28 Gallon Air Compressor Model: 52619 *Actual product may vary slightly 88052619 01/2014
Important Operating Instructions CALIFORNIA PROPOSITION 65 WARNING: You can create dust when you cut, sand, drill or grind materials such as wood, paint, metal, concrete, cement, or other masonry. This dust often contains chemicals known to cause cancer, birth defects, or other reproductive harm. Wear protective gear. WARNING: This product or its power cord may contain chemicals, including lead, known to the State of California to cause cancer and birth defects or other reproductive harm.
Important Operating Instructions GENERAL SAFETY INSTRUCTIONS • Keep work area clean. Messy areas and cluttered workbenches invite personal injury and/or property damage. • Keep children and visitors away. All children should be kept away from the work area. DO NOT let children handle the compressor or extension cord. Maintain a safe distance for any person near the work area.
Important Operating Instructions GENERAL SAFETY INSTRUCTIONS • Do not overreach. Proper footing and balance is a must at all times while using tools. Unstable support may lead to personal injury. Do not stand on the tool. Serious injury could result if the tool tips over or you accidentally contact the tool. • Never leave the air compressor running unattended. Always turn the power to the OFF position and do not leave the air compressor until it comes to a complete stop.
Important Operating Instructions GENERAL SAFETY INSTRUCTIONS • Operate the air compressor in a well-ventilated area. Do not direct paint or other spray material towards the compressor. Read and follow all safety instructions for the material you are spraying. Risk of injury • Do not direct air stream at body. Use eye protection. Compressor starts automatically. Do not touch moving parts. Keep guards in place. Compressor does not supply breathable air.
Important Operating Instructions GENERAL SAFETY INSTRUCTIONS Risk of falling • Portable air compressors can fall from a table, workbench, or roof causing damage to the compressor and could result in serious injury or death to the operator. Always operate air compressor in a stable and secure position to prevent accidental movement of the unit. Never operate air compressor on a roof or other elevated position. Use additional air hose to reach high locations.
Important Operating Instructions GROUNDING INSTRUCTIONS This product should be grounded. In the event of an electrical short circuit, grounding reduces the risk of electric shock by providing an escape wire for the electric current. This product is equipped with a cord having a grounding wire with an appropriate grounding plug. The plug must be plugged into an outlet that is properly installed and grounded in accordance with all local codes and ordinances.
Important Operating Instructions EXTENSION CORDS CAUTION: The use of an extension cord with this product is not recommended as this can result in the loss of power to your air compressor which can prevent the motor from starting or running properly. This can also cause your fuse to blow or circuit breaker to trip. Running your air compressor on an undersized extension cord will cause permanent damage to internal switches and overheating of the electric motor.
Important Operating Instructions Guard against electrical shock. Avoid body contact with grounded services such as pipes, ovens, stoves, and refrigerator enclosures. If not properly grounded, this air compressor can incur the potential hazard of light trickle shock, particularly when used in damp locations. If electrical shock occurs, there is the potential of secondary hazard such your hands contacting an operating air tool.
Important Operating Instructions WARNING: Do not operate this air compressor if damaged during shipment, handling, or misuse. Damage may result in bursting, which can cause serious injury or property damage. All damaged parts must be repaired or replaced as needed prior to operating this air compressor. Check to see that all nuts, bolts, and fittings are secure before putting this air compressor into service.
Important Operating Instructions 6. SAFETY RELIEF VALVE: This compressor is equipped with a safety relief valve that is designed to prevent system failures by relieving pressure from the system when the air pressure reaches a predetermined level. The safety relief valve is preset by the manufacturer. DO NOT attempt to modify or remove the safety relief valve. 7. AIR TANK DRAIN VALVE: Moisture is produced whenever air is compressed.
