ASSEMBLY, OPERATING INSTRUCTIONS AND PARTS LIST FOR another free manual from www.searstractormanuals.com SIEArt, S SUBURBAN TRACTOR MODEL NO. 917.99400 - RECOIL STARTER MODEL NO. 917.99410 - ELECTRIC STARTER SEARS ROEBUCK AND CO. PART NO. 6547H SEARS, ROEBUCK AND CO.-U.S.A. SIMPSONS-SEARS LIMITED-CANADA PRINTED IN U.S.A.
TABLE OF CONTENTS another free manual from www.searstractormanuals.
SEARS another free manual from www.searstractormanuals.com ROEBL,K AND CO . . . WE GUARANTEE the Sears Tractor to be free from defects in materials and workmanship for a period of one (1) year from date of sale. This also includes the gasoline engine which is warranted for a period of one (1) year by the gasoline Should a defect appear within the guarantee period, we will, at our option, either repair or replace the defective part without cost to you.
INTRODUCTION Your Tractor is ruggedly built for plenty of stamina and long life. You will delighted with its ease in maneuvering. The design of your Tractor will give you the superior performance you have a right to demand of any tractor of this size. Properly adjusted, maintained and operated, it will respond to every reasonable demand you make upon it, and will give you reliable service for years. another free manual from www.searstractormanuals.
PARTS IDENTIFICATION another free manual from www.searstractormanuals.com FOOT PEDAL — FOOT REST FIG. B CHOKE IGNITION SWITCH REMOTE CONTROL (throttle lever) LIGHT SWITCH SHIFT LEVER RANGE SHIFT LEVER (High-Low Range) FIG.
SETTING UP INSTRUCTIONS A number at the beginning of a paragraph in the following instructions refers to an arrow in the adjoining figure except when otherwise stated. When R.H. (Right Hand) and L.H. (Left Hand) are used, it should be understood to to mean from a position behind and facing the tractor (or direction of travel). Reference to "front" indicates the engine and hood end of tractor, and the "rear" the transmission. Remove carton from around tractor. Cut banding holding tractor to crate bottom.
BEFORE STARTING ENGINE LIFT COWLING another free manual from www.searstractormanuals.com 1. To lift cowling, grasp each side of cowling, at rear and pull outward and upward Lift cowl ing to its extreme open position. FIG. I FOR RECOIL STARTER 1. Advance throttle lever to about 1/2 throttle. 2. Turn key clockwise to on position. re (I) and 3. Grasp recoil starter handle See Figure pull sharply to start engine. Do not allow starter rope to snap back. Repeat until engine starts.
another free manual from www.searstractormanuals.com TO OPERATE TRACTOR ENGINE LUBRICATION 1. Try your tractor in a large, open space. Learn start, stop and reverse. to 2. Start the engine and put the remote control lever at about 1/2 throttle. Push down on foot pedal, move gear shift lever and range lever to speed desired. Release foot pedal slowly, and tractor will start to move. After foot pedal is fully released (clutch engaged) move remote control lever to fast psoition.
BELT ADJUSTMENT IDLER BRACKET FRAME _ IDLER PULLEY BELT 62-" another free manual from www.searstractormanuals.com FLAT IDLER FOOT PEDAL 1. Loosen bolt in flat idler and frame, and push idler and bolt down in slot of frame until center of idler pulley on idler bracket (just back of engine) is 6-12 inches above frame as shown. Tighten bolt in flat idler and frame securely. NOTE: Foot pedal should be in vertical or just back of vertical position with clutch engaged.
another free manual from www.searstractormanuals.com MAINTENANCE AND SERVICE FIG. N FIG. L STARTER GENERATOR BELT AIR CLEANER 1. Remove 3 screws (A) holding belt guard to engine. 2. Loosen bolt (B) in generator adjusting strap and generator, move starter generator back to tighten belt and tighten bolt (B) securely. Belt should be tight enough to prevent belt tractor. when starting slippage Clean air cleaner periodically.
IMPORTANT - BATTERY CARE TIRES Proper attention to the battery on units so equipped is of the utmost importance. Keep tires inflated to 15 pounds of air in front, 8 pounds in rear. To repair a punctured tire, front wheel may be removed by unscrewing cap screw from front spindle and sliding washer and front wheel complete with tire from spindle. NOTE: Bolt on L.H. front wheel has L.H. threads. Remove rear wheel by unscrewing three hub bolts from wheel and hub.
TROUBLE SHOOTING HARD TO START another free manual from www.searstractormanuals.com No gasoline in fuel tank or carburetor. Fill fuel tank: open fuel shut off valve. Check fuel line, fuel strainer and carburetor. Remove fuel strainer and clean. Clean fuel line and carburetor. Fuel strainer, or fuel line clogged Drain fuel from tank and carburetor. Refill with fresh clean gasoline. Remove and dry spark plug and reset plug gap. Replace wire on spark plug. Water in gasoline or old fuel.
