SE_AR8 OWNERS MANUAL MODEL NO. 919,150270 CRAFTSMAN COMPACT AIR COMPRESSOR Listed 7"21Y Record In the spaces provided. Air Compressor (1) The model number which can be found On the Io1_1 on the back of tha unit.
TABLE OF CONTENTS WARRANTY SAFETY ....................................................... GUIDELINES WARNING GENERAL AND CHART .............................. 3 CHART ................................................. SPECIFICATION .GLOSSARY 3 4 CHART .......................................... s ........................................................ INFORMATION DESCRIPTION UNPACKING ,5 ........................................ OF OPERATION INSTRUCTIONS 5 ..................................
FULL ONE YEAR WARRANTY ON AIR COMPRESSORS If this air compressor fails due to a def_-t in material or workmanship within one year from the date of purchase, return it to the nearest Sears Service Canter/Department throughout the United States and Sears will repair it, free of charge.
HAZARDSCAN N, , OCCUR IF EQUIPMENT IS NOT USED PROPERLY. READ THE FOLLOWING CHART ,,,,,,, ,,,,,,,i WHAT TO LOOK FOR ,,,,,,,,, ,1111 HOW TO PREVENT IT Hot Parts The top of the compressor gets hot when the compresSOr is running. If you touch it, you may be seriously burned. Nevertouchthetopoftheaircompressor during or immediately after operation. Always use the handle, Flammabie _/a_ It is normal for the motor's etectrical contacts to spark when the compressor starts or stops.
SPECIFICATION CHART Model No. 919.1S0270 Horsepower SCFM @ 40 psig SCFM @ 9O psig Disptecement CFM Bore Stroke Voltage-Single Phase Minimum Branch Circuit Requtrem_mt "Fuse Type Amperage at Max. Pressure _/, 2.7 2.0 4.0 2%" ,9" 110-120 15 AMPS Time Delay 10.6 "A circuit breaker is preferred. Use only a fuse or circuit breaker that is the same rating as the branch cimult the air compressor is operated on. If the air compressor is connected to a circuit pmtented by fuses, use time delay fuses.
INSTRUCTIONS Tools Needed for Unpacking A +/2"socket wrench. Grasp the handle _und lift the air compressor out of the carton. Remove the styrofoam and plastic brace. Note the plastic brace attached to the air compres_ sot"by a hex screw, Using a _h" socket wrench, remove the hex screw. Dlacard both the screw and the plastic brace. ASSEMBLY INSTRUCTIONS Tools Needed for Assembly Turn your compressor on its side. . 2, insert eyelet into rubber fool A phillips screwdriver. Installing rubber feet.
OPERATING PROCEDURES 1. Before plugging in the air compressor, set the adjustable pressure valve to =Start-. Make sure the _ONOFF* switch is in the "OFF" position. 2. Connect the air hose to the air outtet aclapter.Tighten securely. 7. Slowly Jr=creasethe pressure setting ofthe adjuatabI pressure valve. You should be able to hear and fe, air pressure being relieved by the adjustable pressu_ valve. If pressure is not being relieved, turn the a compressor off immediately. The pressure valv must be replaced.
STORAGE Motor I_eplaP.,ement - Wiring Diagram m./_ K .... Conna=t When you have finished using the air c0mp_ssOr:. IG - s._ 2. Relieve all pressure from the air ¢ompressor head and air hose by turning the adjustable pressure valve to the "Start" position. =i! ii! 1;= I I L'--= "I !i i = 3. Protect the electrical cord and air hose frOmdamage by winding them loosely around the air compressor. tP, II 1. Set the "ON-OFF" switch to _OFF" and unplug the ' cord. 4.
TROUBLESHOOTING GUIDE WAINING F ,,,, ,, ., i I IIIIIIII VOLTAGE SOURCES, MOVING PARTS, OR COMPRESSED AIR SOURCES ARE EXPOSED WHEN REPAIRING THE COMPRESSOR. PERSONAL INJURY CAN OCCUR. UNPLUG THE COMPRESSOR AND BLEED OFF ALL AIR PRESSURE BY TURNING THE ADJUSTABLE PRESSURE VALVE TO THE START POSITION BEFORE ATTEMPTING ANY REPAIRS. PROB "' i CAUSE I_EM ....... ,,,, Air Leaks , ,,,.., i i ,,,,,,,,, ,,,,,,,,,, ,,,,,,,,, i ,,,,,,,,,., Hose firing loose, ,, ,,N.
NR COMPRESSOR DIAGRAM [ s L 14 17 15 16 22 21 PARTS LIST KEY NO. 1 2 3 4 5 6 7 8 g 10 11 12 PARTNUMBER LA-G25 SSF-8129-ZN LA-1780-1 CAC-4259 SSW-7428 SST-S_ STDSt0807 SSN-S3 STD6108f0 mESCRFTION Not used Hot surfaea label Locimut 1/,_-20 (2 used) Not used Warning label Rear shroud assembly Sears logo label not available _(3 Recess bumper (3 used) Screw #8 AB x % LG Rat washer (2 used) Screw #8 ABx I LG (=.ead) !0 .sed) KEY NO.
COMPRESSOR PUMP OIAGRAM PARTS LIST KEY NO. 26 27 28 29 30 31 PART NUMBER DESCRIPTION CAC-280-2 CAC-1018 Filter Intake muffler Not used Not used Set screw Shoulder stud _':20 SSF-2043 SSF-6637 26 27 x 11/e" 31A (2 used) 31A SSF-927 Screw %%20 x 11/8" (2 used) *,'n,'32 33 CAC-4234 CAC-245-1 SSF-98_! 35 CAC-251-2 36 CAC-38g 37 "_'_ 38 39 J" 40 _" 41 42 43 44 45 NOT CAC-246-3 CAC.