OPERATOR’S MANUAL Marathoner Gold & SilverStar GAS CONVECTION OVENS SilverStar Models SLGB/12CCH SLGB/12SC SLGB/15CCH SLGB/15SC SLGB/22CCH SLGB/22SC SLGB/25CCH SLGB/25SC MANUAL 1181887 REV 1 $18.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS SAFETY PRECAUTIONS Before installing and operating this equipment, be sure everyone involved in its operation is fully trained and aware of precautions. Accidents and problems can be caused by failure to follow fundamental rules and precautions. The following symbols, found throughout this manual, alert you to potentially dangerous conditions to the operator, service personnel, or to the equipment.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATOR’S MANUAL 1181887 REV 1 TABLE OF CONTENTS PAGE 3
SPECIFICATIONS PAGE 4 MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATOR’S MANUAL 1181887 REV 1
SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS The serial plate is located inside the lower front panel. It indicates the type of gas the unit is equipped to burn. All Southbend equipment is adjusted at the factory. Check type of gas on serial plate. These models are design-certified for operation on natural or propane gases. For natural gas, the regulator is set to deliver a 4.5" W.C. pressure to the manifold. For propane gas, it is set to deliver 11" W.C.
SPECIFICATIONS SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS EXTERIOR DIMENSIONS Single-Deck Ovens A B 8" 18.625" 2.5" 4" 38" 13.5" 2.5" 1.25" C TOP VIEW 29" 57.5" 55" 42.875" 33" 29.25" 26" SIDE VIEW Model Number Depth Dimensions FRONT VIEW Oven Interior Rack Clearance Shipping Crate A B C width depth height width depth width depth height volume weight GS/1… SLGS/1… 38.5" 30" 34.375" 29" 22.5" 20" 28.25" 22" 55" 45.5" 45" 65.17 cu. ft.
SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS SPECIFICATIONS Double-Deck Ovens A B 8" 18.625" 2.5" 4" 38" 13.5" 2.5" 1.25" C TOP VIEW 29" 66.5" 64" 38.25" 29" 42" 22.875" 13" 9.5" 6" SIDE VIEW Model Number Depth Dimensions FRONT VIEW Oven Interior Rack Clearance Shipping Crate A B C width depth height width depth width depth height volume weight GS/2… SLGS/2… 38.75" 30" 34.375" 29" 22.5" 20" 28.25" 22" 55" 45.5" 81.5" 118 cu. ft. 1040 lbs.
SPECIFICATIONS SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS MINIMUM CLEARANCES ! WARNING There must be adequate clearance between the left side of the ovens and combustible construction.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION I NSTALLATION These installation procedures must be followed by qualified personnel or warranty will be void. Local codes regarding installation vary greatly from one area to another. The National Fire Protection Association, Inc. states in its NFPA 96 latest edition that local codes are the “authority having jurisdiction” when it comes to installation requirements for equipment. Therefore, installations should comply with all local codes.
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Step 2a: Installation of Legs on Single-Deck, SilverStar Models INSTALLATION 1. Raise oven sufficiently to allow clearance for the legs to be attached. Use of a lift truck or other mechanical lifting means is recommended. For safety, “shore up” and support the oven with an adequate blocking arrangement strong enough to support the load. (If it is absolutely necessary to rest the oven on its side, rest it on its left side or back side.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION Step 2b: Installation of Legs on Single-Deck, Marathoner Gold Models 1. Raise oven sufficiently to allow clearance for the legs to be attached. Use of a lift truck or other mechanical lifting means is recommended. For safety, “shore up” and support the oven with an adequate blocking arrangement strong enough to support the load. (If it is absolutely necessary to rest the oven on its side, rest it on its left side or back side.
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Step 2c: Installation of Legs on Double-Deck Ovens INSTALLATION Double-deck oven can be shipped either already bolted together, or as two separate ovens to be bolted together after delivery. In either case, the oven that is (or will be) the lower oven will have leg pads already bolted to the bottom corners of the oven. Do the following: 1. Raise oven sufficiently to allow clearance for the legs to be attached.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION Step 3: Installation of Restraint (Only for Ovens with Casters) NOTICE ! WARNING To avoid accidental gas disconnection and potential explosion: If disconnection of this restraint is necessary to move the appliance for cleaning, etc., reconnect it when the appliance is moved to its originally installed position. 1.
