THE SMART TRAMPOLINE TM Assembly and Disassembly Instructions for Trampoline and Enclosure WANT TO JUMP? DO IT SAFE! ONE AT A TIME. ENVIE DE SAUTER? FAITES-LE EN TOUTE SÉCURITÉ! UNE À LA FOIS. MAT DIAMETER 11 ft x 11 ft (3.4 m x 3.4 m) MINIMUM NET HEIGHT FROM MAT 6 ft (1.8 m) MAT HEIGHT FROM GROUND 3 ft (0.9 m) MAXIMUM USER WEIGHT 220 lbs (100 kg) The information in this document is subject to change without notice. © Copyright Springfree® Trampoline Inc. 2005, 2017. All rights reserved.
WARNING 0-6 Read the warnings on this page and those contained in the User Guide before you assemble and use the trampoline and enclosure. Treat any loaded rod with caution until you are sure it is properly installed or uninstalled. Keep face clear of loaded rods. An improperly installed rod could release and cause facial injury or blindness. No more than one person at a time.
WARNING A. Two people are required for assembly. Installation typically takes two hours to complete. B. Keep small children at least 25 ft (7.5 m) away while assembling the trampoline; they could be injured by improperly assembled rods releasing and ejecting from the frame. C. Do not attempt to use the trampoline until it is completely assembled. D. Be aware that when loaded, the rods can spring back and may cause injury. Keep your face well clear of the rods during assembly or disassembly.
1 A If for any reason you need to remove a rod from the mat, do not twist or rotate the mat edge as shown. This could cause serious injury or damage the trampoline. B Si vous devez désinstaller une tiges du tapis, ne tordez et ne tournez pas le bord du tapis. Cela peut entra ner de graves blessures ou des dommages au trampoline. C D Part Quantity A. Mat 1 B. White Mat Rods Net C. Part D.
2 C B D A E Part A. B. C. D. Quantity Curved Frame Sections Straight Frame Sections Legs Center Posts 4 4 8 8 Part E. F. G. H. Wrenches C-clips (Attached to Frame) Small Bolts & Nuts Large Bolts & Nuts F G Quantity 3 12 16 8 WARNING - Use the tools provided to fasten the nuts. Do not over tighten the nuts. Do not use power driver, torque wrench, or drill. Lay out the remaining parts as shown. The colored stickers all face upwards.
3 1 2 6 5 4 7 3 8 TIP - Fastening the final two frame sections often requires additional effort. Two people are required for assembly. TIP - When installing the legs, it is easiest when one person to holds the frame up and horizontal while the other person inserts the legs into the leg sockets. Connect and fasten frame sections using the large nuts and bolts. When finished, the bolt head should be flush with the frame and the nut should face the center of the trampoline.
4 Lay out the mat with the yellow stripes facing upwards inside the trampoline frame. The blue tags on the mat should approximately align with the blue stickers on the frame. Before moving to the next step, ensure that the mat rod holders are correctly positioned with the mat rod holder tag outside the mat rod holder pocket, as per the insert. If the mat rod holder tag is under the pocket, adjust accordingly.
5 B B NOTE - As you install the white mat rods into the mat rod sockets the net will become tight against the frame. Handle the net with care and be sure that it does not get caught or it may tear. Locate the green tag on the bottom edge of the net and match it with any green sticker on your trampoline frame. Holding the net so that the green tag is facing you, gently place the rest of the net inside the frame as shown. DO NOT let go of the green tag.
TOP VIEW 6a 4 5 7 2 1 8 6 3 WARNING - Treat any loaded rod with caution until you are sure it is properly installed or uninstalled. Keep your face well away from any loaded rod. WARNING - Both people must maintain a steady grip on the rod until it is securely installed in the mat rod holder. NOTE - Before you install the first white mat rod into a mat rod holder, read the instructions in Step 6b and 6c. NOTE - Following the sequence shown spreads the tension evenly across the mat.
1 6b Have one person position themselves inside the frame of the trampoline while the other stands outside as shown. 2 Inside Person: Ensure that the mat rod holder is correctly positioned with the small tag positioned outside the mat rod holder pocket. Inside Person: Take hold of the rod with both hands and maintain a steady grip until it is securely installed in the mat rod holder. Outside Person: Hold the white mat rod with your palm facing up and bend your arm at a right angle.
