Full Product Manual

• Only qualified persons should use the Sumner Premium Chain
Block Series PCB Hoist.
• Wear eye protection, hard hat, cut resistant gloves and safety
toe shoes when using this tool.
• Do not use tool while tired or under the influence of drugs,
alcohol, or medication.
•
Keep body parts and loose clothing away from moving parts.
• Always follow safety procedures as shown in this manual.
FAILURE TO OBSERVE THESE WARNINGS CAN
RESULT IN SEVERE INJURY OR DEATH.
FAILURE TO OBSERVE THESE WARNINGS COULD
RESULT IN SEVERE INJURY OR DEATH
WARNING
- Personal Safety Hazards
WARNING
• Read and understand all instructions and safety information in
this manual before operating or servicing this tool.
3
IMPORTANT SAFETY INFORMATION
4
IMPORTANT SAFETY INFORMATION
DANGER
:
Electrical Shock Hazards
• Use this tool for the manufacturers intended purpose only. Use other
than that described in this manual can result in injury or property damage.
• Only qualified personnel should configure and use the Sumner
Premium Chain Block Hoist .
• This hoist is designed and intended for use by properly trained and
experienced personnel only. If you are not familiar with the
proper and
safeoperation of a chain block hoist, do not use until proper training
and knowledge has been obtained.
• Do not use to lift, support or transport people; or to lift or support loads
over people.
• Do not exceed the rated capacity of the hoist.
• Do not use the chain as a sling. This may cause damage to the chain.
• Always inspect the hoist for damage prior to use. If hoist is
damaged,
do not use until it has been repaired or replaced.
• Do not use more than one hoist to lift or move a load. If this is unavoidable,
each hoist must have the same capacity as the load to be moved.
• Never allow chain to “set” over sharp edges. All pulls or lift
s must be made
with straight chain that is free of obstacles.
• If the hoist is difficult to operate, then the load exceeds the capacity of the
hoist. Reduce load or select a hoist of larger capacity.
• Do not use hoist if the chain is twisted, kinked or damaged.
• Do not operate hoist unless load is centered between top and
bottom hooks.
WARNING:
• This is not an insulated tool, contact with live circuits could
result in severe injury or death.
• Do not operate this tool while wearing loose fitting clothing.
Retain long hair.
FAILURE TO OBSERVE THESE WARNINGS CAN
RESULT IN SEVERE INJURY OR DEATH.
Tool Use Hazards
FAILURE TO OBSERVE THESE WARNINGS CAN
RESULT IN SEVERE INJURY OR DEATH.
WARNING:
Entanglement Hazard