Technical data

Section 08 ELECTRICAL SYSTEM
Sub-Section 05 (INSTRUMENTS AND ACCESSORIES)
08-05-3
The resistance measured between PINK / BLACK
and PINK wires must be in accordance with fuel
level (measured from under the flange) as speci-
fied in the following charts.
Oil Sensor
The sensor sends the signal to the low-oil level
light in the fuel gauge.
The bottom of the sensor has a small reservoir
with two small holes underneath to let the oil en-
ter inside and one at the top to let the air enter
allowing the oil to flow out.
When there is enough oil inside the oil tank (and
therefore in the sensor reservoir), the sensor de-
tects the liquid and the light DOES NOT turn on.
When the oil level goes at critical LOW level in-
side the oil tank (and therefore in sensor reser-
voir), the sensor detects the absence of liquid and
the light TURNS ON.
To check the oil sensor, unplug its connector and
pull sensor out of oil tank.
Using an ohmmeter, check the continuity be-
tween the BLUE and BLUE / BLACK terminals.
When sensor is out of oil tank and its reservoir is
empty, resistance must be infinite (open circuit).
NOTE : Wait about 15-20 seconds before
taking any reading to give the oil enough
time to flow out or inside sensor reservoir.
Soak sensor in oil so that its reservoir fills up.
Maximum resistance should be approximately 2
Ω (closed circuit).
1. Measure resistance here
2. Sensor reservoir
To reinstall sensor :
– Remove rubber seal from sensor.
– Install seal in oil tank hole.
– Push sensor in seal.
– Plug connector.
FUEL LEVEL AND RESISTANCE
(SPI, SPX, XP)
FUEL LEVEL
(mm)
RESISTANCE
(Ω)
From 206.1 ± 5 and more
0 ± 2.2
0
From 189.1 @ 206 ± 5 17.8 ± 2.2
From 162.1 @ 189 ± 5 27.8 ± 2.2
From 135.1 @ 162 ± 5 37.8 ± 2.2
From 108.1 @ 135 ± 5 47.8 ± 2.2
From 81.1 @ 108 ± 5 57.8 ± 2.2
From 54.1 @ 81 ± 5 67.8 ± 2.2
From 40.1 @ 54 ± 5 77.8 ± 2.2
From 0 @ 40 ± 5 89.8 ± 2.2
FUEL LEVEL AND RESISTANCE
(GTS, GTI)
FUEL LEVEL
(mm)
RESISTANCE
(Ω)
From 257.9 ± 5 and more
0 ± 2.2
0
From 234.4 @ 257.8 ± 5 17.8 ± 2.2
From 200.9 @ 234.3 ± 5 27.8 ± 2.2
From 167.4 @ 200.8 ± 5 37.8 ± 2.2
From 134 @ 167.3 ± 5 47.8 ± 2.2
From 100.5 @ 133.9 ± 5 57.8 ± 2.2
From 67 @ 100.4 ± 5 67.8 ± 2.2
From 40.1 @ 66.9 ± 5 77.8 ± 2.2
From 0 @ 40 ± 5 89.8 ± 2.2
TEST CONDITION READING (Ω)
Sensor OUT of oil. ∝(open circuit)
Sensor soaked IN oil. 2 Ω max. (closed circuit)
F03H0BA
1
2
www.SeaDooManuals.net