8inch Built-In Dishwasher Installation Instruction SD-9252W SD-9252SS
READ CAREFULLY AND KEEP THESE INSTRUCTIONS. BEFORE INSTALLATION Read these instructions completely and carefully. IMPORTANT Observe all governing codes and ordinances. CONTENTS Material You Will Need . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Tools . . . . . . . . . . . . .. . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Unit Dimensions . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation Preparation 1
choose C and D. Installation Preparation UNIT DIMENSIONS 18" DRAIN CONNECTIONS The type of drain installation depends on the answers to the following questions: • Is air gap required by local codes and ordinances? • Will waste tee or disposer connection be less than 18” above the floor? If both answers are YES, use method A or B. Otherwise choose C or D.
Installation Preparation PREPARE ELECTRICAL WIRING WARNING! FOR PERSONAL SAFETY: Remove house fuse or open circuit breaker before beginning installation. Do not use an extension cord or adapter plug with this appliance. GROUNDING INSTRUCTIONS--Power Cord Models This appliance must be grounded. In the event of a malfunction or breakdown, grounding will reduce the risk of electric shock by providing a path of least resistance for electric current.
Installation Instructions PREPARE WATER LINE ADJUST DOOR BALANCE The line may enter from either side, rear or floor within the shaded area. The line may pass through the same hole as the electrical cable and drain hose. Or cut an additional hole of 1-1/2” max. Note: Power cords with plug must pass through a separate hole. To check door balance, hold the top of the dishwasher firmly. Open the door slowly, if the door drops when released, increase spring tension.
Installation Instructions INSTALL POWER CORD Skip this step if dishwasher will be direct wired or has a factory installed power cord. The power cord and connections must comply with the National Electrical Code, Section 422 and/or local codes and ordinances. Be sure power is turned off at the source. A Remove Junction Box Cover C Insert Power Cord Wires Thru Strain Relief and Tighten White 1. Remove junction box cover. 2. Secure house wiring to the back of the junction box with a strain relief. 3.
Installation Instructions SLIDE DISHWASHER INTO CABINET DO NOT PUSH AGAINST FRONT PANEL WITH KNEES. DAMAGE WILL OCCUR. Slide dishwasher into the opening a few inches at a time. As you proceed, pull the drain hose through the opening under the sink. Stop pushing when the dishwasher is a few inches forward of adjacent cabinetry. Make sure drain hose is not kinked under the dishwasher and there is no interference with the water line and wiring or any other component.
Installation Instructions POSITION DISHWASHER, SECURE TO CABINET The dishwasher must be secured to the countertop or the cabinet sides. When countertops are made of wood use Method 1. When countertops are granite or other materials that will not accept screws, use Method 2 to secure at the sides. Method 2: Secure dishwasher with side-mounting brackets Position dishwasher so that the door lines up with the front face of adjacent cabinets.
Installation Instructions CONNECT DRAIN LINE FOLLOW ALL LOCAL CODES AND ORDINANCES. If a longer drain hose is required, add up to 42” of length for a total of 10 ft. to the factory installed hose. Use 5/8" or 7/8" inside diameter hose and a coupler to connect the two hose ends. Secure the connection with hose clamps. Hose Clamp Coupler Hose Clamp Figure 22 * Secure the drain hose to the air gap, waste tee or disposer with clamps.
Installation Instructions PRE-TEST CHECK LIST DISHWASHER WET TEST Review this list after installation to avoid charges for a service call that is not covered by your warranty. • Turn on power supply(or plug power cord into outlet, if equipped). • Start with normal wash. • Check to be sure that water enters the dishwasher. If water does not enter the dishwasher, check to be sure that water and power supply are turned on. • Check for leaks under the dishwasher.