江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 S U M E C 安全数据表 Safety-Data Sheet 样 品 名 称 : Name of Sample: 生 产 单 位 电池包 Battery pack : 江苏苏美达五金工具有限公司 Manufacturer : SUMEC HardWare&tools Co.,Ltd. 报 告 编 号 : SUMEC-2020-019 Report Number : 签 发 日 期 : Date of Issue : 2020-03-20 江苏苏美达五金工具有限公司测试中心 SUMEC HardWare&Tools Co.,Ltd.
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 声 明 Statement 1. 本报告无检测单位印章无效。 The test report is invalid without the official stamp of SUMEC. 2. 未经本试验室书面同意,不得部分地复制本报告。 Nobody is allowed to photocopy or partly photocopy this test report without written permission of SUMEC. 3. 本报告无批准人、审核人及检测人签名无效。 The test report is invalid without the signatures of Ratifier, Reviewer and Testing engineer. 4. 本报告涂改无效。 The test report is invalid if altered. 5.
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 安全数据表 Safety-Data Sheet 1.化学品及企业标识 Chemical product and company identification 样品名称 Name of sample 电池包 Battery pack 样品型号 24VBAT-XR Type/modle 24V 5.0Ah 120Wh 申请单位 Applicant Name 江苏苏美达五金工具有限公司 Sumec Hardware&Tools Co.,Ltd. 申请单位地址 Application Address 江苏省南京市高新开发区星火路 1 号 1#Xinghuo Road, Nanjing High-Tech Zone, Nanjing, Jiangsu, P.R.China 生产工厂 Manufacturer 宁波三叶工具有限公司 NingBo Sayeah Tools Co.
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 2.
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 碳酸乙烯酯 Ethelyne Carbonate 碳酸丙烯酯 电解液溶剂 Propylene Carbonate 96-49-1 108-32-7 5-20 Electrolyte solvent 碳酸二乙酯 Diethyl Carbonate 丙酸乙酯 Ethyl propionate 聚偏氟乙烯 Polyvinylidene fluoride (PVdF) 105-58-8 105-37-3 (C2H2F2)n 24937-79-9 ﹤1 Cu 7440-50-8 3-15 铝 Aluminium Al 7429-90-5 2-10 钴酸锂 Lithium cobalt oxide LiCoO2 12190-79-3 20-50 C 7782-42-5 10-30 铜 Copper 石墨 Graphite 4.
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 Eye: Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid. 皮肤:万一接触,用大量水冲洗至少15 分钟,同时除去污染的衣物和鞋子,迅速 就医。 Skin: Remove contaminated clothes and rinse skin with plenty of water or shower for 15 minutes.Get medical aid. 吸入:立即从暴露处移至空气清新处,如果呼吸困难给予输氧,立即就医。 Inhalation: Remove from exposure and move to fresh air immediately. Use oxygen if available.
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 燃烧产生的危险物品:一氧化碳,二氧化碳,锂氧化物烟气 Hazardous Combustion Products Carbon monoxide, carbon dioxide, lithium oxide fumes. 6. 泄漏应急处理 Accidental release measures 为防止电池材料泄露或释放采取的措施 如果电池内部材料泄露,操作人员应立刻撤离事故区直到烟气消散。将通风设备 打开吹散危险性气体。用抹布擦净试验区,清除溢出的液体,将泄露电池放进塑 料袋中,然后放进钢制容器。避免皮肤和眼睛接触或吸入有害气体。 Steps to be taken in case Material is Released or Spilled If the battery material is released, remove operators from area until fumes dissipate.
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 7. 操作处置和储存 Handling and storage 禁止打开、毁坏或焚烧电池,因为电池有可能在这些处理过程中发生爆炸、破裂或 泄露等事故。 禁止将电池短路、过充、强制放电或扔入火中。禁止挤压刺穿电池或将电池浸入溶 液中。 The battery should not be opened, destroyed or incinerate, since they may leak or rupture and release to the environment the ingredients that they contain in the hermetically sealed container. Do not short circuit terminals, or over charge the battery, forced over-discharge, throw to fire.
