User guide

ManualsBrandsSkyjacker ManualsCarHB-916

2007- 2014 Toyota Tundra

1"- 3” Performance Strut

Installation Instructions

www.skyjacker.com

I-TU730ST REV3 6-14 Pg 1

REQUIRED TOOL LIST:













Before beginning the installation, thoroughly & completely read these instructions & the enclosed

driver’s WARNING NOTICE. Affix the WARNING decal in the passenger compartment in clear view

of all occupants. Please refer to the Parts List to insure that all parts & hardware are received prior

to the disassembly of the vehicle. If any parts are found to be missing, contact SKYJACKER

Customer Service at 318-388-0816 to obtain the needed items. If you have any questions or

reservations about installing this product, contact SKYJACKER

Technical Assistance at 318-388-

0816.

Park the vehicle on a level concrete or asphalt surface. Many times a vehicle is not level (side-to-

side) from the factory & is usually not noticed until a lift kit has been installed, which makes the

difference more visible. Using a measuring tape, measure the front & rear (both sides) from the

ground up to the center of the fender opening above the axle. Record this information below for

future reference.

Driver Side Front: Passenger Side Front:

Driver Side Rear: Passenger Side Rear:



• If larger tires (10% more than the OEM diameter) are installed, speedometer recalibration will be

necessary. Contact your local Toyota dealer or an authorized dealer for details.

• After installation, a qualified alignment facility is required to align the vehicle to the OEM

specifications.

Summary of content (6 pages)

PAGE 1
2007- 2014 Toyota Tundra 1"- 3” Performance Strut Installation Instructions www.skyjacker.com Required Tool List: • • • • • • Safety Glasses Metric / Standard Wrenches & Sockets Floor Jack / Jack Stands Measuring Tape Strut Spring Compressor Torque Wrench Before beginning the installation, thoroughly & completely read these instructions & the enclosed driver’s WARNING NOTICE. Affix the WARNING decal in the passenger compartment in clear view of all occupants.
PAGE 2
Component Box Breakdown: Part #: TU730ST / TU730STBH / TU710R Item # TU713STS Description TOYOTA 1"-3" ADJ FRT STRUT (Included With TU730ST & TU730STBH Box) RBF125 1.
PAGE 3
7. Remove the upper strut mounting bolts from the OEM upper frame mounts & remove the OEM strut assemblies. 8. Using a strut spring compressor, unload the tension on the OEM upper mounts of the OEM strut assemblies. Remove the upper strut retaining nuts & remove the OEM struts from the bottom strut assemblies. (See Photo # 4) Note: There are six snap ring grooves located on the new Skyjacker strut body for 1" to 3" lift heights. The ring is installed in the second groove from the top when shipped.
PAGE 4
Rear Installation: 15. Block the front tires / wheels & raise the rear of the vehicle using a floor jack. Properly support the frame rails using jack stands & remove the rear tires / wheels. 16. Remove the OEM rear shocks & disconnect the OEM brake line bracket from the axle. 17. Remove the OEM rear u-bolts & lower the rear axle to allow for the installation of the new Skyjacker 1.25" rear lift blocks. Photo # 7 18. Install the new Skyjacker 1.25" rear blocks between the OEM leaf springs & rear axle. 19.
PAGE 5
Torque specificAtions Inch System Bolt Size 5/16 3/8 7/16 1/2 9/16 5/8 3/4 Grade 5 15 FT LB 30 FT LB 45 FT LB 65 FT LB 95 FT LB 135 FT LB 185 FT LB Metric system Grade 8 20 FT LB 35 FT LB 60 FT LB 90 FT LB 130 FTLB 175 FT LB 280 FT LB Bolt Size 6MM 8MM 10MM 12MM 14MM 16MM 18MM Class 8.8 5 FT LB 18 FT LB 32 FT LB 55 FT LB 85 FT LB 130 FT LB 170 FT LB Class 10.
PAGE 6
Jesus Forgives, Rocks don’t www.skyjacker.com Jesus Christ Died For You. Jesús murió por ti. For God so loved the world that He gave His only Son, so that everyone who believes in Him should not perish, but have everlasting life. Romans 3:23 “Porque tanto amó Dios al mundo, que dio a su Hijo unigénito, para que todo el que cree en él no se pierda, sino que tenga vida eterna.” Romanos 3:23 For all have sinned; all fall short of God’s glorious standard.