Manual and User Guide
Table Of Contents
- TABLE 1
- Figure 1
- INSTALLATION CODES
- CODES D'INSTALLATION
- TO TURN GAS OFF TO APPLIANCE
- COMMENT COUPER L’ADMISSION DE GAZ
- L’APPAREIL
- The minimum vent system for horizontal termination must consist of:
- The maximum horizontal vent system consists of:
- The minimum vent system for horizontal termination must consist of:
- The maximum horizontal vent system consists of:
- The minimum vent system for horizontal termination must consist of:
- The maximum horizontal vent system consists of:
- The minimum vent system for horizontal termination must consist of:
- The maximum horizontal vent system consists of:
- The minimum vent system for horizontal termination must consist of:
- The maximum horizontal vent system consists of:
- The maximum vertical system consists of:
- Apply RTV high temperature
- sealant around male pipe.
- 3.3.9 PRIMARY AIR ADJUSTMENT / AJUSTEMENT DE L'AIR PRIMAIRE
- CORRECTIVE ACTION
- SYMPTOM
- 1. Weak or improperly located pilot flame
- 2. Defective thermocouple
- 3.Thermocouple not installed properly
- 4. Open wire connection in pilot circuit
- 5. Defective Valve
- 1. Loose or defective connections
- III. Main burner will not light
- 1. Valve control off
- 2. Blockage at the burner (line, orifice, or ports)
- 3. Defective remote
- 4. Defective wiring or connections
- 5. Defective Valve
- I. Soot deposits
- 1. Air inlet blocked or restricted
- 2. Vent system is restricted or inadequate
- 3. Logs are sooting up
- V. Flame burns blue and lifts off burner
- 1. Insufficient combustion air being supplied
- 2. Manifold pressure set too high
- 3. Vent system restricted
- VI. Main flame does not burn properly
- VII. Flames impinge on firebox top
- 1. Vent system is restricted or inadequate
- 2. Manifold pressure too high
- 8.0 LABEL INFORMATION
- WARNING
- Electrical Grounding Instructions
- APPENDIX A (AMERICAN FLAME VALVE INFORMATION)
- APPENDIX A (Continued)
- APPENDIX B (NG – LP CONVERSION KITS)
Page 3 of 54
Table of Contents
IMPORTANT SAFETY INFORMATION …………………………………………………………….. 4 – 5
1.0 INTRODUCTION .....................................................................................................................
1.1 Specifications, Appliance Dimensions & Installation Codes ................................. 6 - 7
1.2 Features, Remote Control Functions .................................................................. 8 - 10
1.3 Intended Use ............................................................................................................ 11
1.4 General Safety .................................................................................................. 11 - 12
2.0 OPERATION ...........................................................................................................................
2.1 Lighting Instructions ......................................................................................... 13 – 14
3.0 INSTALLATION ......................................................................................................................
3.1 Installation & Safety Notes ...................................................................................... 15
3.2 Unpacking ................................................................................................................ 15
3.3 Installation ............................................................................................................... 15
3.3.1 Minimum Clearances & Non Combustible Material Requirements .................. 16 - 18
3.3.2 Gas Line Installation ................................................................................................ 19
3.3.3 Direct Vent Information .................................................................................... 20 - 31
3.3.4 Glass Media Installation ........................................................................................... 32
3.3.5 Door Installation ................................................................................................ 33 – 34
3.3.6 Safety Screen ........................................................................................................... 34
3.3.7 Initial Firing .............................................................................................................. 35
3.3.8 Pilot Flame Adjustment ............................................................................................. 35
3.3.9 Primary Air Adjustment .................................................................................... 35 - 36
3.3.10 Altitude Adjustment .................................................................................................. 36
3.3.11 Fan Access ....................................................................................................... 36 - 38
3.3.12 Gas Valve Access .................................................................................................... 38
4.0 MAINTENANCE .....................................................................................................................
4.1 Maintenance Safety ................................................................................................. 39
4.2 Recommended Service ........................................................................................... 39
4.3 Glass Cleaning ........................................................................................................ 40
4.4 Burner & Pilot Cleaning ........................................................................................... 40
4.5 Valve & Pilot Replacement ............................................................................. 40 - 41
5.0 TROUBLE SHOOTING ……………………………………………………………….……. 41 - 42
6.0 REPLACEMENT PARTS ………………………………………………………………………...43
7.0 WARRANTY .………………………………………………………………………………....44 - 46
8.0 LABEL INFORMATION .………………………………………………………………….…47 - 48
APPENDIX A (INTERMITTENT PILOT & VALVE KIT)……………………....………………….49 - 52
APPENDIX B (NG – LP CONVERSION KITS)........................................................................52 - 54
BARRIÈRE conçu pour réduire le risque de
brûlures et à la consultation verre chaud EST
FOURNI AVEC CET APPAREIL ET DOIT SE.