MSDS

MATERIAL SAFETY DATA SHEET
SPECTRA METAL SALES INC
Information Phone# [phone]
ATLANTA, GEORGIA Super cedes MSDS dated 01/03/09
Preparation date: 10/10/12
SECTION I > PRODUCT IDENTIFICATION SECTION II > PHYSICAL PROPERTIES
Product Number: 500 Series Boiling Range: N/A % Volatile Volume: 24% (Typical)
Product Name: Gutter & Lap Seal Lbs/ Gallon: 9.20 VOC: 4 percent by weight
Product Class: Rubber Sealant Vapor Density: Heavier than air.
CAS# Not Applicable (mixture) Evaporation Rate: Slower than ether
HMIS classification: Health 1, Flammability 3, Reactivity/Physical Hazard 0, PPE – No specific recommendation provided.
SECTION III > HAZARDOUS COMPONENTS INFORMATION
Occupational Vapor
Exposure limits Pressure
Ingredient CAS# Percent TLV PEL @ 25 ΕC
Proprietary Aliphatic Ester blend NA (mixture) 8-25 200ppm* 1500ppm* ~34 mm Hg
Aromatic Petroleum Distillates 64742-94-6 <4 50ppm 100ppm 3mm Hg
* of most significant/most hazardous ingredient
Additional significant ingredients are not considered OSHA Hazardous.
Synthetic Rubber Elastomers NA (mixture) 15-40% N/est N/est N/A
Organic Resins NA (mixture) 10-30% N/est N/est N/A
Calcium Carbonate 471-34-1 0-30% N/est N/est N/A
Note: The main hazard of calcium carbonate is dust inhalation. Because of incorporation into sealant, exposure by inhalation is unlikely.
N/est = not established.
SECTION IV > FIRE and EXPLOSION HAZARD INFORMATION
Flammability Classification: OSHA: Class IB Flash Point: Below 150
o
F, TCC
DOT: 173.150 (c) "Consumer Commodity", Class ORM-D Material.
173.121, Class 3(b) E 173.150
Extinguishing Media: Water Fog, Dry Chemical, Foam, Carbon Dioxide.
Unusual Fire & Explosion Hazards: None. During emergency conditions, over exposure to combustion products such as
smoke and carbon monoxide may cause a health hazard.
Special Firefighting Procedure: Under fire emergency conditions, it is recommended that full protection equipment
be used, including self-contained breathing apparatus to protect fire fighters from
any hazardous combustion products.
SECTION V > HEALTH HAZARD INFORMATION
Primary Route(s) of Entry: Inhalation. People with a history of chemical sensitivity should be advised this product contains
petroleum solvents.
Effects of Acute Overexposure: Overexposure symptoms may include dizziness, shortness of breath, headache, nausea.
Direct contact may cause significant irritation to eyes.
Medical Conditions Prone to Aggravation by Overexposure: May parallel effects of acute overexposure.
Emergency and First Aid Procedures: If in eyes: Flush with large amounts of water immediately, for 15 minutes.
If fumes or vapors are inhaled: remove subject to fresh air.
If on skin: Wash contact area with soap and water.
Action: Take to a Physician for medical care.
SECTION VI > REACTIVITY INFORMATION
Stability: [X] Stable. [ ] Unstable. Hazardous Polymerization: [X] Will not occur. [ ] May occur.
Incompatibility (Materials to avoid): None Known.
Conditions to Avoid: Heat and ignition sources.
SECTION VII > SPILL or LEAK PROCEDURES
Steps to be Taken in Case Material is Released or Spilled: Cover spill with absorbent and place into a closed container.
SECTION VIII > SAFE HANDLING and USE INFORMATION
Waste Disposal Method: Dispose in accordance with federal, state, and local regulations.
Ventilation: For outdoor use or unoccupied dwellings having forced fresh air ventilation.
Protective Gloves: It is good practice to wear gloves while working.
Respiratory Protection: Not needed, but avoid concentrating vapors in any closed area.
Hygienic Practices: Wash hands before eating or using washroom.
Eye Protection: Wear safety glasses.
SECTION IX > SPECIAL PRECAUTIONS
Precautions Taken in Handling and Storing: Store in a cool and dry place away from heat and ignition sources.
Other Precautions: Do not take internally. KEEP OUT OF REACH OF CHILDREN. Intended for outdoor use. Intentional misuse of this
product by deliberately inhaling its concentrated vapor may be harmful or fatal. Reports have associated intentional misuse of petroleum solvents
by inhaling its concentrated vapor with permanent brain, nervous system, liver or kidney damage and mucous membrane irritation.