MSDS

Page 2 of 5
Nickel Metal Hydride Batteries
January, 2010
©2010 Energizer
(CAS# 7439-96-5)
Mischmetal
including:
Lanthanum (CAS# 7439-91-0)
Cerium (CAS# 7440-45-1)
Neodymium (CAS# 7440-00-8)
Praseodymium (CAS# 7440-10-0)
15 mg/m
3
TWA (particulates
not otherwise regulated-total
dust)
5 mg/m
3
TWA (particulates
not otherwise regulated-
respirable fraction)
10 mg/m
3
TWA (particulates
not otherwise classified-
inhalable)
3 mg/m
3
TWA (particulates not
otherwise classified-respirable)
< 13
Nickel
as nickel hydroxide
(CAS# 12054-48-7)
as nickel oxide (CAS# 1313-99-1)
as nickel powder (CAS# 7440-02-0)
1 mg/m
3
TWA (as Ni)
1.5 mg/m3 TWA
(as inhalable Ni)
0.2 mg/m
3
TWA (as inhalable
Ni, insoluble compounds)
30-50
Potassium Hydroxide
(CAS# 1310-58-3)
None established
2 mg/m
3
Ceiling
< 7
Sodium Hydroxide
(CAS# 1310-73-2)
2 mg/m
3
TWA 2 mg/m
3
Ceiling
0-4
Zinc
as zinc metal (CAS# 7440-66-6)
as zinc oxide (CAS# 1314-13-2)
as zinc hydroxide (CAS# 20427-58-1)
15 mg/m
3
TWA (total dust:
zinc oxide)
5 mg/m
3
TWA (respirable
fraction: zinc oxide)
10 mg/m
3
TWA (total dust: zinc
oxide)
< 3
Non-Hazardous Components
Steel
(iron CAS# 7439-89-6)
Water, Paper, Plastic and Other
None established
None established
None established
None established
14 - 18
Balance
SECTION 4 – FIRST AID MEASURES
Ingestion: Do not induce vomiting or give food or drink. Seek medical attention immediately. CALL NATIONAL BATTERY INGESTION
HOTLINE for advice and follow-up (202-625-3333) collect day or night.
Inhalation: Provide fresh air and seek medical attention.
Skin Contact: Remove contaminated clothing and wash skin with soap and water. If a chemical burn occurs or if irritation persists, seek
medical attention.
Eye Contact: Immediately flush eyes thoroughly with water for at least 15 minutes, lifting upper and lower lids, until no evidence of the
chemical remains. Seek medical attention.
SECTION 5 - FIRE FIGHTING MEASURES
If fire or explosion occurs when batteries are on charge, shut off power to charger.
In case of fire where nickel metal hydride batteries are present, apply a smothering agent such as METL-X, sand, dry ground dolomite, or soda ash,
or flood the area with water. A smothering agent will extinguish burning nickel metal hydride batteries. Water may not extinguish burning batteries
but will cool the adjacent batteries and control the spread of fire. Burning batteries will burn themselves out. Virtually all fires involving nickel metal
hydride batteries can be controlled with water. When water is used, however, hydrogen gas may evolve. In a confined space, hydrogen gas can
form an explosive mixture. In this situation, smothering agents are recommended.
Fire fighters should wear self-contained breathing apparatus. Burning nickel metal hydride batteries can produce toxic fumes including oxides of
nickel, cobalt, aluminum, manganese, lanthanum, cerium, neodymium, and praseodymium.