Use and Care Manual

LOADING
Alwayshandletoolwithcare.
Visuallyinspectthetoolforwornordamage d partspriortouse.
1.Disconnectfromairsupply

2. Installamale,pneumaticfittingintotherearcapofthetoolensuringthatthefitting
allowsthetooltoexhaustanyairinthetoolwhentheairhoseisdisconnected.

3.Addtwodropsofnon‐detergent,20‐weightoilintothemalefitting.

4. ConnecngtheAirHose
a.Useaquickconnectfingtothetoolandchecktheairpressurereadingonthe
regulatortoensureitdoesnotexceed120p.s.i.Checkthetoolforanyairle aks.
b.Placethetool,emptyoffasteners,inopera
ngposiononascrapworkpiece.
Fullydepressthesafetyandpullthetriggertoverifythatthetoolcycles.

5. Usingthefollowingcycleguidelines,cyclethetoolseveralmestocheckforproper
tooloperaon.

BEFOREUSINGVERIFYTHETRIGGERSETTINGTOENSUREITISSET
FORDESIREDTRIGGERACTUATION

RedTrigger–Single‐sequenalactuaon–RestricveInstalled
Thetoolwillnotcycleasecondmeunlessboththetriggerandsafetyyokeare
fullyreleasedandthendepressedagain.


Black–ContactActuaon–BumpFireIncluded
Thetoolwillnotcycleasecondmeunlessthetriggerand/orsafetyyokearefully
releasedandthendepressedagain.

Blue–SelecveActuaon‐InstantConversionBump/Restricve
Thistriggerallowsforoperatortoselecteithersingle‐sequenalactuaonor
contactactuaon.Seeaboveforexplanaonbeforeusing.

6.Openthemagazineorslidethepushertothelockedpositionandloadthe
fastenersapprovedfortheuseinthetool.

7.Cyclethetoolonascrappiecetoevaluatethedepthofthepenetrationbythe
fastenerintotheworkpiece.

8.AdjustableDepthControl
Toadjustthedepthofpenetration,disconnecttheairhose,adjustthedepthcontrol
knoborscrew,connecttheairhoseandcyclethetoolonascrapworkpieceto
evaluatetheadjustment.
Repeatasneededtosetthecorrectdepth,usingtheminimumamountofair
pressuretodrivethefastener.


Page6
TOOLSERVICE/MAINTENANCE

Cleanandinspectyourtooleverymeyouuseit


Toolserviceshallberepairedorequippedonlywithpartsoraccessoriesthatare
suppliedorrecommendedbyAuthorizedSpotnailsrepairpersonnel.Serviceorrepairsby
unqualifiedpersonnelmayresultinariskofinjury.

Pleaserefertotheschemacdrawingbeforestarnganyrepairs.

Toolshould
beinspectedperiodicallyandreplaceanywornorbrokenpartstokeepthe
tooloperangsafelyandefficiently.

Tightenallscrews.Loosescrewscanresultinunsafeoperaonoftool.

Withtooldisconnectedfromtheairsupply,regularlyinspectthesafety,thetriggerand
thespringfor
freeunhinderedmovement.Neveruseatoolthatrequiresservicing.

Wheneverrepairsorreplacementofpartsinsidethebodyoccur,checkthepiston‘o’ring
foradequategreaselubricaon.

Periodicallycleanthemagazineandnoseofthetoolwithamild,non‐flammablesolvent.

Disconnecttoolfrompower
sourcewhennotinuse,loweringormovingtooltoanew
locaon,toolisoutsideofthe operator’ssupervisionorcontrolandremovingfasteners
fromthemagazine.

Wrienapprovalofthetoolmanufacturermustbeobtainedpriortomakingany
modificaonstothetool.















Page7