Service Manual User Manual

Section 2
2-12
2.5.7 Drive Shaft Splines
IMPORTANT: DO NOT disassemble any of the drive
shafts (see
Section 6 Transfer Case
of this manual for
information covering drive shafts and U-joints). To help
ensure optimum performance, the drive shaft assemblies
are specially balanced as a unit at the factory. When ser-
vicing any flange yoke, slip yoke or drive shaft tube, order
a complete assembly. Refer to the parts manual for
ordering information.
Respective of the above statement, should it become
necessary to coat the transmission input drive shaft
splines, use molybdenum disulfide grease. Molybdenum
disulfide grease specifically formulated for this purpose is
marketed by several manufacturers under various
names, including:
Aldrich Chemical Co., Inc.
Product name:
Aldrich MOLYBDENUM (IV) SULFIDE,
Catalog Number 23,484-2
Package Size: 5 g (0.175 oz)
100 g (3.5 oz)
500 g (17.5 oz)
Contact:
Aldrich Chemical Co., Inc.
P. O . B o x 3 3 5
Milwaukee, Wisconsin 53201 USA
Telephone: [phone]
DOW CORNING INC.
Product name:
MOLYKOTE
®
77 Paste
Contact:
Dow Corning Corporate Center
P. O . B o x 9 9 4
Midland, MI 48686-0994
Telephone: [phone]
2.5.8 General Anti-corrosion
A. Anti-corrosion Compound
For general anti-corrosion protection, use a wax film rust
inhibitor that provides a protective film two ten-thousandths
of an inch (0.0002", or 0,00005 mm) thick. One such rust
inhibitor that is specifically formulated for this purpose is
LPS 3
. It is marketed by:
LPS Laboratories, Inc.
4647 Hugh Howell Rd.
Tucker GA 30085-5052
Phone: [phone]
Fax: [phone]
Note: Anti-corrosion protection is especially important in
frame and stabilizer cylinder pin support bores for protec-
tion from fretting corrosion wear.
B. Anti-corrosion Need Areas
Coat all unplated pins and all bores for cylinder pins, attach-
ment pivot pins, chain sheave pins, the quick-attach lock
pin, and all quick-attach lock pin bores. On the boom,
coat the fork shaft and unpainted boom slide pathways.
2.5.9 Electrical
A. Basic Ratings
Battery Type ................ 12Vdc, Negative (-) ground/earth,
Maintenance Free
Battery Rating ..........................1,000 cold cranking amps
@ 0°F (-18°C)
Number of Batteries ............................................. One (1)
Alternator Rating.................................................65 amps
B. Fuse Ratings, amps
• Main (S/N 8249 and Before) ..................................... 40
(S/N 8250 and After) ........................................ 30
• Cold Start (Optional) ................................................. 15
• Logic Panel .............................................................. 7.5
• Display Panel ........................................................... 7.5
• Fuel Shutoff ............................................................. 7.5
• Neutral Sense .......................................................... 7.5
• Neutral Relay/Starter ............................................... 7.5
• Hourmeter ................................................................ 7.5
• Horn ......................................................................... 7.5
• Stabil-TRAK ............................................................. 7.5
• Stabilizer Lock Relay ................................................ 7.5
• Steering Solenoids ................................................... 7.5
• Park Brake Sense Relay .......................................... 7.5
• Transmission Solenoids ........................................... 7.5
• Transmission Relay (without Closed Cab Option)..... 7.5
• Transmission Relay (with Closed Cab Option)........... 15
• Switch Lamps (Optional) .......................................... 7.5
• Closed Cab Option - Front Wiper Motor .................. 7.5
• Closed Cab Option - Skylight Wiper Motor .............. 7.5
• Closed Cab Option - Rear Wiper Motor ................... 7.5
• Closed Cab Option - Blower Motor ........................... 25
• Closed Cab Option - Power WIndow Motor .............. 30
• Closed Cab Option - Power Accessories Relay ........ 40
• Closed Cab Option - Power Window Motor Relay .... 40
• Light Package Option - Circuit A ............................... 20
• Light Package Option - Circuit B ............................... 20
Model 3606
•
Origin 10/99