care Card

Hardware Bag Contents

Item # Quantity Reqd. Description

1 2 7” Wire Ties

2 2 4” Wire Ties

3 8 Philips Head Screws

4 1 Upper Mounting Hardware

Assembly

5 1 Lower Mounting Hardware

Assembly

Additional Items Required For Installation

Item # Quantity Reqd. Description

Conflicts

SCION tC Cargo Net – PN: PT347-52051

Recommended Tools

Personal & Vehicle

Protection

Notes

Vehicle Protection Seat/Floor Covers

Part Protection Blankets

Special Tools Notes

Arch Punch 5/8” Hole Diameter

(McMaster PN: 3427A17)

Mallet Rubber Mallet

Screwdriver 1.5” Long Narrow Blade

Flat Head (Craftsman PN:

41541 or equivalent)

Installation Tools Notes

Nylon Panel Removal Tool e.g. Panel Pry Tool #1

Toyota SST # 00002-06001-

Socket/Ratchet 10mm, 12mm & 13mm

Socket Extension 6 inch (optional)

Ratcheting Box End Wrench 13mm

Torque Wrench

3 lbf·ft , and 15 lbf·ft

Pliers 1. Diagonal Cutters

2. Long Nose (optional)

Screwdriver Magnetized Philips # 2

Electric Drill Philips # 2 Drill Bit

Special Chemicals Notes

Cleaner 3M

Prep Solvent–70 (if

required)

General Applicability

ALL SCION tC

Recommended Sequence of Application

Item # Accessory

1 Security / Audio / Satellite Tuner

2 Rear Cargo Mat / Cargo Liner

3 VSE Subwoofer

4 Door Sills

*Mandatory

Vehicle Service Parts (may be required for reassembly)

Item # Quantity Reqd. Description

Legend

STOP: Damage to the vehicle may occur. Do not

proceed until process has been complied with.

OPERATOR SAFETY:

Use caution to avoid risk of

injury.

CAUTION:

A process that must be carefully observed

in order to reduce the risk of damage to the

accessory/vehicle and to ensure a quality installation.

TOOLS & EQUIPMENT:

Used in Figures calls out the

specific tools and equipment recommended for this

process.

REVISION MARK:

This mark highlights a change in

installation with respect to previous issue.

VSE Subwoofer Specifications

Woofer Size 10 Inch

Voice Coil Size 1.5 Inch

Magnet Size 34 oz

Frequency Response 28Hz-100Hz +/-3dB

Efficiency 96 dB

Power Handling 150 watts (woofer)

Dimensions 745mm x 390mm x 370mm

Weight 22 lbs

Impedance Dual 2 Ohms

Page 1 of 17 pages

Issue: A 04/15/04

Summary of content (17 pages)

