I N S TA L L AT I O N INSTRUCTIONS CARE AND USE MANUAL FOR: SIU 404 & SIU 405 ISLAND RANGE HOODS ***BEFORE INSTALLATION*** ENSURE THERE IS NO VISIBLE OR HIDDEN DAMAGE SUSTAINED DURING SHIPPING ***SHIPPING DAMAGE*** MUST BE REPORTED WITHIN 5 DAYS OF RECEIPT Telephone (Toll Free): 866.528.4987 Fax (Toll Free): 866.365.9204 www.siriushoods.com info@siriushoods.
WARNINGS Thank you for purchasing a Sirius Range Hood. Please read all the instructions in this manual before installing the appliance. Save these instructions for future reference. The appliance is not intended for use by young children or infirm persons without supervision. Young children should be supervised to ensure they do not play with the appliance. If the range hood is vented, the air so vented must be ducted into a dedicated duct that is not showed with any other equipment whatsoever.
TABLE OF CONTENTS BEFORE YOU BEGIN 1 MINIMUM AND MAXIMUMS 1 DUCTING 1 Duct Run Calculation 2 ELECTRICAL 2 Electrical Supply 2 INSTALLATION 2 Structural preparation for the hood fan installation 2 Fixing the Main Support Bracket 3 Attaching the range hood to the ceiling 4 Connecting Electricity and Ducting 4 Re-Circulating Requirements 5 Schematic of Classical Island Components 5 OPERATING PROCEDURES 6 General Advice 6 Functions 6 MAINTENANCE 7 Cleaning the Filter 7 Cleani
BEFORE YOU BEGIN The manufacturer declines all responsibility in the event of failure to observe the instructions given here for installation, maintenance and suitable operation of the product. The manufacturer further declines all responsibility for injury due to negligence and the warranty of the unit automatically expires due to improper maintenance and/or installation. BEFORE STARTING – please read this entire document and ensure you are fully conversant with the requirements and limitations.
heaters. To minimize the risk of drawing these lethal gases back into the home please follow the heating equipment manufacturers safety standards and guidelines. Refer to NFPA and ASHRAE for additional information. based on the table below. Duct Run Calculation Each 6” or 3 1/4 x 10” duct Maximum Run 6” or 3 1/4 x 10” duct Deduct Each 90 elbow used 15FT Each 45 elbow used 9FT Transition used The maximum duct run before effecting the performance of the hood is 100’.
and ideally not higher than 32”above the cook-top. It is strongly recommended, at this point, that calculations and measurements be made and all planning and heights be finalized. You will need to fit the appropriate length of ducting to the hood fan before installing it to the ceiling. Planning should consist of a test assembly of the power unit and telescoping structure before attempting to mount everything to the ceiling.
Fix Bracket “C” to the power unit with the nuts and washers supplied (Items “A” on the schematic on page 5). Please ensure that the bracket is installed as shown to enable full access to the square plastic black box and the metal electrical junction box. Slide Bracket “B” over Bracket “C” (once again ensure full access to the plastic and electrical boxes is maintained) and fix it in place, at the previously calculated length using the machine screws denoted by items “B” on the schematic on page 5.
Re-Circulating Requirements Fit the carbon filter after the installation is complete – these fit in behind the aluminum grease filter. A short length of ductwork must be connected from the exhaust outlet up to the deflector purchased with hood). (must be The deflector, after attaching part B with screws E connects to the top of Bracket “A” and forces the air out through the grills on the side of the chimney section back into the room. (see diagram C).
O P E R AT I NG P R O C E D U R E S Read all the instructions before operating the appliance. Save these instructions for future reference. General Advice Ensure that the grease filters are in place. Without these components, operating blowers could catch on to hair, fingers and loose clothing. Keep fan, filters and surfaces clean of grease and fat. Always turn hood fan ON when cooking. NEVER leave cooking unattended. Never pick up a flaming pan – you may be burned.
MAINTENANCE The hood-fan should provide many years of trouble free service provided it is maintained properly. Cleaning the Filter On the surfaces that are exposed directly to heat from the cook-top, it is advisable to clean these on a regular basis to avoid the marks from becoming baked on. Clean the grease filter either by carefully hand washing, (so as not to damage the filter design) or, preferabl y in a dis hwas her.
T h r e e Ye a r L i m i t e d W a r r a n t y WARRANTY SERVICE To qualify for warranty service, you must notify Sirius Range Hoods at the address stated below or call toll free USA or Canada 1-866-528-4987 and provide the model number, description of the fault or defect and original date of purchase. Sirius reserves the right to request proof of original purchase.
USA: SIRIUS RANGE HOODS (USA) LTD. 1051 Clinton Street Buffalo, NY 14206 Telephone (Toll Free): 866.528.4987 Fax (Toll Free): 866.365.9204 CANADA: SIRIUS RANGE HOODS LTD. 1252 Speers Road Unit 11 Oakville, ON L6L 5N9 Telephone: 905.257.0046 Fax: 905.847.0330 www.siriushoods.com Email: info@siriushoods.