EN Vacuum toilet system Operation manual DE Abwasser-Auslasspumpe Bedienungsanweisung . . . . . . . . . . . . 12 FR Pompe d’évacuation Mode d’emploi . . . . . . . . . . . . . . . . . 12 ES Bomba de descarga Manual de instrucciones . . . . . . . . . . 12 NL Aftappomp Instructihandleiding . . . . . . . . . . . . . . 12 IT Pompa di scarico Manuale di istruzioni . . . . . . . . . . . . . 12 FI Tyhjennyspumppu Käyttöohje . . . . . . . . .
SeaLand 4700 Series VacuFlush Toilet 11 1 1 2 10 A 9 8 4 2 7 3 6 B 5 3 B C G A D F E 4 4 2 10 6 9 1 7 8 3 5 2
SeaLand 4700 Series VacuFlush Toilet Notes on using the manual Table of contents 1 2 3 4 5 6 7 8 9 1 EN Notes on using the manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 General safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 4 Intended use . . . . . . . . . . . . . .
General safety instructions SeaLand 4700 Series VacuFlush Toilet Caution! Hazard of Flooding If the toilet uses fresh water for flushing and is connected directly or indirectly to a shoreside municipal water system at ANY time, shoreside water connections MUST be disconnected if the boat is unattended (even if boat is unattended for a brief period). Failure to do so can result in flooding which can cause loss of property and life.
SeaLand 4700 Series VacuFlush Toilet 4 Components 4.1 4700 series VacuFlush toilet (fig. 1 , page 2) Ref. Description Intended use (fig. 2 , page 2) Ref.
Components SeaLand 4700 Series VacuFlush Toilet 5 Specifications 5.1 Materials Toilet body: vitreous ceramic Toilet seat: thermoset plastic resin or wood (seats vary according to toilet model) Discharge fitting: PVC 5.2 Approvals CE, REACH and ROHS compliant components 5.3 Toilet installation specifications Electrical Amp draw (average) 2 amps at 12 V DC; 1 amp at 24 V DC Fuse 2-amp internal fuse (resettable) * Water Supply Fitting 0.5 in. NPT Flow rate 4.
SeaLand 4700 Series VacuFlush Toilet 6 Operation 6.1 Toilet system start-up Specifications 1. Fill freshwater tank. 2. Turn on electrical power and water supply to toilet. 3. Flush water through toilet system by flushing toilet five times (allow each flush cycle to complete until green light indicates system is ready for next flush). Each cycle takes about one minute. 6.
Operation 6.4 SeaLand 4700 Series VacuFlush Toilet Indicator lights “OK TO FLUSH” GREEN INDICATOR Wall Switch DVS01 Panel Wall Switch DVS01 Panel A steady green “OK to Flush” light indicates when the toilet is ready to flush. A momentary flashing green light indicates when flush mode is changing. “DO NOT FLUSH” RED INDICATOR A red “Do Not Flush” red light indicates two toilet system conditions: 1. Vacuum level in toilet system is not sufficient for complete flush. 2.
SeaLand 4700 Series VacuFlush Toilet 7.2 Maintenance/winterizing/service VacuFlush system maintenance Maintenance procedures vary widely and depend on factors such as frequency of use, quality of flushing water, etc. The chart provides a general guideline for keeping your toilet system ready for use at any time. Maintenance procedure Service interval Notes ROUTINE Check all clamped hose joints below water line for leaks. Monthly — Check filter screen in water valve.
Maintenance/winterizing/service SeaLand 4700 Series VacuFlush Toilet 5. Turn off power to the vacuum pump. 6. Completely pump out holding tank. If system will be subjected to freezing temperatures, please follow above procedure, then winterize system as described in Section 7.7. TURN OFF ELECTRICITY AND WATER TO TOILET IF IDLE FOR LONG PERIODS OF TIME If people will not be using the boat for a long time (vacation, maintenance, off-season, etc.
