Use and Care Manual

8807253 08/13
3000LB WINCH
CALIFORNIA PROPOSITION 65
WARNING: You can create dust
when you cut, sand, drill or grind
materials such as wood, paint,
metal, concrete, cement, or other
masonry. This dust often
contains chemicals known to
cause cancer, birth defects, or
other reproductive harm. Wear
protective gear.
WARNING: This product or its
power cord may contain
chemicals, including lead,
known to the State of California
to cause cancer and birth
defects or other reproductive
harm. Wash hands after
handling.
Important!
When using equipment, a few
safety precautions must be
observed to avoid injuries and
damage. Please read the complete
operating manual with due care.
Keep this manual in a safe place,
so that the information is available
at all times. If you give the
equipment to any other person,
give them these operating
instructions as well. We accept no
liability for damage or
accidents which arise due to non-
observance of these instructions
and the safety information herein.
SPECIFICATIONS
Single line rated pull: 3,000
pounds
Motor: Permanent magnet
Braking action: Mechanical and
dynamic
Wire rope: 1/5 inch by 34 feet
Weight: 19.8 pounds
CAUTION:
FOR YOUR OWN SAFETY,
READ INSTRUCTION MANUAL
COMPLETELY AND
CAREFULLY BEFORE
OPERATING THIS WINCH.
Any failures made in following
the safety regulations and
instructions may result in an
electric shock, fire, and/or
serious injury.
Model: 7253
SAFETY INSTRUCTIONS
1) Never lift people or hoist loads
over people. Do not lift items
vertically. This winch was
designed for horizontal use only.
2) Do not overload the winch. Use
an optional pulley block to double
the line if the weight is over 1,000
pounds.
3) Do not attempt to use the winch
for prolonged pulls of heavy loads.
This winch is designed for
intermittent use only and is not
meant for constant heavy duty
use. Never pull a load for more
than one minute at or near the
rated load.
4) Never winch with less than five
(5) turns of wire rope around the
winch drum because the wire rope
and fastener may not be able to
withstand full load.
5) Avoid continuous pulls from
extreme angles. This will cause
the wire rope to pile up on one
end of the drum, which can cause
damage to the rope or winch.
[e-mail]