5VERTICAL/HORIZONTAL TON HORIZONTAL 28 TON LOG LOG SPLITTER SPLITTER MODEL NO. LS401105 (40110500) MODEL NO. LS401105H (401105H0) ASSEMBLY & OPERATING INSTRUCTIONS Owner’s Manual THIS SAFETY ALERT SYMBOL IDENTIFIES IMPORTANT SAFETY MESSAGES IN THIS MANUAL.
Table of Contents Page(s) Important Safety Information................................................................................................................. 1-6 Intended Use ......................................................................................................................... 1 Personal Protective Equipment ............................................................................................... 1 Safety Decals ...........................................................
WARNING: Read and thoroughly understand all instructions and safety information before assembling or operating this log splitter. Failure to do so may cause serious injury or death. Do not allow anyone to operate this log splitter who has not read this manual. As with all power equipment, a log splitter can be dangerous if assembled or used improperly. Do not operate this log splitter if you have doubts or questions concerning safe operation.
PART NUMBER: 52055200 LOCATION:TOP, FRONT END OF HYDRAULIC CYLINDER PART NUMBER: 52023200 LOCATION: HYDRAULIC TANK LOWER TANK, RIGHT CORNER PART NUMBER: 51018900 LOCATION: TOP OF HYDRAULIC CYLINDER Page 2
GENERAL SAFETY Failure to follow these instructions may result in serious injury or death. EVER NEVER allow children to operate this log splitter. NEVER allow adults lacking proper instructions and understanding to operate this log splitter. KEEP all people and pets a minimum of 10 feet away from your work area when operating this log splitter. Only the operator is to be near the log splitter during use.
KNOW how to stop the log splitter and disengage the controls before operating it. NEVER place hands or feet between the log and splitting wedge or ram during forward or reverse stroke. Serious injury or death could result. NEVER straddle or step over the log splitter during operation. NEVER reach or bend over the log splitter to pick up a log. NEVER try to split two logs on top of each other. NEVER try to cross split a second log.
HYDRAULIC SAFETY The hydraulic system of your log splitter requires careful inspection along with the mechanical parts. Be sure to replace frayed, kinked, cracked or otherwise damaged hydraulic hose and components. NEVER check for leaks of hydraulic fluid with your hand. Fluid escaping from a small hole can be almost invisible. Escaping fluid under pressure can have sufficient force to penetrate skin causing serious personal injury or even death.
IMPORTANT NOTE: This log splitter is equipped with an internal combustion engine and should not be used on or near any unimproved forestcovered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in efffective working order by the operator. In the state of California a spark arrester is required by law. Other states have similar laws.
ASSEMBLY INSTRUCTIONS NOTE: This log splitter was partially assembled at the factory. Refer to the drawing and parts list should it become necessary to disassemble the unit for repair or replacement of parts. STEP 1: Remove all the components from the crate. Inspect each piece for shipping damage. If any part is damaged, contact your dealer or delivering carrier.
ENGINE OIL RECOMMENDATIONS SpeeCo 6.5 HP Use 4-stroke automotive detergent oil. SAE 10W-30 is recommended for general use. Refer to the SAE Viscosity Grades chart on page 17 of your engine owner’s manual for average temperature ranges. The engine manufacturer recommends using API SERVICE Category SE or SF oil. The engine oil capacity is 0.63 US qt (0.6 L). Always check oil level before starting the engine. Keep oil level at full. Honda GC190 For temperatures above 50 degrees F, use an SAE 30W oil.
To Start a Warm Engine 1) Move the throttle lever to the FAST position. 2) Leave the choke lever in the OFF position. 3) Pull the starter grip until the engine starts. To Stop the Engine 1) Move the throttle lever to the SLOW position. 2) Move the throttle lever to the STOP position. 3) Turn the fuel valve to the OFF position. NOTE: The engine maximum governed speed is preset at the factory at 3600 RPM no load speed.
PARTS BREAKDOWN FOR MODEL LS401105/LS401105H LOG SPLITTERS O/L- Obtain locally. Common fasteners available through hardware and farm stores.
O/L- Obtain locally. Common fasteners available through hardware and farm stores.
MODEL NO LS401105/LS401105H0 LOG SPLITTERS Tank and Wheel Assembly Refer to parts List on Pages 10 and 11 MODEL NO. LS401105 LOG SPLITTER Engine Assembly for Honda GC190/SpeeCo 6.5 HP Page 12 Refer to Parts List Below Ref.
IMPORTANT NOTICE We, the manufacturer, reserve the right to change the product and/or specifications in this manual without notification. The manual is for information usage only and the pictures and drawings depicted herein are for reference only. NOTES Warranty Repair and Service Do not return this product to the store for warranty issues or repair. Call 1-800-525-8322 for the location of the nearest service center. Record the information below for future reference. Model No.
SPECIFICATIONS Engine Pump Cylinder Valve Maximum Splitting Force Maximum Log Length Cycle Time SpeeCo 6.5 H.P. OHV or Honda GC190 Two-Stage, 11 gpm 3-1/2 in. Diameter x 18 in. Stroke Auto-Return 15 Tons 19 in. 9 Seconds Wheels 4.80 x 8 in. Road Tires Wedge 6 in. High Beam Size Hydraulic Capacity Filter 4-1/2 in. x 7 in. 10 Quarts Replaceable Height 36 in. Length 65 in. Width 45 in. Weight 300 lbs. *Ideal case cycle time.