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 8. 接触控制/个人防护 Exposure controls/personal protection 呼吸防护: 当电池排气阀打开时,应尽量使通风设备开至最大,避免将打开排气阀的电芯局 限在某一狭窄空间内。正常操作条件下,呼吸保护是不必要的。Respiratory Protection In case of battery venting, provide as much ventilation as possible. Avoid confined areas with venting cell cores. Respiratory Protection is not necessary under conditions of normal use. 通风条件 正常使用条件下不必考虑。 Ventilation Not necessary under conditions of normal use.
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 9. 物理和化学特性 Physical and chemical properties 外形: 方形 Appearance: square 认证编号:1118060011 Ref, No.: 1118060011 气味: 泄漏时,有醚的气味。 Odour: If leaking, smells of medical ether. 酸碱度:不适用 pH: Not applicable as supplied. 闪点:针对单个组分暴露情况,其他不适用。 Flash Point: Not applicable unless individual components exposed. 易燃度:针对单个组分暴露情况,其他不适用。 Flammability: Not applicable unless individual components exposed.
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 Conditions to Avoid : Heat above 70°C or incinerate. Deform. Mutilate. Crush. Disassemble. Overcharge. Short circuit. Expose over a long period to humid conditions. 应避免的材料:氧化剂,碱,水。 Materials to avoid: Oxidising agents, alkalis, water. 危险分解物:有毒烟雾,并可能形成过氧化物。 Hazardous Decomposition Products : Toxic Fumes, and may form peroxides. 聚合危害:不适用 Hazardous Polymerization : N/A.
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 下列情况下会危险人员身体健康:如果与电池内部材料直接接触,皮肤可能会出 现干燥、灼烧等轻微或严重的刺激,并且损坏靶器官的神经,肝脏和肾脏。 Medical conditions generally aggravated by exposure: In the event of exposure to internal contents, moderate to server irritation, burning and dryness of the skin may occur, Target organs nerves, liver and kidneys. 12. 生态学资料 Ecological information 对哺乳动物的影响:目前未知。 Mammalian effects: None known at present. 生态毒性:目前未知。 Eco-toxicity: None known at present.
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 Label for conveyance: class 9 lithium battery hazard label UN 编号:UN3480, UN3481 UN Number: UN3480,UN3481 包装等级:Ⅱ Packaging Group: Ⅱ EmS 编号:F-A ,S-I EmS No: F-A ,S-I 海洋污染物:无 Marine pollutant: No 正确的装运名称: Proper Shipping name: 单独运输:锂离子电池(包括锂离子聚合物电池) Separate transport:Lithium ion batteries(Including lithium ion polymer batteries); 与设备包装在一起的锂离子电池(包括锂离子聚合物电池) Packed with equipment:Lithium ion batteries packed with equipment (Including lithium ion polymer ba
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 《Dangerous Goods Regulations》 《对危险货物运输的有关规定的建议》 《Recommendations on the Transport of Dangerous Goods Model Regulations》 《国际海运危险货物规则》 《International Maritime Dangerous Goods》 《危险货物品名表》 《List of dangerous goods》 《欧洲道路危险货物国际运输协议》 《European Agreement concerning the International Carriage of Dangerous Goods by Road》 《危险品安全运输技术指令》 《Technical Instructions for the Safe Transport of Dangerous Goods》 《危险货物分类和品名编号》 《Classification and code of dangerous goods》 《职业
江苏苏美达五金工具有限公司测试中心 SUMEC Report Number:SUMEC-2020-019 《安全饮用水法》 《Safety Drinking Water Act》(CWA) 《加州65 提案》 《California Proposition 65》 《美国联邦法规》 《Code of Federal Regulations》(CFR) 根据所有联邦、州和地方法律。 In accordance with all Federal, State and local laws. 16.