Operating instructions

66
DISCONNECT THIS HOSE
Lower hose as necessary so that drain-
ing can take place.
Reconnect fitting when done.
Also ensure air compressor drain line
is not obstructed. Clean as necessary.
Body Rinsing/Repair
Wash the body with soap and water so-
lution (only use mild detergent). Rinse
thoroughly with fresh water. Remove
marine organisms from the hull.
CAUTION: Never clean fiberglass and
plastic parts with strong detergent,
degreasing agent, paint thinner, ace-
tone, etc.
For small gelcoat repairs, refer to an au-
thorized SEA-DOO dealer. Replace dam-
aged labels/decals.
Propulsion System
Lubricant in jet pump reservoir should
be drained and reservoir cleaned. Re-
fer to an authorized SEA-DOO dealer
for this operation.
Grease lubrication point(s) of propulsion
system as explained in MAINTENANCE
section.
Fuel System
SEA-DOO fuel stabilizer (or equiva-
lent), can be added in fuel tank to pre-
vent fuel deterioration. Follow manu-
facturer’s instructions for proper use.
CAUTION: Fuel stabilizer should be
added prior to engine lubrication to
ensure fuel system components pro-
tection against varnish deposits.
Cooling System Flushing and
Engine Internal Lubrication
Refer to procedure in POST-OPERATION
CARE.
Battery
Contact your authorized SEA-DOO
dealer.
Antifreezing Protection
NOTE: This procedure requires approx-
imately 2.5 L (2.6 U.S. qt.) of antifreeze.
In cool regions where freezing point
may be encountered, cooling system
should be filled with an equal part of
water and antifreeze solution.
F07E0HY

WARNING
Fuel is inflammable and explosive
under certain conditions. Always
work in a well ventilated area. Do
not smoke or allow open flames or
sparks in the vicinity. Fuel tank may
be pressurized, slowly turn cap
when opening. Never use an open
flame to check fuel level. When fu-
eling, keep watercraft level. Do not
overfill or top off the fuel tank and
leave watercraft in the sun. As tem-
perature increases, fuel expands
and might overflow. Always wipe
any fuel spillage from the watercraft.
smo2003-005a.book Page 66 Friday, November 1, 2002 8:25 AM