Important Operating Instructions 3. Turn the pressure regulator knobs fully clockwise to open airflow from air outlet port. NOTE: Be careful not to over tighten pressure regulator knob when it “bottoms out” as this may damage pressure regulator. 4. Turn the power switch to the OFF position. 5. Plug the power cord directly into a properly grounded power source of the correct voltage (see Grounding instructions). 6.
Important Operating Instructions MAINTENANCE WARNING: Disconnect air compressor from the power source and bleed off all air pressure before attempting any maintenance or repair. SHUTDOWN & STORAGE NOTE: NEVER stop the air compressor by unplugging it from the power outlet as this may result in damage to the compressor. 1. Turn the switch to the OFF position. 2. Disconnect the power cord from the power outlet. Disconnect the power cord from the power outlet by grabbing the plug (not the cord).
Important Operating Instructions MAINTENANCE CHECKLIST Daily: • Drain accumulated liquid from tank • Check for unusual noise and/or vibrations • Check that all fasteners are secure • Wipe compressor clean Weekly: • Inspect and clean air filter Monthly: • Check for air leaks • Check safety relief valve CHECKING SAFETY RELIEF VALVE WARNING: Safety relief valve must be replaced if it cannot be actuated or it leaks air after the ring is released. 1. The air compressor must be turned OFF. 2.
Important Operating Instructions CHECKING AIR FILTER ELEMENT 1. The air compressor must be turned OFF. 2. Disconnect compressor from the power source. 3. Open tank drain to bleed off all air pressure before attempting any maintenance or repair. 4. Allow compressor to fully cool before attempting any maintenance or repair. 5. Remove the face of the filter body to access the filter element by removing screw holding filter in place. 6.
Important Operating Instructions TROUBLESHOOTING GUIDE Symptom Possible Cause(s) Corrective Action Power cord not plugged in Plug cord into grounded outlet Motor/Pressure switch in OFF position Move switch to AUTO position Motor thermal overload switch has tripped Turn air compressor off, wait until the motor is cool, then press motor thermal overload (red) button firmly until click is heard.
Important Operating Instructions TROUBLESHOOTING GUIDE Symptom When in the start/stop option, motor runs continuously Air continues to leak at motor/pressure switch release valve after motor stops Air continues to leak at motor/pressure switch release valve while motor is running Air leaks from safety relief valve Possible Cause(s) Corrective Action Motor/pressure switch does not shut off motor when air compressor reaches “cut-out” pressure and safety relief valve activates Move the motor/pressure sw
Important Operating Instructions TROUBLESHOOTING GUIDE Symptom Possible Cause(s) Corrective Action Air leaks at fittings Fittings are not tight enough Tighten fittings where air can be heard escaping. Check fittings with soapy water solution. DO NOT OVERTIGHTEN. Air leaks in air tank Defective or rusted air tank Air tank must be replaced.
Important Operating Instructions WARRANTY Limited Manufacturer Warranty North American Tool Industries (NATI) makes every effort to ensure that this product meets high quality and durability standards. NATI warrants to the original retail consumer a 1-year limited warranty from the date the product was purchased at retail and each product is free from defects in materials.
PARTS LIST 28 Gallon Air Compressor Model: 52619 20 88052619 01/2014
PARTS LIST 28 Gallon Air Compressor Model: 52619 21 88052619 01/2014
PARTS LIST Model: 52619 28 Gallon Air Compressor # Description QTY # Description QTY # Description QTY 1 Release Pipe 1 28 Discharge Pipe 1 55 Spring Washer 4 2 Power Cord 1 29 Elbow 1 56 Bolt, M6 4 3 Pressure Switch 1 30 Spring Washer 1 57 Cylinder Gasket 1 4 Pressure Gauge 2 31 Bolt 1 58 Valve Plate 2 5 Nut 3 32 Washer 1 59 Reed Valve 2 6 Ring 1 33 Shroud Bottom 1 60 Filter 1 7 Quick Coupler 2 34 Circuit Breaker 1 61 Plastic Plate 1