® ® TWO-SIDED GRILLS 230V MODELS ® CG10, GR10 CG14 & GR14 CG28 & GR28 SERIES Installation and Operation Instructions ® 2M-Z8985 Rev. D 11/18/09 35.6 CM X 35.6 CM Grooved Grill 35.6 CM X 71.
SAFETY SYMBOL These symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual accompanying the appliance. RETAIN THIS MANUAL FOR FUTURE REFERENCE NOTICE Using any part other than genuine Star factory supplied parts relieves the manufacturer of all liability. Star reserves the right to change specifications and product design without notice.
PRODUCT IDENTIFICATION Star Manufacturing International, Inc.
GENERAL INSTALLATION DATA VENTILATION AND CLEARANCES The installation of any components such as a vent hood, grease extractors, and/or fire extinguishing systems, must conform to their applicable nationally recognized installation standards and/or local building codes.
ELECTRICAL SPECIFICATIONS Rated Wattage Model No. Volts GR 10 GR 10I CG 10I GR 14 GR 14I CG 14 CG 14I CG 28I GR 28I 230 230 230 230 230 230 230 230 230 Amps NEMA Plug 1653 7.2 1653 7.2 1653 7.2 1653 7.2 3306 14.2 1653 7.2 3306 14.2 6612 28.7 6612 28.7 INITIAL START UP Level unit using the adjustable feet under the unit (approximately 1/2" adjustment). Before using the unit for the first time, clean and heat for approximately 30 minutes.
ON/OFF ROCKER SWITCH (TIMER MODELS ONLY) The switch turns the unit on and off. The switch has three positions: With the switch in this position, both top and bottom platens will heat. With the switch in this position, neither platen will heat. With the switch in this position only bottom platen will heat. DAILY OPERATION Always allow 10-20 minutes of preheat time before loading the unit with product. Failure to allow sufficient preheat time will result in unsatisfactory cooking of the first load.
CLEANING CON'T OPERATION TROUBLESHOOTING CAUTION DO NOT USE SHARP OBJECTS TO REMOVE CARBON BUILD-UP. BEFORE CLEANING MAKE SURE POWER IS TURNED OFF, UNIT IS UNPLUGGED AND IS NOT TOO HOT. While holding top lid with one hand, apply only cleaners which are safe for aluminum and iron surfaces. Wipe with clean sponge or towel until unit is clean. DO NOT SPLASH FRONT CONTROL PANEL! DO NOT SPLASH FLEX CONDUIT CONNECTING TOP AND BOTTOM OF THE UNIT. 1. Unit not heating. A.
INTERNATIONAL ONE (1) YEAR EQUIPMENT WARRANTY All workmanship and materials in “STAR” products are warranted for a period of one year from the date shipped from the factory or one year from the date shown on the proof of purchase of the end-user when purchased through an authorized “STAR” dealer/distributor in a commercial foodservice location. “STAR’s” obligation under this warranty is limited to the replacement of the defective part(s) only without charge.
TOP ELEMENT 15 AMP PLUG NEMA 5-15P ON ALL 120V UNITS. NEMA 6-15P ON 240V, 1,800 WATT UNITS. 20 AMP PLUG NEMA 6-20P ON 240V, 3,600 WATT UNITS. GREEN INLET IEC 320 16A WHITE BLACK TERMINAL BLOCK TRANSFORMER G L N 20 9 18 10 8 1 19 6 2 6 4 8 7 13 5 230V UNITS BOTTOM ELEMENT THERMOSTAT 9 3 7 3 INDICATOR LIGHT (POWER ON) 10 12 13 E2 E1 11 12 3 2 4 11 5 1 SWITCH TIMER BOARD FOR REFERENCE WIRING DIAGRAM IS SHOWN AS UNIT IS ASSEMBLED WITH THE BOTTOM PLATE REMOVED.