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS 2. Install eye-bolt (item “F”) to a frame member on the rear of the equipment. After checking carefully behind the frame member for adequate clearance, drill a 1/4" hole through the frame member. 3. Thread hex nut (item “G”) and slide the washer (item “H”) onto the eye-bolt. Insert the eye-bolt through the 1/4" drilled hole and secure with a washer (item “H”) and nylon lock nut (item “I”). INSTALLATION 4.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION 5. Lift the top oven and position it on top of the lower oven, as shown in the drawing below.
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION 7. Insert two bolts (items “A” in the following diagram) up through the top of the lower oven and screw them into the threaded holes in the bottom of the top oven. Tighten these bolts and the screws that you did not tightened in the previous step. A A 8. Assemble the gas piping shown in the following drawing. Be sure to check all connections for leaks once the oven has been installed.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION INSTALLATION OPERATOR’S MANUAL 1181887 REV 1 PAGE 17
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Step 5: Install Down Draft Diverter (if applicable) NOTICE INSTALLATION Installation must use approved CSA International down draft diverter supplied by Southbend. If the oven flue is to be connected directly to an external vent, a down draft diverter must be installed. The installation of ventilation pipes through walls and roofs must conform to all local codes. To install the down draft diverter, do the following: 1.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION Step 6: Installation of Optional Open Rack Storage An option for single-deck Marathoner Gold ovens is to have open rack storage below the oven. The following describes how to assemble this option. All holes are pre-drilled for the screws provided. 1. Attach the legs to the oven as described in installation Step 2b on page 11. OPERATOR’S MANUAL 1181887 REV 1 PAGE 19 INSTALLATION 2.
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION 4. Attach either the shelf or the two channel frames (depending on which option was ordered) as shown in the drawing below. Use the screws and four side rack clips provided to secure the shelf or channel frames to the rack guides. 5. Attach the rack stop using two screws.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION INSTALLATION OPERATOR’S MANUAL 1181887 REV 1 PAGE 21
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Step 8: Connect Gas Supply NOTICE INSTALLATION The installation must conform with local codes, or in the absence of local codes, with the National Fuel Gas Code, ANSI Z223.1, Natural Gas Installation Code, CAN/CGA-B149.1, or the Propane Installation Code CAN/CGA-B149.2, as applicable, including: 1.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATION O PERATION ! DANGER EXPLOSION HAZARD In the event a gas odor is detected, shut down equipment at the main shut off valve. Immediately call the emergency phone number of your gas supplier. ! CAUTION NOTICE For an appliance equipped with a convection oven, no attempt should be made to operate oven during a power failure.
OPERATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Control Panel of STANDARD Models Power Switch Switch ON to use the oven, switch OFF when done using the oven. ON COOK OFF COOL POWER FAN MODE COOK TIMER (MIN.) Cook Timer Turn knob to set a time duration. An alarm will sound when the timer runs out. The timer is a reminder to the user; the timer does not control the oven. OPERATION HEAT ON Cook Temperature Control Turn knob to select desired cooking temperature.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATION Operation of STANDARD Models Models with Standard Controls operate much like a standard oven: you turn the oven ON and select a cooking temperature. Two additional controls are used to control the fan (as described below). The timer is a reminder to you of when to remove food from the oven. The timer does NOT control the temperature of the oven. To cook, do the following: 1. Turn the oven ON using the Power Switch at the top of the control panel.
OPERATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Control Panel of CYCLE/COOK and HOLD Models Power Switch Switch ON to use the oven, switch OFF when done using the oven. ON COOK OFF COOL POWER FAN MODE Time Display Displays time setting. Indicator lights indicate whether the numbers shown represent hours-andminutes or minutes-and-seconds. OPERATION TIME Temperature Display Displays cook-temperature setting.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATION Operation of CYCLE/COOK and HOLD Models CYCLE/COOK and HOLD models have electronic controls that enable the oven to cook food at a specified cook-temperature for a specified time period, then enter an optional Hold Mode during which the oven maintains a specified hold-temperature for an indefinite period of time. Whenever the power switch is on, the oven will be in one of two modes.
OPERATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS If you open the oven doors, the fan and burners will temporarily shut off, and the time display will pause until the oven doors are closed again. For ovens that are equipped with an oven interior light, to turn on the light press and hold the switch located at the bottom of the control panel. During the cook time you can start or stop having the fan cycle on-and-off by pressing the Cycle button.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATION Control Panel of PROGRAMMABLE Models OPERATION OPERATOR’S MANUAL 1181887 REV 1 PAGE 29
OPERATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Operation of Models with PROGRAMMABLE Controls Models with Programmable Controls can follow a recorded sequence of timed cooking periods, with an option of the last period being an indefinite hold time. Each time period begins with an “event” that specifies what conditions will be maintained during the period that follows. To cook WITHOUT using a recorded cook program, do the following: 1.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATION 10. When you are done cooking, switch the Power Switch to OFF. To RECORD a cook program to use later, do the following: 1. Press the Program Mode On/Off button. 2. Select which program you want to record by pressing the corresponding program button (PGM1, PGM2, PGM3, PGM4, or PGM5). The bottom line of the control panel display will indicate which program is being recorded.
OPERATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Control Panel of RACK TIMER Models Power Switch Use to switch oven on or off. ON OPERATION Time Display Displays remaining time for the rack with the least remaining cook time. When the timer runs out, the display will show the rack number of the rack which has timed out. Heat-On Indicator Lit when the burners are operating. OFF POWER HEAT ON Fan Speed Indicator Indicates fan speed is set to either High or Low.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATION Operation of RACK TIMER Models Rack Timer models have five independent timers, one for each rack. After loading a rack, you can start a timer for that rack. The control panel displays which racks are being timed, which rack will be the next to time out, and how much time remains before that happens. Of course, the oven temperature, fan speed, and fan mode are the same for all racks.
COOKING HINTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS C OOKING H INTS In a standard (non-convection) oven, the air is relatively still and an insulating layer of moisture surrounds the cooking food product. In a convection oven, the fan-blown circulating air strips away this insulating layer allowing the heat to penetrate faster for quicker baking and roasting. Hence, in a convection oven cooking procedures and techniques may require some modification for successful results.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS COOKING HINTS COOKING HINTS OPERATOR’S MANUAL 1181887 REV 1 PAGE 35
COOKING HINTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Cooking Time Temperature Number of Racks 35 min. 375°F 3 5-10 min. 400°F 5 Cornbread 18 min. 400°F 5 French Bread 10 min. 375°F 5 Sheet Cake 18-20 min. 300°F 5 Cream Puffs 20 min. 375°F 5 Brown & Serve Rolls 6 min. 400°F 5 Ginger Bread 18 min. 300°F 5 Yeast Rolls, sheet pan 16-18 min. 325°F 5 Pineapple Upside Down Cake 25-30 min. 325°F 5 Apple Turnovers 15-18 min. 350°F 5 Fruit Cobbler 22-25 min.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS CLEANING C LEANING Southbend equipment is sturdily constructed of the best materials and is designed to provide durable service when treated with ordinary care. To expect the best performance, your equipment must be maintained in good condition and cleaned daily. Naturally, the periods for this care and cleaning depend on the amount and degree of usage. Following daily and periodic maintenance procedures will enhance long life for your equipment.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS CLEANING CLEANING PAGE 38 OPERATOR’S MANUAL 1181887 REV 1
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS ADJUSTMENTS A DJUSTMENTS ! WARNING ADJUSTMENTS AND SERVICE WORK MAY BE PERFORMED ONLY BY A QUALIFIED TECHNICIAN WHO IS EXPERIENCED IN, AND KNOWLEDGEABLE WITH, THE OPERATION OF COMMERCIAL COOKING EQUIPMENT. HOWEVER, TO ASSURE YOUR CONFIDENCE, CONTACT YOUR AUTHORIZED SERVICE AGENCY FOR RELIABLE SERVICE, DEPENDABLE ADVICE OR OTHER ASSISTANCE, AND FOR GENUINE FACTORY PARTS.
ADJUSTMENTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS ADJUSTING DOOR CHAIN MECHANISM The door chain mechanism causes the left and right doors to open and close together. To adjust the door chain mechanism, do the following: 1. Remove lower front panel that covers the door chain mechanism (shown below). 2. Close both doors. 3. Check the positioning of the chain on the sprockets. There should be five regular links and one master link visible on the front side of each chain.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS ADJUSTMENTS TEMPERATURE CONTROLLER (Standard-Control Models Only) The calibration of the temperature controller should not be changed until sufficient experience with cooking results has definitely proved that the temperature controller is not maintaining proper oven temperatures. Before any recalibration is attempted, the oven temperature should be checked by the following procedure: 1. Remove all trays and pans from the oven. 2.
TROUBLESHOOTING MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS T ROUBLESHOOTING ! WARNING ADJUSTMENTS AND SERVICE WORK MAY BE PERFORMED ONLY BY A QUALIFIED TECHNICIAN WHO IS EXPERIENCED IN, AND KNOWLEDGEABLE WITH, THE OPERATION OF COMMERCIAL COOKING EQUIPMENT. HOWEVER, TO ASSURE YOUR CONFIDENCE, CONTACT YOUR AUTHORIZED SERVICE AGENCY FOR RELIABLE SERVICE, DEPENDABLE ADVICE OR OTHER ASSISTANCE, AND FOR GENUINE FACTORY PARTS.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS TROUBLESHOOTING TROUBLESHOOTING GUIDE The left column of the following table lists symptoms that indicate a problem, while the center and right columns list the possible causes and appropriate corrective action. Note that the recommendations of this table assume that the wiring connections are good. When checking a component, always check the wiring attached to the component as well.
TROUBLESHOOTING MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS TROUBLESHOOTING GUIDE (continued) Symptom Possible Cause Check or Replace Burners light but go out within a few seconds. (Ignitor will glow approximately 4 seconds. If burner does not ignite, ignition module will try 3 times and then lock out.) Bad flame switch. Check in series on micro amps. Minimum is 0.75 amps, no maximum. Bad gas valve. Check gas valve. Should be 24 volts from ignition module on wires 46 and 47.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS TROUBLESHOOTING BLOWER WHEEL REPLACEMENT To replace the blower wheel, do the following: 1. Remove racks and rack guides. 2. Remove rear air baffle in front of blower wheel. 3. Loosen the two square heads on blower wheel hub. 4. Pull blower wheel from motor shaft. If blower wheel is difficult to pull off, use puller disk (available from Southbend Technical Service Department as part number 1179100).
TROUBLESHOOTING MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS TROUBLESHOOTING Electrical Schematic for 120 Volt Models with Standard Controls PAGE 46 OPERATOR’S MANUAL 1181887 REV 1
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS TROUBLESHOOTING Electrical Schematic for 208-240 Volt Models with Standard Controls TROUBLESHOOTING OPERATOR’S MANUAL 1181887 REV 1 PAGE 47
TROUBLESHOOTING PAGE 48 MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATOR’S MANUAL 1181887 REV 1
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS TROUBLESHOOTING Electrical Schematic for 208-240 Volt Models with Cycle/Cook and Hold Controls TROUBLESHOOTING OPERATOR’S MANUAL 1181887 REV 1 PAGE 49
TROUBLESHOOTING MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS TROUBLESHOOTING Electrical Schematic for 120 Volt Models with Programmable or Rack Timer Controls PAGE 50 OPERATOR’S MANUAL 1181887 REV 1
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS TROUBLESHOOTING Electrical Schematic for 208-240 Volt Models with Programmable or Rack Timer Controls TROUBLESHOOTING OPERATOR’S MANUAL 1181887 REV 1 PAGE 51
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS P ARTS NOTICE INSTALLATION OF OTHER THAN GENUINE SOUTHBEND PARTS WILL VOID THE WARRANTY ON THIS EQUIPMENT. The serial plate with voltage, model, and serial information is located inside the lower front panel of the oven. Replacement parts may be ordered either through a Southbend Authorized Parts Distributor or a Southbend Authorized Service Agency.
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Front Panel and Flue Parts 2 1 Key Part Number Qty 1 1177867 1 2 1181838 1 * 4440502 1 * not shown on drawing.
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS PARTS Door Parts PAGE 54 OPERATOR’S MANUAL 1181887 REV 1
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Door Chain Mechanism Parts 1 2 3 4 5 6 7 8 Key 1 2 3 4 5 6 7 8 9 Part Number 1164523 1164551 1164522 1164552 1175214 1172326 1177567 1172327 1181956 1183358 Qty 4 2 2 2 1 2 1 2 1 1 9 Description Pivot rod Nut, 3/8-16, hex head, right hand threaded Turnbuckle, 2 3/4" long, brass Nut, 3/8-16, jam, left hand threaded Door mechanism, weld asm Screw, #4-40 x 3/4, zinc plated Switch, door, spdt, 15 amp Nut #4-40, zinc plated, hex Bracket, door switc
PARTS PAGE 56 MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATOR’S MANUAL 1181887 REV 1
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS PARTS PARTS OPERATOR’S MANUAL 1181887 REV 1 PAGE 57
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Control Panel Parts for Cycle/Cook and Hold Models (CCH Models) See drawing on following page.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATOR’S MANUAL 1181887 REV 1 PARTS PAGE 59
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Control Panel Parts for Models with Programmable Controls (PC Models) See drawing on following page.
