www.scott-sports.com All rights reserved © 2014 SCOTT Sports SA SCOTT Sports SA | 17 Route du Crochet | 1762 Givisiez | Switzerland Distribution: SSG (Europe) Distribution Center SA P.E.D Zone C1, Rue Du Kiell 60 | 6790 Aubange | Belgium V4.
ENGLISH ENGLISH CONTENTS Bicycle Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 04 www.scott-sports.com Saddle Height . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 05 Chain Tension . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
IMPORTANT! If you purchased this bicycle for a minor, it is essential that a responsible adult thoroughly reads and explains the safety instructions in this manual to the minor. Please ensure your SCOTT bike is completely assembled by your authorized SCOTT dealer. This ensures that your bike is correctly set up to optimize safety, performance and fun while riding. It is important to understand the basics of and exercise common sense when cycling.
-- Finally make the fine tuning with adjustment screw B as mentioned above. The wheel needs to spin free without touching the brake pads. Fix counter nut A. GENERAL BRAKE ADJUSTMENT ENGLISH ENGLISH BRAKES IMPORTANT! Your SCOTT bike is fitted with a reliable and well-functioning braking system, provided the brakes are correctly adjusted. Check by measuring the distance between the brake shoes and the rim: it should be 1.5 to 2 mm. Make sure that the brake works perfectly.
Remove the shoe fixing pin shoe fixing pin ENGLISH ENGLISH TIRES AND RIMS Replacement of the brake pads/cartridge shoe Tires should always be inflated within the manufacturer’s recommendations. They are rated from 40 to 80 lbs. (check your tires). Higher pressure for smoother roads or heavy riders. Lower pressure for more shock absorption on rougher terrains. For example: Remove the shoe by sliding it along the groove of the shoe holder INFLATE TO MIN. 3.5 (50PSI) - MAX. 6.
Bicycle wheels are designed to be removable for easier transportation and for repair of a tire puncture. In most cases, the wheel axles are inserted into slots, called “dropouts” in the fork and frame, but some suspension mountain bikes use what is called a “through axle” wheel mounting system.
SCOTT bikes such as Racing Concept, Racing, Endurance, Progressive, Road, Roadster and Kids Series are not intended to be used with baby seats. Please note that SCOTT will not take any warranty or responsibility when using a baby seat on bikes mentioned above. There are too many different baby seat and baby seat fixation systems on the market to give a detailed table of systems that might fit without technical problems or endangering the passengers.
-- Chain wear and tension (on bikes equipped with internal gear hubs). Readjust if necessary, clean and grease the chain. -- Bottom bracket cartridge for play, replace it if necessary. -- Pedal bearings for play, replace them if necessary. -- Front and rear derailleur for perfect function and grease them. Readjust the system and clean it if necessary. -- Stem and handlebar for visible damage and replace them if necessary.
PART Rear Derailleur MOUNTING BOLT -- Mounting bolt -- Cable fixing bolt -- Pulley screws MAX. TORQUE 7.8-9.8 Nm 3.9-5.9 Nm 2.9-3.9 Nm TROUBLE REASON SOLUTION Fork Shakes Headset Loose Tighten and Lock Chain Pops Out -- Derailleurs Not Adjusted -- Adjust According to Manual -- Chainwheel Bent -- Fix or Change Front Derailleur -- Clamp -- Cable fixing bolt 4.9-6.8 Nm 4.9-6.8 Nm -- Bottom Bracket -- Replacement Rapidfire lever -- Clamp mounting bolt 4.9-6.
WARRANTY What is Covered? How Do You Make a Claim Under This Limited Warranty? This warranty covers defects in materials and workmanship at the time of transfer of risks in frames, swingarms and forks (provided it is a fork of SCOTT) on SCOTT branded bikes sold completely assembled by SCOTT or an authorized SCOTT dealer (“Product”).
PARTS OF WEAR AND TEAR ARE EXCLUDED FROM ANY WARRANTY. TIRES The tires are subject to wear and tear due to their use. The extend of the wear and tear depends on the maintenance and conditions the bike is subjected to and is influenced by the owner's riding style. ENGLISH ENGLISH PARTS OF WEAR AND TEAR Aggressive braking will reduce the lifetime of the tire dramatically. CHAIN The chain is subject to wear and tear due to its use.
SCOTT SERVICE PLAN Model . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Model . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Year . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SCOTT SERVICE PLAN Model . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Model . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Year . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .