SEAFLO is one of the professional manufacturer focuses on Researching, Developing and selling RV pumps and Marine water pumps. The patented design delivers smooth，consistent flow at all ranges of operation, while drawing low current. The balanced motor design incorporates precision ball bearings for long life, motor is equipped with an integral thermal breaker. All RV/marine duty pumps have sealed switches and are finished with a Electro Coating to inhibit corrosion.
ELECTRICAL ·The pump should be on a dedicated (individual) circuit protected by the specified fuse indicated on the motor label. · A U/L, CE ect approved marine duty (ignition protected) switch rated at above 15 amps is recommended and must interrupt current flow on the positive (+ red) lead. · The pump must be grounded to a known ground (battery). The ground wire must be the same size (gauge/Mm2) as the positive wire. · Wire Sizing: Proper wire sizing is required for good pump operation.
SANITIZING: Potable water systems require periodic maintenance to deliver a consistent flow of fresh water. Depending on use and the environment the system is subject to, sanitizing is recommended prior to storing and before using the water system after a period of storage. Systems with new components, or ones that have been subjected to contamination, should also be disinfected as follows: 1. Use one of the following methods to determine the amount of common household bleach needed to sanitize the tank.
WILL NOT PRIME/SPUTTERS :( No discharge/Motor runs) NOISY OR ROUGH OPERATION: Is the strainer clogged with debris? Is there water in the tank, or has air collected in the hot water heater? Is the inlet tubing/plumbing sucking in air at plumbing connections (vacuum leak)? Is inlet/outlet plumbing severely restricted or kinked? Proper voltage with the pump operating (+_10%) For debris in pump inlet/outlet valves or swollen/dry valves. Pump housing for cracks or loose drive assembly screws.
Component PSI/Bar GPM[LPM] Amps 1 Pressure switch 0/0 3.0[11.3] 2.8 Pump head 10/0.7 2.3[8.7] 3.2 2 20/1.4 1.9[7.2] 4.2 NO LIMITED WARRANTY 3 Valve plate assembly 30/2.1 1.6[6.0] 5.1 SEAFLO warrants its RV/Marine Duty Fresh Water Pumps to be free from material and workmanship defects under 4 Diaphragm/ Drive assembly 40/2.8 1.4[5.3] 6.1 normal use and service for a period of one(1) year form the date of purchase. In the absence of proof of purchase 5 Motor 50/3.4 0.8[3.