PAGE 1
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Preparation NOTE: Part number of this accessory may not be the same as the part number shown. Part Number: PTS20-21050 Kit Contents Item # 1 2 3 4 5 6 Quantity Reqd. 1 1 1 1 1 1 Description Vehicle Specific Enclosure (VSE) Subwoofer Wire Harness Hardware Bag Installation Instructions Product Feature Placard Service Care Card Quantity Reqd.
PAGE 2
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Procedure Care must be taken when installing this accessory to ensure damage does not occur to the vehicle. The installation of this accessory should follow approved guidelines to ensure a quality installation. These guidelines can be found in the "Accessory Installation Practices" document. This document covers such items as:• Vehicle Protection (use of covers and blankets, cleaning chemicals, etc.). • Safety (eye protection, rechecking torque procedure, etc.).
PAGE 3
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Procedure (d) Proceed to remove and secure the rear foam passenger side storage compartment. (1) Remove the two (2) plastic plugs and pull the block straight up. (Fig. 3-2) Fig. 3-2 (e) Proceed to remove and secure the rear bench seat, by pulling upwards on each corner, to release the two (2) mounting clips. (Fig. 3-3) (f) Using the 2 release handles, lower the driver and passenger side rear seat backs. Fig.
PAGE 4
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Procedure Release with Screwdriver Plastic Hook (i) Using a 10mm socket, remove the passenger rear D-Ring (Tie Down Hook) (discard) and save the 10mm bolt for reuse. (j) Remove and save, the Philips head screw from the upper rear passenger panel & save for reuse. (k) Remove & discard passenger rear taillight access panel. Fig. 3-6 (l) Using the 1.
PAGE 5
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Procedure (d) Remove the radio unit, by removing the two (2) top 10mm nuts and two (2) bottom screws from the radio bracket. (Fig.4-3) (e) Open the glove compartment latch and press the outside edges of the glove compartment inwards, to remove. (Fig.4-4) Fig. 4-3 Fig. 4-4 (1) Detach the glove compartment damper prior to removal. (Fig.4-5) Fig. 4-5 (f) Using a NRT, remove passenger front scuff plate by carefully pulling upward. (Fig.
PAGE 6
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Procedure Fig. 5-1 5. Routing Wire Harness (a) Starting at the rear of the vehicle, route the pig tail end underneath the rear strut reinforcement access panel, and route towards rear passenger side taillight. (Fig.5-1) 1 2 Fig. 5-2 3 (b) Using the 12mm socket, remove the #3 Child Restraint bracket bolt, & re-install groud ring underneath bracket. (Fig.
PAGE 7
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Procedure Fig. 5-5 (g) Attach wire harness with one (1) 4” wire tie at the junction plug located underneath kick well. (Fig.5-5) (1) Using the diagonal cutter pliers, clip the 4” wire tie. (Fig.5-5) Fig. 5-6 (h) Route wire harness up behind the dash and secure wire harness to the dash reinforcement bar using (1) 7” wire tie. (1) Using the diagonal cutter pliers, clip the 7” wire tie. (Fig.5-6) Fig.
PAGE 8
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Procedure flat washer and lock nut using a 13mm ratcheting box end wrench or socket from behind the inner sheet metal panel. (Fig.7-2) (1) Make sure antenna wire harness runs underneath hardware assembly (Fig.7-2) (c) With the upper hardware assembly installed, index the outer rear quarter panel by positioning panel over the hardware stud and use the 5/8” Hole Punch & Mallet to punch a hole through the panel. (Fig.
PAGE 9
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Procedure (e) Referencing Step 3. b, reassemble the rear Cargo Floor panel & floor mat (if equipped). Fig. 9-1 (f) Referencing Step 3. a, reassemble the rear Tonneau Cover. (g) Referencing Step 3. e, reassemble the rear bench seat. 9. Install VSE Subwoofer Fig. 9-2 (a) With the pigtail exiting the inner quarter panels’ taillight access hole, connect the pigtail to the VSE Subwoofer. (Fig.
PAGE 10
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Procedure 10. In Process Functional Test. (a) Reconnect the vehicle’s negative battery cable. (1) Position the negative terminal at an angle of 90˚ to the battery as shown. (2) Tighten the nut with 4.1 N-m (36 lbf-in) of torque. (3) Be careful not to touch the positive battery terminal. (b) Referencing Step 4. d., reassemble the Radio by connecting: 1) T-Harness into the back of the Radio2) the Satellite harness (if equipped) and 3) the radio antenna cable.
PAGE 11
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Procedure 11. Reassemble Front Cabin Interior Components (a) Referencing Step 4. g - f., reassemble all panels into their original locations, making sure that all clips are securely fastened. (b) Referencing Step 4. e., reassemble glove compartment & strut to its original location, making sure that all clips are securely fastened. (c) Referencing Step 4. c., carefully reconnect the vehicle harness back onto the center IP.
PAGE 12
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Procedure 12. Resetting Vehicle Components (a) Reset the power windows. (1) Turn ignition key to ON position. (2) Push down the power window switches of each door, and lower the windows halfway. (3) Pull up the switches until the windows close and hold switches up for a further one (1) second (minimum.) (b) Reset the power moon roof. (1) Push and hold moon roof switch to close side until moon roof closes. Hold for a further two (2) seconds. 13.
PAGE 13
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Procedure 14. Clean Up (a) Clean up and remove any trash. (b) If required, wipe down all applicable interior surfaces with 3MTM Prep Solvent-70, to remove fingerprints, etc (1) When cleaning with 3MTM Prep Solvent70: (2) Always use a clean (lint free, scratch resistant) soft cloth (or wipe), and clean a small area at a time ( ~ 3 ft. x 3 ft. max.). (3) Shake Well. (4) Apply 3MTM Prep Solvent-70 to cloth or wipe.
PAGE 14
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA®) Troubleshooting. Condition: Check For: Accessory Function Checks Turn on Radio Radio display turns on & sound is heard Verify CD & Satellite Tuner (if equipped) CD player functions & Satellite Tuner stations are playing (if equipped) Antenna is functioning Reception of AM/FM stations VSE Subwoofer operation VSE Subwoofer – Listen to VSE Subwoofer to make sure it is functioning properly or by feeling the VSE Subwoofer for vibration.
PAGE 15
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Troubleshooting. Condition: Check For: No sound from VSE Subwoofer, however factory speakers still play 1. Is the green L.E.D. lit on the VSE Subwoofer? If not, check for 12 volts on pins of the VSE Subwoofer with the ignition on. If either pin doesn’t indicate 12 volts, check T-Harness connectors behind the radio. 2. Is the 14-pin Molex connector securely connected to the VSE Subwoofer? 3.
PAGE 16
SCION tC VSE SUBWOOFER (BAZOOKA®) 2005 - Troubleshooting. Condition: Check For: Dimming Radio Lights Dimming Radio Lights could occur when the VSE Subwoofer is played at high volumes. Radio does not come on Check to ensure that the main connector, antenna connector, and auxiliary connector have been correctly plugged back in. No Sound at all 1. Is the fuse under the hood still operational? 2. Is the battery ground reconnected? 3.
PAGE 17
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA®) Wire Harness & Radio Wiring Schematics. WIRING CONNECTOR SCHEMATICS: Harness Split Pin No. Wire Color 1 2 3 4 5 6 Red White/Black Gray/Black Blue/White White Gray Radio Connector Subwoofer Connector Harness Split Connector Function 12 Volt Battery Connection (B+) Left Front Speaker (-) Right Front Speaker (-) Remote Turn-On/Ignition (Switched+) Left Front Speaker (+) Right Front Speaker (+) Subwoofer Connector Pin No.