EN Vacuum pedal-flush toilet operation manual 508+ 706 500 Plus Series, 706 Model VacuFlush® Toilets For VacuFlush toilet models 506+, 508+, 547+, 548+, 706 1
VacuFlush Pedal-Flush Toilet 1 2 A F C B B A D C E 3 1 3 2 4 D 7 10 5 8 E 6 9 4 2 3 10 6 9 1 7 8 4 5 2
VacuFlush Pedal-Flush Toilet Notes on using the manual Table of contents 1 2 3 4 5 6 7 8 9 1 EN Notes on using the manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 General safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 4 Intended use . . . . . . . . . . . . . . . . .
General safety instructions VacuFlush Pedal-Flush Toilet Caution! Hazard of Flooding If the toilet uses fresh water for flushing and is connected directly or indirectly to a shoreside municipal water system at ANY time, shoreside water connections MUST be disconnected if the boat is unattended (even if boat is unattended for a brief period). Failure to do so can result in flooding which can cause loss of property and life.
VacuFlush Pedal-Flush Toilet 4 Components Components (fig. 3 , page 2) Ref. 4.1 1 (fig. 2 , page 2) Ref. Description VacuFlush toilet Seat and lid assembly (fig. 3 , page 2) A 2 Ceramic bowl 3 Vacuum breaker 4 Water supply hose 5 Half clamp kit 6 Pedestal base 7 Flush pedal lever (cover not shown) 8 Water valve 9 Inlet screen 10 Pedestal cover Description Vacuum status panel (DVS01 - option) (fig.
Specifications 5.2 VacuFlush Pedal-Flush Toilet Toilet installation specifications Electrical Water Supply Discharge Required component Vacuum pump* draw 6 amps at 12 V DC; 3 amps at 24 V DC Circuit breaker/fuse 10 amps at 12 V DC; 5 amps at 24 V DC Fitting 0.5 in. NPT Flow rate 2.0 gpm/7.6 lpm minimum required at toilet Size 1.5 in./38 mm ID PVC pipe or sanitation hose Horizontal run** 50 ft./15 m maximum to vacuum source Vertical run** 6 ft./1.
VacuFlush Pedal-Flush Toilet 6 Operation 6.1 Toilet system start-up Operation 1. Fill freshwater tank. 2. Turn on electrical power and water supply to VacuFlush toilet system. 3. Flush water through entire toilet system by pressing flush pedal for about 15 seconds. Release pedal, allowing pedal to snap back into original position. Vacuum pump will operate for about one minute, then shut off. 6.
Maintenance/Winterizing/Service VacuFlush Pedal-Flush Toilet 7 Maintenance / Winterizing / Service 7.1 Cleaning the toilet To maintain the toilet’s original, lustrous appearance, use SeaLand® Toilet Bowl Cleaner or other non-abrasive bathroom and toilet bowl cleaners. Please follow label directions. Caution To avoid damaging the toilet system’s seals and valves, do not clean toilet with abrasive cleaners, caustic chemicals, or lubricants and cleaners that contain alcohols or petroleum distillates. 7.
VacuFlush Pedal-Flush Toilet 7.4 Maintenance/Winterizing/Service During extended periods of non-use Sanitation hoses should be cleared if toilet will not be needed for an extended period of time (more than two weeks). 1. Fill toilet bowl with water and add 4 oz. (120 ml) of liquid biodegradable laundry detergent (should NOT contain bleach). 2. Flush toilet, holding pedal down for about two minutes. Close flush ball. 3. Turn off water supply to toilet. 4.
Maintenance/Winterizing/Service 7.7 VacuFlush Pedal-Flush Toilet Troubleshooting guide BASE ASSEMBLY VACUUM BREAKER REAR VIEW, VACUUM TOILET CAP WATER HOSE CONNECTION VACUUM BREAKER/BOWL CONNECTION Problem Possible Cause Service Instruction 1. Water will not stay in bowl. a. Loose clamp ring. b. Improper seal around flush ball due to dirt or debris on flush ball or under flush ball seal. c. Worn or damaged seal. d. Worn or damaged flush ball. a. Tighten clamp ring adjusting nut. b.
VacuFlush Pedal-Flush Toilet Problem Maintenance/Winterizing/Service Possible Cause 4. Water does not shut off in toilet (toilet overflows). 5. Water does not enter toilet bowl properly. Service Instruction a. Not enough clearance between pedal and top of water valve cap. b. Dirt lodged in water valve seal. a. Adjust cam strap so clearance is .06 in. (1.5 mm) max. a. Insufficient water flow rate at toilet. b. Water valve clogged. a. Check water flow rate at toilet. Rate should be 2 gpm (7.6 lpm). b.
Maintenance/Winterizing/Service Problem 12. Vacuum pump will not run. VacuFlush Pedal-Flush Toilet Possible Cause a. No electrical power. b. Loose or broken electrical wiring. c. Improper electrical connections. d. Faulty vacuum switch. e. Faulty motor. f. Shut-down relay prevents pumping. 13. Vacuum pump is running too slow, overheating, blowing fuses or circuit breaker. a. Gear motor is worn, defective. b. Plugged vent line or vent filter. c. Blockage in discharge line. d. Improper wire size. e.
VacuFlush Pedal-Flush Toilet Problem 15. Blockage between toilet and vacuum generator. Maintenance/Winterizing/Service Possible Cause a. Collapsed vacuum line. b. Sharp bends or kinks in vacuum hose. c. Improper operation of toilet. d. Foreign objects were flushed down toilet. 16. Pump emits odor. a. Loose or defective hose connection on pump. b. Loose intake or discharge fittings on pump. c. Worn, torn or punctured pump bellows (vacuum generator) or diaphragm (vacuum holding tank).
Warranty 8 VacuFlush Pedal-Flush Toilet Warranty and product liability North America and Rest of the World: Manufacturer’s One-Year Limited Warranty Dometic Corporation, Sanitation Division warrants to the original purchaser only that this product, if used for personal, family or household purposes, is free from defects in material and workmanship for a period of one year from the date of purchase.
VacuFlush Pedal-Flush Toilet Warranty / Customer Service Europe: Warranty and Customer Service Warranty arrangements are in accordance with EC Directive 44/1999/CE and the normal conditions applicable for the country concerned. For warranty or other service, please contact our SeaLand Customer Service department. Any damage due to improper use is not covered by the warranty.
VacuFlush Pedal-Flush Toilet Convenience products for SeaLand toilet systems Many marine dealers offer SeaLand deodorants, toilet tissue and other accessories to make using and maintaining VacuFlush toilet systems as easy as possible. SeaLand® Rapid-Dissolving Toilet Tissue Four 500-sheet rolls Item No. 379441204 SeaLand® Clean ‘n Green Bowl Cleaner & Tank Deodorant 12-2 oz. drop-in pouches Item No. 379512602 SeaLand® Liquid Tank Deodorant Four 8-oz. bottles Item No.