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Control Panel Parts for Models with Programmable Controls (PC Models) See parts list on previous page.
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Control Panel Parts for Models with Rack Timer Controls (RT Models) See drawing on following page.
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS 3 7 5 6 4 7 6 7 6 7 9 8 10 11 12 2 13 19 1 22 14 18 12 10 15 12 21 16 21 21 17 20 PARTS OPERATOR’S MANUAL 1181887 REV 1 PAGE 63
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Internal Gas Supply Parts 5 1 Key 1 2 3 4 Qty 1 1 1 1 1 1 3 4 Description Switch, shutdown, SPDT, 15 amp Bracket, shutdown switch mtg.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS PARTS Burner Compartment Parts PARTS OPERATOR’S MANUAL 1181887 REV 1 PAGE 65
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Oven Interior and Fan Motor Parts 14 15 12 13 9 8 3 4 5 6 7 11 10 1 2 Key 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Qty 2 1 2 2 1 1 2 2 1 1 1 5 5 2 2 8 4 1 1 4 Description Thumb screw 1/4-20 x 3/4 Baffle, air. s/a, enamel Nut, 1/4 x 20, speed Bracket, baffle, ctg, G-series Puller disk Blower wheel single Tube asm. outer combustion Bolt, carriage, 3/8 x 3.5", ss Pocket weld asm.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATOR’S MANUAL 1181887 REV 1 PARTS PAGE 67
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Leg Parts for Single-Deck SilverStar Models 1 PARTS 3 Key Part Number Qty 1 1177849 4 2 1177850 4 3 1174266 4 * 1173584 4 4 1174264 2 5 1174263 2 * 1174265 1 * 1146213 20 * 1146513 20 * 1146522 20 * not shown on drawing.
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Leg Parts for Single-Deck Marathoner Gold Models 1 2 5 3 Key Part Number Qty 1 1175090 4 2 1175089 4 3 1174266 4 * 1173584 4 4 1174264 2 5 1174263 2 * 1174265 1 * 1146213 16 * 1146513 16 * 1146522 16 * not shown on drawing.
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Storage Rack Parts 1 7 6 2 3 Key 1-7 1 2 3 4 5 5 Description Cooling rack kit, with shelf, shallow depth Cooling rack kit, with shelf, bakery depth Cooling rack kit, w/o shelf, shallow depth Cooling rack kit, w/o shelf, bakery depth Rack hanger, G/E ser co Stop channel Rack guide, 11 pos. shallow Rack guide, 11 pos.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS PARTS Double-Deck Oven Stacking Parts 6 1 2 3 2 4 5 Description 3/4" elbow 3/4" x 13-1/4" pipe 3/4" union 3/4" tee pipe Tie bracket Flue box Bolts PARTS Key Part Number Qty 1 1146904 1 2 1175149 2 3 P-5239-5 1 4 1147304 1 5 1175085 1 6 1181840 1 * 1146213 2 * not shown on drawing.
PARTS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Leg Parts for Double-Deck Ovens 1 1 4 2 3 Description Leg pad SS leg, 3/4" stud Leg package (set of four legs only) Caster with brake Caster without brake Set of four casters (two with brake, two without brake) 3/8 x 16 x 1 hex head bolt 3/8 lock washer 3/8 flat washer PARTS Key Part Number Qty 1 1172788 4 2 1174259 4 * 1174260 1 3 1174264 2 4 1174263 2 * 1174265 1 * 1146213 16 * 1146513 16 * 1146522 16 * not shown on drawing.
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Notes: OPERATOR’S MANUAL 1181887 REV 1 PAGE 73
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Notes: PAGE 74 OPERATOR’S MANUAL 1181887 REV 1
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS OPERATOR’S MANUAL 1181887 REV 1 PAGE 75
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Marathoner Gold & SilverStar GAS CONVECTION OVENS A product with the Southbend name incorporates the best in durability and low maintenance. We all recognize, however, that replacement parts and occasional professional service may be necessary to extend the useful life of this unit. When service is needed, contact a Southbend Authorized Service Agency, or your dealer.