Assembly Installation, Care Maintenance and User Instructions Manual Jungle GYM Swing Set Model SJG201 ! WARNING Read all precautions and instructions in this manual before using this equipment. Save this manual for future reference. Maximum occupancy 2 users. Maximum weight capacity 162 lbs. Ages 4 to 8 SKYWALKER SPORTS Skywalker Holdings LLC P.O.
. On-site adult supervision at all times . Age Grading: 4-8 years, maximum weight of 81 lbs. Maximum Occupancy 7 children SJG200 3 children SJG201 2 children SJG202 1 children SJG203 1 children The total maximum weight not exceed of 567 lbs. (Warning label location) ( ID label location) CONTENTS Before you Begin..........................................................................................................................3 Important Precautions....................................................
BEFORE YOU BEGIN Thank you for selecting a Skywalker Sports Jungle Gym. The Jungle Gym will provide many years of backyard fun. Your Jungle Gym comes equipped with warnings and instructions for the assembly, care, maintenance, and use. This information must be read by all Jungle Gym supervisors and communicated to or read by all users before any person is allowed to use the Jungle Gym.
PLAYGROUND SURFACING MATERIALS INFORMATION The following information is from Section 4 of the United States Consumer Product Safety Comission’s (USCPSC) Outdoor Home Playground Safety Handbook for playground surfacing material. X3. SECTION 4 OF THE CONSUMER PRODUCT SAFETY COMMISSION’S OUTDOOR HOME PLAYGROUND SAFETY HANDBOOK X3.
USER INSTRUCTIONS Observing the following statement and warnings reduces the likelihood of serious or fatal injury. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. The Jungle Gym Base Station is designed for up to 2 persons and not to exceed 162 lb. total weight limit. On-site adult supervision for children of all ages at all times is required. Instruct children not to walk close to, in front of, behind, or between moving items.
JUNGLE GYM SAFETY INFORMATION A Jungle Gym is a recreational product. The information on this manual identify important safety precautions. The precautions are not all-inclusive, because a Jungle Gym can be used in ways that this manual cannot cover completely. USING THE JUNGLE GYM SAFELY Adult Supervision of Children Children using the Jungle Gym must be supervised by adults at all times.
ASSEMBLY PART IDENTIFICATION CHART Before beginning assembly, refer to the drawings below to identify all the parts used in assembly. The number in parentheses by each drawing is the key number of the part, from the PART LIST on page 13 and 14.
PRE-ASSEMBLED PART CHART Before beginning assembly, refer to the drawings below to identify all the pre-assembled parts.
ASSEMBLY Make Things Easier for Yourself! This manual is designed to ensure that the Jungle GYM Swing Set can be assembled successfully by anyone. Most people find that by setting aside plenty of time, assembly will go smoothly. Before beginning assembly, carefully read the following information and insruction: * One people can assembly. Two people is recommended. * For help indentifying parts, use the PART IDENTIFICATION CHART on page 7, page 8 and PART LIST on page 13.
2. First find the “U” Frame 1 (2) with marked 2. 2 Attach the “U” Frame 1 (2) to the Upright 1 (4) and the Upright 2 (5) with four M8X60 Button Bolts (13), eight M8 Arc Washers (9) and four M8 LockNuts (10). Tighten all the Bolts. 9 2 13 9 9 9 13 9 10 10 9 9 9 5 4 3. Attach the Top Tube (1) to the “U” Frame 1 (2) with the M8X65 Button Bolt (20), the M8X105mm Button Bolt (12), three M8 Arc Washers (9) and two M8 LockNuts (10). (Note: the round hole lies in this side).
5. Attached the Swing Set (7) to the Top Tube (1) with two M8 Arc Washers (9) and two M8 LockNuts (10). 5 10 9 9 1 7 6. Attached the Flying Rings (8) to the Top Tube (1) with two M8 Arc Washers (9) and two M8 Lock Nuts (10).
7. Remove the two Plastic Caps from the Jungle GYM. Attach the “U” Frame 2 (3) to the Jungle GYM with eight M8X20mm Button Bolts (11) and four M8 Arc Washers (9) and four M8 Washers(21). 3 21 11 11 9 21 9 8. Tighten all the Nuts. 9.Use the hammer to make the anchor into the ground in the direction as shown below. The anchor effect is to prevent tipping, overturning, or lifting of the support members. Note: The anchor is not provided in this product and need to be purchased seperately.
PART LIST Key No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 Qty. 1 1 1 1 1 1 1 1 24 12 8 2 4 2 Descriprition Key No. Top Tube “U” Frame 1 “U” Frame 2 Upright 1 Upright 2 Cross Bar Swing Set Flying Rings M8 Arc Washer M8 Lock Nut M8X20mm Button Bolt M8X105mm Button Bolt M8X60mm Button Bolt M8X35mm Button Bolt M8 Arc Washer (9) 15 16 17 18 19 20 21 * * * * * Qty.
4mm Hex Key (*) 5mm Hex Key (*) 6mm Hex Key (*) Wrench (*) 14
EXPLODED DRAWING 12 20 9 9 19 3 10 9 11 21 10 10 9 9 1 9 12 9 19 10 9 11 21 2 8 21 11 911 11 21 9 20 9 9 9 9 7 13 9 9 9 910 13 9 10 9 10 5 14 4 17 16 15 9 18 17 16 9 14 18 15 15 6
MAINTENANCE INFORMATION This product was manufactured using quality materials and crafted to provide you and your family with many years of enjoyment and exercise. Proper maintenance care will help to prolong the life and reduce the possibility of injury. The following guidelines should be followed. 1. Tighten all hardware at the beginning of each play season. 2. Lubricate all metallic moving parts per manufacturer’s instructions. 3. Check all protective coverings on bolts, pipes, edges, and corners.
LIMITED WARRANTY Skywalker Holdings, LLC warranties its trampoline products to be free from defects in material and workmanship under normal use and service conditions. The steel frame is warranted for one (1) year after the date of purchase. All other parts are warranted for ninety (90) days after the date of purchase. Wind or weather damage is not warranted. All warranty coverage extends only to the original retail purchaser from the date of purchase.