6c 7 Outside Person: Rocking from your heels to the balls of your feet, use your body weight to push the white mat rod towards the center of the mat. 8 Inside Person: As the outside person pushes, carefully pull the rod in and up in the direction of the mat rod holder. Inside Person: Guide the white mat rod up and over the back edge of the mat rod holder and into position. Check that the rod is fully seated in the mat rod holder before continuing.
TOP VIEW 7 11 5 12 10 9 13 14 16 15 WARNING - Treat any loaded rod with caution until you are sure it is properly installed or uninstalled. Keep your face well away from any loaded rod. NOTE - Follow the mat rod installation sequence. Do not install multiple mat rods in one location. If you do not follow this sequence, it will be very difficult to attach the mat.
8 WARNING - Do not use the trampoline until it is completely assembled. Failure to follow these instructions may cause rods to break or eject from the trampoline frame. NOTE - Check that the net is not caught on the trampoline frame or the bolts – if the net catches, it may tear. Moving clockwise around the frame, carefully slide the net up to the top of the white mat rods. Then, starting at one of the blue stickers on the curved frames, gently and slowly pull the net up and over the edge of the mat.
9 1 Unfold and align 2 Secure WARNING - Treat any loaded rod with caution until you are sure it is properly installed or uninstalled. Keep your face well away from any loaded rod. Assemble the black net rods as shown. Locate the pockets at the top edge of the net and install all of the black net rods. Take care to fully push the ball of the black net rod into the pocket as shown.
10 WANT TO ENVIE DE SAUTER? AT A TIME. IT SAFE! ONE FOIS. UNE À LA JUMP? DO SÉCURITÉ! EN TOUTE FAITES-LE WANT TO ENVIE DE SAUTER? AT A TIME. IT SAFE! ONE FOIS. JUMP? DO UNE À LA SÉCURITÉ! EN TOUTE FAITES-LE WARNING - Never attempt to remove a black net rod from its net rod pocket or disengage (unlock) the rod sleeve while the black net rod is under tension.
1 Disassembly WARNING - Never remove a black net rod from its net rod pocket or disengage (unlock) the rod sleeve while the black net rod is under tension. First, remove the net rod from the net rod socket on the frame. Always ensure a solid grip when handling and do not stand directly in front of the rods. Outside Person: Remove the white c-clips located on the net rod sockets. Lift the bottom end of the black net rods out of the net rod sockets and lower the net.
2a 1 Outside Person: Hold the white mat rod with your palm facing up and bend your arm at a right angle. 3 Inside Person: Take hold of the rod with both hands. Outside Person: Stand with one leg forward and bend your knees. Push your elbow into your hip. 2 4 Inside and Outside Person: Ensure the outside person's hands are positioned as shown. Check that their left hand is tight against the corner of the mat rod holder but not obstructing the opening.
2b 5 Outside Person: Push forward, rocking from your heels to the balls of your feet, using the weight of your body to push the white mat rod over the back edge of the mat rod holder. Keep the mat edge horizontal with your other hand. 6 Inside Person: Once the ball comes to the back edge of the mat rod holder, pull the white mat rod down and out. Sometimes a forceful pull is needed to dislodge the ball from the mat rod holder.
TOP VIEW 3 5 TOP VIEW 4 13 12 5 6 11 A 7 3 2 8 1 14 B 10 15 16 9 WARNING - Treat any loaded rod with caution until you are sure it is properly installed or uninstalled. Keep your face well away from any loaded rod. NOTE - Following the sequence shown spreads the tension evenly across the mat. If you do not follow this sequence, it will be very difficult to remove the mat.
If you purchased tgoma® for your trampoline, scan here or visit http://springfr.ee/s2tgoma-install for a helpful installation instructions. Alternatively, follow the instructions in your tgoma manual. Springfree is the world’s first and only Smart Trampoline. The four black sensor top plates on your mat mean that your trampoline is digitally enabled to create an interactive Smart Play experience when you purchase the tgoma game system.