SEARS SUBURBAN 10 HP TRACTOR -- MODEL NUMBERS 917.99400 & 917.99410 A A 16 D another free manual from www.searstractormanuals.com 15 14 14 13 ./ NIVV1A/14/14/. Y D 17 29 18 1 32 21 t,20 1H 22 26 25 ce 24 23 27 R 70 '`' 69 68 33 34 66 0 65 71 64 63 37 58-4 60-6 -Ca 59 50-"" .,c, T 43 51 "45 40 38 42 44 44V- 60 0,62 ," 59-45,° 55 56 54 48 53 /1.. 4 (19,_ 52 51 'K OPQRST , 73 c) Cn 74 91 03 c94 77 53Cn 90O 3 T ©89 © 86 87 88 4rip .
SEARS SUBURBAN 10 H.P. TRACTOR -- MODEL NUMBERS 917.99400 AND 917.99410 PARTS LIST another free manual from www.searstractormanuals.com KEY NO. PART NO.
SEARS SUBURBAN 10 HP TRACTOR -- MODEL NUMBERS 917.99400 & 917.99410 4 17 19 16 18 20 -1-- another free manual from www.searstractormanuals.com 14 / 1 21 —4 -§P1-7- _- --_-. cZZD / 11 I5 ;3' 13 \ \ 4 6 sio r- 9 i • I i, 1 ti i8 t\ -'1, 7 7 , , --/--1 1 I I 13 61 L.- 22 60 -4_ 12 29 31 ,/ 23 28 36 -.
SEARS SUBURBAN 10 H.P. TRACTOR -- MODEL NUMBER 917.99400 AND 917.99410 PARTS LIST KEY NO. another free manual from www.searstractormanuals.com 1 2 3 4 5 6 7 8 9 PART NO. 6368H 6740H 98000071 19252016 5138H 5949H 6468H 626A31.
SEARS SUBURBAN 10 FfP TRACTOR -- MODEL NUMBERS 917.99400 & 917.99410 21 3 E 33 Y 34 23 another free manual from www.searstractormanuals.com 26 m 25 )k ': •--.
• SEARS SUBURBAN 10 H.P. TRACTOR -- MODEL NUMBER 917.99400 & 917.99410 PARTS KEY NO. another free manual from www.searstractormanuals.com >< - -- PART NO. 3 4 5 6 7 8 9 6636H 634A24 -177923 9416771.
SEARS SUBURBAN 10 HP TRACTOR -- MODEL NUMBER 917.99410 if 6 cif9 — - 3 another free manual from www.searstractormanuals.com 2 \ 12 10 11 14 13 CP.
• SEARS SUBURBAN 10 H.P. TRACTOR -- MODEL NUMBER 917.99410 another free manual from www.searstractormanuals.com PARTS KEY NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 5072H 19091216 3748M 5110H 6121H1 120375 51111-11 3754H1 120233 6419H 273589 120377 606A325 6593H 5797H 132900 17 18 19 5913H 6534H 122052 LIST KEY NO. DESCRIPTION Battery Bolt Washer 17/64 x 1/4 x 16 qu..
another free manual from www.searstractormanuals.com SEARS SUBURBAN 10 HP TRACTOR -- MODEL NUMBER 917.
A.V71709110g :ammo 1:1 SEARS TO THE PURCHASER... Below is listed the model number of TRACTOR GUARANTEE your Sears Tractor as well as the date of your purchase. Keep this certificate with your valuable papers. This information will prove helpful should you need to -wail yourself of your guarantee rights or if you need to order repair parts during the ISSUED TO years of service which have been built another free manual from www.searstractormanuals.com into this fine piece of equipment.
SEARS SUBURBAN 10 H. P. TRACTOR -- MODEL NO. 917.99410 PARTS another free manual from www.searstractormanuals.com KEY NO. 1 2 3 4 5 6 7 8 9 PART NO. 6541H 6540H 6539H 6538H 5740H 5731H 5735H 6440M 120361 DESCRIPTION Tie Lead Wire Lead Wire Lead Wire Wire Connector Head Light Bracket Light Switch Tail Light Bracket Hex Nut #10 -24 LIST KEY NO. PART NO. 10 187463 11 12 6537H 120272 13 14 15 16 17 273588 120376 6651H 5734H 19161004 18 19 5732H 5736H DESCRIPTION Truss Hd.
SUY: elr WRIT WIF SELL 1 tiller where you live in the another free manual from www.searstractormanuals.com ire. Your Sears Tractor takes on new value when you discover that Sears has 2000 Service units around the country using 7500 fully-equipped trucks and staffed by 10,000 factory-trained technicians. These men are Service Professionals who back up all Sears guarantees. They use Sears approved parts and methods for expert repairs to fulfill the pledge: "We Service What We Sell".
