Use and Care Manual

ManualsBrandsSportsman ManualsMiscellaneous PartsEarth Series 32.7cc Gas Powered T-Post Driver

GPDR

2-CYCLE GASOLINE POWERED PILE DRIVER

ASSEMBLY & OPERATING INSTRUCTIONS

READ ALL INSTRUCTIONS AND WARNINGS BEFORE USING THIS PRODUCT.

This manual provides important information on proper operation & maintenance. Every effort has

been made to ensure the accuracy of this manual. These instructions are not meant to cover

every possible condition and situation that may occur. We reserve the right to change this

product at any time without prior notice.

IF THERE IS ANY QUESTION ABOUT A CONDITION BEING SAFE OR UNSAFE,

DO NOT OPERATE THIS PRODUCT!

If you experience a problem, have questions or need parts for this product, call Customer Service

at 1-866-460-9436, Monday-Friday, 8 AM - 4 PM Central Time. A copy of the sales receipt is

required.

FOR CONSUMER USE ONLY – NOT FOR PROFESSIONAL USE.

KEEP THIS MANUAL, SALES RECEIPT & APPLICABLE WARRANTY FOR FUTURE

REFERENCE.

Summary of content (16 pages)

PAGE 1
GPDR 2-CYCLE GASOLINE POWERED PILE DRIVER ASSEMBLY & OPERATING INSTRUCTIONS READ ALL INSTRUCTIONS AND WARNINGS BEFORE USING THIS PRODUCT. This manual provides important information on proper operation & maintenance. Every effort has been made to ensure the accuracy of this manual. These instructions are not meant to cover every possible condition and situation that may occur. We reserve the right to change this product at any time without prior notice.
PAGE 2
INDEX I II III IV V VI VII VIII IX X XI Part Information / Specifications .......................................................................................... 3 Safety Instructions ............................................................................................................... 4 Use and Function ................................................................................................................ 4 Assembly .....................................................................
PAGE 3
1 Name of Main Parts No. Name of Part No. Name of Part No.
PAGE 4
SPECIFICATIONS Engine type Fuel Fuel tank capacity Weight Displacement Max power/speed Max torque/speed Fuel consumption Impact frequency Impact energy Carburetor type EPA Approved Single cylinder, air cooling, 2 stroke, cylinder diameter × stroke: 36×32mm Mixed oil (Gasoline: two-stroke engine oil= 50:1) 1.0675 quart (34.16 ounces) 28.66 lbs 32.7CC 0.9KW/7500r/min Spark plug type L6T 1.45N.m/5000r/min ≤0.50L/h 1700~2230 RPM 20~45J 1E36F-2E.1A" IMPORTANT SAFETY INSTRUCTIONS – SAVE THESE INSTRUCTIONS 1.
PAGE 5
ASSEMBLY Fig. 1 ) Identify Pile Driver, Piling Socket Sleeves (2 pieces), Inner Pile Head and Socket Pin. Fig. 2 ) Attach Piling Socket Sleeve by screwing it onto Pile Driver. Fig. 3 ) Insert Socket Pin, then rotate Piling Socket Sleeve Φ69 to make sure it is tight & secure. Fig. 4 ) Insert Inner Pile Head Φ67. Use a wood handle or metal bar to force inside Sleeve. * NOTE: Piling Socket SleeveΦ49 does NOT need Inner Pile Head. Fig.
PAGE 6
USE AND FUNCTION Use: Use for outside piling operation for farm fences, orchard fences or barriers. Function: • The operator can achieve 360° all-around operation. • Can drive posts up to 2 .6 7 in c h e s (68mm) in diameter. • Two-way Damping Spring helps reduce vibration. MIXING GAS/OIL FUEL Use only quality gasoline and two-stroke special engine oil. Recommended mixing ratio: Condition Gasoline : 2-Cycle Engine Oil Operation within 20 hours Operation of over 20 hours 50:1 50:1 1.
PAGE 7
When the engine has started, open the choke completely. After idling for approximately 5 minutes, you can start working. OPERATION After engine is started, allow 5 minutes idle operation to warm up the machine. When the engine is warmed up, press throttle handle to the appropriate speed. Note: The unit will provide low or medium-speed for work in the first 6 hours of operation and the maximum throttle should not be used. High-speed operation of pile driver during non-piling is prohibited.
PAGE 8
Air Filter Check air filter regularly. Soot deposit blocking air filter will reduce power of gasoline engine and service life. If the filter has too much soot deposit, clean it with warm water and detergent, and then wipe dry it with dry cloth, and then install the air filter. Replace Filter if damaged. If working in a d u s t y environment, maintenance cycle will be shortened. Silencer Regularly remove dirt on inlet and outlet of silencer, or clean dirt in it with detergent.
PAGE 9
TROUBLESHOOTING Problem analysis and solving Example 1: Difficulties in starting cool engine.
PAGE 10
MAINTENANCE √ screws) Clean Control handle/stop button Air Filter Fuel Filter Petrol Tank/Petrol Tank cover Gear Box/Cylinder Silencer Cylinder Cooling Fin Function check √ √ √ √ Clean √ √ Check √ Replace √ Clean √ √ √ √ Tighten √ Clean √ Add oil √ Check √ Remove carbon deposit √ Check √ Clean √ Check/Adjust the distance Spark Plug √ between electrodes Replace Screw and Nut √ Replace Check Check Tighten If necessary tightness of Temporary Failure The whole mach
PAGE 11
PARTS LIST Part No. Name Part No.
PAGE 12
PARTS DIAGRAM GPDR 2-‐Cycle Pile Driver Instruction Manual 12
PAGE 13
PARTS LIST Parts No. Name Qty Parts No. Name Qty 1 Gasoline Engine 1 2 Clutch Plate 1 41 Right Paper Pad 1 42 Right Steel Cover 1 3 Circlip for Hole A Type 40 2 43 Ram O-ring 1 4 5 Deep Groove Ball Bearing 6203-2RZ 4 44 Ram 1 Bevel Pinion 1 45 Impact Cylinder 1 6 Reduction Gearbox 1 46 Shock 1 7 Hexagon Socket Head Cap Screw M6×8 3 47 Shock O-ring 2 8 Flat Gasket Φ16XΦ22X0.5 1 48 Crash Pad 2 9 Bevel Gear Wheel 1 49 Wave Washer Φ39×46×0.
PAGE 14
PARTS DIAGRAM GPDR 2-‐Cycle Pile Driver Instruction Manual 14
PAGE 15
EMISSION CONTROL SYSTEM WARRANTY BUFFALO CORPORATION Your Warranty Rights and Obligations The California Air Recourse Board, U.S. EPA and Buffalo Corp. are pleased to explain the Emission Control System Warranty on your 2019 model year new outdoor power equipment engine. California In California, new spark-ignited small off-road equipment engines must be designed, built and equipped to meet the State’s stringent anti-smog standards. Other States, U.S.
PAGE 16
Repair or replacement of any warranted part under the warranty provisions herein must be performed at a warranty station at no charge to the owner. Notwithstanding the provisions herein, warranty services or repair will be provided at all of our distribution centers that are franchised to service the subject engines.