SeaLand 4700 Series VacuFlush Toilet 7.8 Maintenance/winterizing/service Troubleshooting guide Toilet base assembly Electric flush handle Vacuum Breaker Bowl Seal Flush Ball Seal Electric Water Valve Retaining Ring Filter Screen Motor Flush Ball Drive Arm Linkage Rotor Shaft Cam Flush Spring Cam Switch Circuit Board Caution Use an ohmmeter and wiring diagrams of toilet and vacuum system when troubleshooting electrical problems. Problem 1. Water does not enter bowl and toilet does not flush.
Maintenance/winterizing/service Problem 2. Water enters toilet bowl, but toilet does not flush. SeaLand 4700 Series VacuFlush Toilet Possible Cause a. Green “OK to Flush” light is not lit on status panel. b. Electrical failure from flush switch or flush handle to toilet. c. Flush switch or handle may be defective. d. Loose flush ball motor wires. e. Defective flush ball motor. f. Flush ball motor drive arm failure. g. Drive linkage failure. 3. Water does not enter toilet bowl, but toilet flushes. a.
SeaLand 4700 Series VacuFlush Toilet Problem 9. Flush ball does not open completely. Maintenance/winterizing/service Possible Cause Service Instruction a. Rotor shaft cam is loose or defective. b. Weak or defective spring assembly. c. Excessive drag between flush ball and seal. a. See instructions for repair or replacement on pages 14-15. b. Replace spring. 10. Squeaky noise occurs during flush cycle. a. Lubrication needed between flush ball and seal. b.
Maintenance/winterizing/service 7.9 SeaLand 4700 Series VacuFlush Toilet Servicing toilet base components ALIGNING CAM SWITCH/FLUSH BALL The flush ball should be properly positioned so that the “A” and “B” distances are equal (see illustration at right). If the flush ball becomes misaligned (resulting in water leaking from bowl or other flushing problems), follow instructions below to resolve problem. REMOVING TOILET FROM FLOOR 1. Turn off water and electrical power to toilet. 2.
SeaLand 4700 Series VacuFlush Toilet Maintenance/winterizing/service REPLACING THE FLUSH BALL REPLACING THE ROTOR SHAFT CAM 1. Turn off water to toilet. 1. Follow disassembly steps 1 through 14 under “Replacing the Flush Ball”. 2. Open flush ball in Service Mode, then turn off power to toilet. 3. Disconnect water inlet hose. 4. Remove toilet from floor and turn upside down, and disconnect Service Switch wires at in-line connectors. 5.
Warranty 8 SeaLand 4700 Series VacuFlush Toilet Warranty and product liability North America and Rest of the World: Manufacturer’s One-Year Limited Warranty Dometic Corporation, Sanitation Division warrants to the original purchaser only that this product, if used for personal, family or household purposes, is free from defects in material and workmanship for a period of one year from the date of purchase.
SeaLand 4700 Series VacuFlush Toilet Warranty Europe: Warranty and Customer Service Warranty arrangements are in accordance with EC Directive 44/1999/CE and the normal conditions applicable for the country concerned. For warranty or other service, please contact our Dometic Customer Service department. Any damage due to improper use is not covered by the warranty.
Customer service 9 SeaLand 4700 Series VacuFlush Toilet Customer service There is a strong, worldwide network to assist in servicing and maintaining your sanitation system. For the Authorized Service Center near you, please call from 8:00 a.m. to 5:00 p.m. (ET) Monday through Friday. You may also contact or have your local dealer contact the Parts Distributor nearest you for quick response to your replacement parts needs. They carry a complete inventory for the SeaLand product line.
SeaLand 4700 Series VacuFlush Toilet Notes 19
SeaLand 4700 Series VacuFlush Toilet Dometic Group is a customer-driven, world-leading provider of leisure products for the RV, automotive, truck and marine markets. We supply the industry and aftermarket with a complete range of air conditioners, refrigerators, awnings, cookers, sanitation systems, lighting, mobile power equipment, comfort and safety solutions, windows, doors and other equipment that make life more comfortable away from home.