Energy Guide

ManualsBrandsSPEEDWAY ManualsTools & Hardware80 gal. 2 Stage Compressor Cast Iron Belt Drive Pump with ASME Tank

88051870 08/11

5HP 80 GALLON TWO

STAGE COMPRESSOR

CALIFORNIA PROPOSITION 65

WARNING: You can create dust

when you cut, sand, drill or grind

materials such as wood, paint,

metal, concrete, cement, or other

masonry. This dust often

contains chemicals known to

cause cancer, birth defects, or

other reproductive harm. Wear

protective gear.

WARNING: This product or its

power cord may contain

chemicals, including lead,

known to the State of California

to cause cancer and birth

defects or other reproductive

harm. Wash hands after

handling.

CAUTION:

FOR YOUR OWN SAFETY READ

INSTRUCTION MANUAL

COMPLETELY AND CAREFULLY

BEFORE OPERATING THIS

COMPRESSOR.

Failure to follow all instructions

as listed below may result in

electrical shock, fire, and/or

serious personal injury.

BREATHABLE AIR

WARNING:

This compressor/pump is not

equipped and should not be

used “as is” to supply

breathing quality air. For any

application of air for human

consumption, the air

compressor/pump will need

to be fitted with suitable in-

line safety and alarm

equipment. This additional

equipment is necessary to

properly filter and purify the

air to meet minimal

specifications for Grade D

breathing as described in

Compressed Gas Association

Commodity Specification G

7.1 - 1966, OSHA 29 CFR

1910. 134, and/or Canadian

Standards Associations

(CSA).

SPECIFICATIONS:

Tank Size: 80 gallons

PUMP RPMs: 1050

CFM: 13.0 @ 40PSI; 12.0 @ 90

PSI

Max Pressure: 150 PSI

Thermal overload protection

SAFETY WARNINGS

Disconnect power and

release all pressure from

the system before

attempting to install,

relocate, service or perform

any maintenance on this

compressor.

Never store flammable

liquids or gases near the

compressor. Electric arcs

can be produced by the

electric motor and pressure

switch.

Do not operate the

compressor without the

belt guard in place. Moving

parts can cause serious

injuries.

1) Follow all electrical and

safety codes along with

National Electrical Codes

(NEC) and Occupational

Safety and Health Act

(OSHA).

2) Electric motors and

starters must be securely and

properly grounded.

Models: 51866, 51870

feedback@natitools.com

Summary of content (10 pages)

PAGE 1
5HP 80 GALLON TWO STAGE COMPRESSOR CALIFORNIA PROPOSITION 65 WARNING: You can create dust when you cut, sand, drill or grind materials such as wood, paint, metal, concrete, cement, or other masonry. This dust often contains chemicals known to cause cancer, birth defects, or other reproductive harm. Wear protective gear. WARNING: This product or its power cord may contain chemicals, including lead, known to the State of California to cause cancer and birth defects or other reproductive harm.
PAGE 2
3) Do not allow the cable to come into contact with oil, grease, chemicals or sharp objects. Do not allow kinks to form in the cable. 4) Do not exceed the pressure limits for any component in or connected to the system. 5) Inspect the compressor to make sure that all the fittings, bolts, etc., are tight and secure before starting the compressor. 6) Do not touch the compressor or motor while it is in operation. These parts become HOT during normal operation.
PAGE 3
Tank Mounting The tank should be bolted on a concrete floor or on a separate concrete foundation. Vibration isolators can be used between the tank leg and the floor. When using isolator pads, do not draw bolts tight. Allow the pads to absorb vibrations. When isolators are used, a flexible coupling should be installed between the tank and service piping. Vertical tanks have three feet and do not need shimming as long as the floor or foundation is level.
PAGE 4
the air intake port on the pump head. 6) Attach the air hose and any desired accessories (not included). Use Teflon tape on the threads to ensure an airtight connection. Do not over tighten the fittings. Note: Vibration isolator pads are recommended prior to bolting to the floor. Only mount the compressor to a concrete floor or concrete pad. OPERATING INSTRUCTIONS Start Up 1) Turn the ON/OFF switch to the off position. 2) Check the air compressor visually for any damage or obstruction.
PAGE 5
Six months or 250 operating hours: - Change compressor oil (SAE 20 or 30) Replace oil more frequently when used in dusty operating environments. CHANGING THE OIL 1) Place oil drain pan below the oil drain plug. cannot be blown clean, the filter should be replaced. Do not allow intercooler fins to become clogged with dirt, lint, dust, paint, etc.
PAGE 6
Symptom No start condition Low pressure Safety valve releasing Possible Cause(s) Possible Solutions Fuse blown or circuit breaker tripped Check for cause of blown fuse/breaker and replace Loose electrical connections Check wiring connections Overheated motor Turn compressor off, wait until total cool down. Check to insure the motor is rotating "clockwise" when facing the front of the compressor before restarting Air leak in safety valve Check valve manually by pulling upwards on ring.
PAGE 7
North American Tool Industries (NATI) makes every effort to ensure that this product meets high quality and durability standards. NATI warrants to the original retail consumer a 1-year limited warranty from the date the product was purchased at retail and each product is free from defects in materials. Warranty does not apply to defects due directly or indirectly to misuse, abuse, negligence or accidents, repairs or alterations, or a lack of maintenance. This product is intended for personal use.
PAGE 8
5HP 80 GALLON TWO STAGE COMPRESSOR Models: 51866, 51870 72 feedback@natitools.
PAGE 9
No.
PAGE 10
No. Description 65 Oil Drain Plug 66 Motor 67 Woodruff Key 68 Motor Pulley 69 V-Belt 70 Electric Cable 72 Valve Plate 74 Air Tank 79 Drain Valve 81 Check Valve 82 Unload Elbow 83 Unload Pipe 84 Unload Nut 85 Pressure Gauge 86 Safety Valve 87 Nipple 88 Pressure Switch 89 Quick Connector 90 Belt Guard 91 Spring Washer 92 Bolt 93 Exhaust Pipe Assembly 94 Exhaust Tube Pipe 95 Exhaust tube Elbow feedback@natitools.