Safety Instructions & Operator's Manual for SINGLE S TA GE SNOW THROWER SERIES 3 MODEL C3203 MODEL PREFIX BODY NUMBER SUFFIX PREFIX EXPLANATION k I MODEL DESlGNATION ENGINE HP EXPLANATION i C. Commercial Model BOD Y EXPLANATION 3.3.0 HP Engine I 20.20" AuRerWidth SUFFIX EXPLANATION 3 - Series Designation SERIES DESlGNATION 8NAPPER.oDonough, GA.. 30253 U.S.A. COPYRIGHT @ 1997 SNAPPER INC. ALL RIGHTS RESERVED INSTRUCTION No. 2-8318 (REV.
IMPORTANT SAFETY INSTRUCTIONS WARNING: This powerful machine is capable of amputating hands and feet and can throw objects that can cause injury and damagel Failure to comply with the following instructions may result in serious Injury to the operator or other persons; The owner of the snow thrower must understand these instructions and, furthermore, must allow only persons who understand these instructions to operate snow thrower.
TABLE OF CONTENTS SECTION 1- IMPORTANT SAFETY INSTRUCTIONS ............................. 2 TABLE OF CONTENTS ............................................................................. 3 SECTION 2 - OPERATING INSTRUCTIONS ........................................ 4-8 Pre-start Starting Starting Starting Checklist ....................................................................................... & Stopping Engine (Recoil Start Models) ......................................
Section 2 -OPERATING INSTRUCTIONS 2.1 PRE-START CHECK LIST Make the following checks and perform the service required before each start-up. 2.1.1. Check guards, chutes, deflectors and covers to make sure all are in place and securelytightened. 2.1.2. Check auger control to insure it work freely. See Figure 2,1. AUGERCONTROL STANDARD FLUID MEASUREMENT (32:1 Ratio) GASOLINE 2 CYCLE OIL (Gallons) 0.25 0.50 0.75 1.00 1.25 1.50 2.00 (Ounces) 1.00 2.00 3.00 4.O0 6.00 6.00 8.
Section 2 -OPERATING 2.1 INSTRUCTIONS PRE-START CHECK LIST (Continued from Previous Page) Make the following checks and perform the service required before each start.up. CAUTION Never use an electrical extension cord that is damaged. A damaged electrical extension cord could cause a shock or fire. Thoroughly inspect electrical extension cord before using machine. If cord is damaged, do not use and do not operate machine. Replace damaged cord immediately.
Section 2 -OPERATING 2.2 INSTRUCTIONS CAUT,ON AI STARTING, STOPPING & OPERATION (RECOIL START MODELS) (Go to Page 7 for Electric Start Models) 2.2.1. ENGINE & AUGER _ 1. Move choke control to the choke "ON" position. See Figure 2.4. Release auger clutch control and make sure auger I has STOPPED before rotating discharge chute, I adjusting deflector, or placing hands near auger. I 2.2.3. IMPORTANT: Stop the auger by releasing the auger control.
Section 2 -OPERATING INSTRUCTIONS 2.2.4. STOPPING Stop the auger Stop the engine "OFF" position. switch before See Figure 2.7. 2.2 by releasing the auger control. by turning the key switch to the Always remove key from key leaving machine unattended. STARTING, STOPPING & OPERATION (ELECTRIC START MODELS) (Go to Page 6 for Recoil Start Models) 2.2.5. ENGINE & AUGER CAUTION RELEASEAUGER CONTROL AUGER Never use an electrical extension cord that is damaged.
Section 2 -OPERATING 2.2 INSTRUCTIONS STARTING, STOPPING & OPERATION (ELECTRIC START MODELS) (Continued from Previous Page) 2.2.6. ENGINE & AUGER 2.2.7. DISCHARGE CHUTE ADJUSTMENT 4. Push the electric starter button. DO NOT hold button for more than 20 seconds to avoid damaging the starting motor. See Figure 2.9 5. After engine starts, move the choke control to the no choke =OFF" position.Allow a brief warm-up until engine runs smooth. 6. Disconnect power cord from machine.
Section 3 - MAINTENANCE 3.1 INTRODUCTION To retain the quality of the snow thrower, use genuine SNAPPER replacement parts only. Contact a local SNAPPER dealer for parts and service assistance. For the correct part or information for a particular snow thrower, always mention model and serial number. 3.2 SERVICE - AFTER FIRST 5 HOURS 3.2.2 CHECK AUGER CLUTCH CONTROL CABLE 1. Visually check cable for fraying, kinking or severed cable strands. Replace cable and adjust tension before operating snow thrower.
Section 4 - REPAIR & ADJUSTMENTS 4.1.2. AUGER BELT REPLACEMENT Inspect belt frequently for signs of excessive wear. Visually check engine drive belt for cracking, fraying, severed or belt strands exposed. 1. Remove belt cover. See Figure 4.2. 2. Push the spring tensioned idler pulley down and remove belt. 3. Push the spring tensioned idler pulley down and install new belt. See Figure 4.3. 4. Reinstall belt cover and tighten screws securely.
Section 4 - REPAIR & ADJUSTMENTS CAUTION Before attempting any adjustments, maintenance, service, or repairs, stop engine and auger, always remove key from ignition switch, remove spark plug wire and secure wire away from spark plug. 4.1.2. AUGER FLITE SHOE REPLACEMENT Inspect flite shoes frequently for signs of excessive wear. Visually check flite shoes for cracking, fraying, severed or belt strands exposed. #6-0631 Flite Shoe Kit will be required to replace existing flite shoes. 1.
TROUBLESHOOTING PROBLEM PROBABLE CAUSE CORRECTIVE ACTION Engine Will Not Start 1. Fueltank empty. 1. Fill fuel tank with fresh fuel/oil mix. Using Recoil Starter 2. Engine needs chokingand priming. 2. Move choke control to =CHOKE" position. Push pdmer bulbthree times 3. Place spark plug wire ontospark plug. 3. Spark plug wire disconnected. Engine Will Not Crank Using Electric Starter Engine Stalls or Stops After Running Engine Loses Power Excessive Vibration Poor Snow Discharging I.
8NAPPER 1 YEAR COMMERCIAL LIMITED WARRANTY For one (1) year from purchase date for the original purchaser's commercial, rental, or non-residential use, SNAPPER, through any SNAPPER dealer will replace, free of charge (except for taxes where applicable), any part or parts found upon examination by the factory at McDonough, Georgia, to be defective in material or workmanship or both.
Safety Instructions & Operator's Manual for SINGLE S TA GE SMALL FRAME SNOW THROWER SERIES 3 I MODEL C3203 J_ WARNING: I,,._ ,,, The engine exhaust from this product contains chemicals known to the State of California to cause cancer , birth defects or other reproductive harm. SJ_J_J_SR®.cDo.ough, COPYRIGHT Q,..3o,53u.s.,. • 1997 SNAPPER INC, ALL RIGHTS RESERVED INSTRUCTION 14 No. 2-8318 (REV.
