Manual

OWNER’S MANUAL 1191904 REV 2 (5/14)
PAGE
23
OF 31
S SERIES RESTAURANT RANGES
TROUBLESHOOTING
WARNING
ADJUSTMENTS AND SERVICE WORK MAY BE PERFORMED ONLY BY A QUALIFIED TECHNICIAN WHO IS
EXPERIENCED IN, AND KNOWLEDGEABLE WITH, THE OPERATION OF COMMERCIAL COOKING EQUIPMENT.
HOWEVER, TO ASSURE YOUR CONFIDENCE, CONTACT YOUR AUTHORIZED SERVICE AGENCY FOR RELIABLE
SERVICE, DEPENDABLE ADVICE OR OTHER ASSISTANCE, AND FOR GENUINE FACTORY PARTS.
NOTICE
Warranty will be void and the manufacturer is relieved of all liability if service work is performed by other than a qualied
technician, or if other than genuine Southbend replacement parts are installed.
The serial plate is located on the inside of the kick panel (see Figure 1 on page 3).
Replacement parts (including parts not listed in this manual) may be ordered either through a Southbend Authorized Parts
Distributor or a Southbend Authorized Service Agency.
When ordering parts, please supply the Model Number, Serial Number, Part Number, and Part Description.
In case of problems in operation at initial installation, check type of gas and manifold pressure and compare with
information listed on the serial plate.
This section contains troubleshooting owcharts, procedures, and electric schematics to assist a qualied service
technician in the servicing of a Southbend S Series Restaurant Range.
TROUBLESHOOTING FLOWCHARTS, PROCEDURES, AND WIRING DIAGRAMS
Find the symptom below that corresponds to the malfunction, then turn to the corresponding page. Follow the owchart on
that page until the problem is solved.
Troubleshooting Flowchart, Procedure, or Wiring Diagram Page
Troubleshooting Open-Top Burners
24
Troubleshooting Base Oven
25
Troubleshooting Convection-Oven Blower 26
Adjustment of Gas Pressure Regulator 27
Adjustment of Open-Top Pilots 19
Adjustment of Open-Top Burners 20
Adjustment of Oven Standing Pilot 20
Adjustment of Oven Burner 20
Calibration of Oven Thermostat 20
Adjustment of Thermostatic Griddle Bypass Flame Level 21
Calibration of Thermostatic Griddle Thermostat 21
Conversion from One Type of Gas to Another 22
Wiring Diagram for Gas Oven 29
TROUBLESHOOTING