Specifications

The hoist will be operated by means of a 12 volt electric pump with
integral oil reservoir and push button operator with 10 ft. cord.
The push button operator will have a lockable storage box to prevent
unauthorized access. The box can dump at up to a 51 degree angle.
The unit will be supplied with a pre-wired 12 volt battery and towing
vehicle charging system as well as a built in 110 volt/12 volt battery
charger for overnight charging.
DIESEL FIRED
Asphalt storage compartment shall be heated by a diesel fired 12VDC
burner.
Burner rating shall be a minimum of 105,000 BTU.
The diesel burner to be equipped with an automatic electronic ignition
system.
The diesel burner will supply primary combustion air and fuel into the
insulated fire box during operation.
It will be equipped with 100% safety fuel shut down if burner ignition
fails.
The combustion chamber temperature will be monitored.
(OPTION 10)
In the event of abnormally high temperature in in the chamber, the fuel
supply will be cut off the burner will automatically shut down.
The diesel burner heating system shall be thermostatically controlled.
The temperature settings shall be adjustable between 175 and 350 degrees
Fahrenheit.
The heating system will be supplied power by a 12 volt battery maintained
through the towing vehicle charging system; an on board 110 volt/12volt
battery charger to be supplied for overnight charging.
The heating system fuel supply tank shall contain a minimum of 25
gallons.
HYDRAULIC
SURGE
BRAKES
(OPTION 11)
Trailer shall be supplied with a 20,000# hydraulic brake actuator and dual
7000# (each) hydraulic brake axle assembly in place of the standard
electric brakes.
LOW TEMP
THERMOSTAT
(OPTION 12)
The heating system controls shall have an additional adjustable low range
thermostat (55 to 175 degree F.) and a toggle selector switch to allow
operation in either high or low temperature range.
24-HOUR
TIMER
(OPTION 13)
The main hotbox controls shall be supplied with an electromechanical
timer, 120 volt, single phase, to allow for unattended on/off control of the
hotbox thermostat circuit.
The timer shall be in a steel enclosure with Normally Open, DPST, 2 HP
rated contacts.
Minimum time setting to be 1 hour and maximum time setting to be 23
hours.
Maximum on/off cycles: 12.
DUMP BOX
(OPTION 9)