CK. DATE LIMITS UNLESS OTHERWISE NOTED FRACTIONS 1/64 DECIMALS .005 DR. MATERIAL 7-05-99 - BOTTOM ELEMENT (ELEMENTO MAS BAJO) BOTTOM ELEMENT (ELEMENTO MAS BAJO) 1 1 1 1 1 1 1 1 QTY. (CANTIDAD) TOP ELEMENT (ELEMENTO MAS ALTO) D9-GR0058 D9-GR0059 D9-GR0060 D9-GR0064 D9-GR0057 D9-GR0065 D9-GR0106 D9-GR0107 PART NO. (PARTE NO.) TOP ELEMENT (ELEMENTO MAS ALTO) 4 2,5 1,8 3,6,7 10 9 11 12 WIRE NO (HILO NO.) 10 SUNNEN DRIVE ST. LOUIS, MO 63143 STAR MFG. INTERNATIONAL, INC.
2 3 20 FRONT CONTROL PANEL REAR PANEL TERM BLOCK (BLOQUE TERMINAL) L N G NEMA L6-30 P PLUG NO REPRODUCTION OR DISCLOSURE OF ITS CONTENTS IS PERMITTED. 15 14 240V UNITS 230V UNITS INLET IEC 320 16A THIS DRAWING CONTAINS INFORMATION CONFIDENTIAL TO STAR MFG. INT'L. INC. MODEL: GR-CG28I-230/240V PILOT LIGHT T-STAT 1 WHITE (BLANCO) BLACK (NEGRO) GREEN (VERDE) 18 19 BOTTOM ELEMENT (ELEMENTO MAS BAJO) TOP ELEMENT (ELEMENTO MAS ALTO) 1 1 1 1 1 QTY.
4 5 3 11 2 10 6 1 7 8 12 13 54 53 9 52 14 54 PR EC Favo o a de no CI ON sum la base sobr e ia gu e GR que ncad roc an ergi este r agua con er a. teng ase ient LI OR SUP NO TOC CAL ERI AR IEN FIC IE TE AU rde dejar esta No m Main corr PE FAV lejos agu a. de O Do CAU not imm erse base Do stan hos e T NO run p nin dow in 24 TIO N let wate r. n. 15 awa g GE T or d not Kee DAN DO HO y from wat er. R SU TOU RFA CH CE .
PARTS LIST November 18, 2009, Rev D MODEL Key Number Part Number Number Per Unit 10' TWO SIDED GRILLS Description Model 1 2C-Z2992 2 SCREW, HANDLE 2 2V-Z2990 1 HANDLE - 10” 3 2B-Z2988 2 ARM - 10” 4 2C-08-07-0040 4 NUT 4 2C-08-07-0262 4 WASHER 5 2C-Z2992 4 SCREW, ARM TO BRACKET 6 D9-Z2038 1 HOUSING-TOP-10” 7 2C-Z3200 2 PIN - TOP HOUSING 8 2C-Z2855 2 RETAINER RING 9 2C-08-07-0040 2 1/4” NUT, USE PART NUMBER 2C-Z2820 10 24-Z3827 1 CONDUIT KEEPER PLATE 11 2C-Z3780 2 CONDUIT RETAINER
PARTS LIST November 18, 2009, Rev D MODEL Key Number Part Number Number Per Unit 10' TWO SIDED GRILLS Description Model 41 2K-Z1971 4 SPACER CG10T, CG10IT, GR10T, GR10IT 42 2J-Y6689 1 PILOT LIGHT, 120V GR10, GR10I, CG10I (120V MODELS) 2J-Z2329 1 PILOT LIGHT, 240V GR10, GR10I, CG10I (240V MODELS) 43 D9-GR0051 1 FACEPLATE ASSY. - 10” w/TIMER GR10T, GR10IT, CG10IT D9-GR0109 1 FACEPLATE ASSY.
PARTS LIST November 18, 2009, Rev D MODEL Key Number Part Number Number Per Unit 14' TWO SIDED GRILLS Description Model 1 2C-Z2992 2 SCREW, HANDLE 2 2V-Z2989 1 HANDLE - 14” 2V-Z3413 1 HANDLE - 14” S.S. GR14, GR14T SER.
PARTS LIST November 18, 2009, Rev D MODEL Key Number Part Number Number Per Unit 14' TWO SIDED GRILLS Description Model 31 D9-GR0032 2 TORQUE BOX ASSY. 32 D9-Z3071 4 BRACKET-HANDLE 33 2V-Z3072 2 HANDLE - SIDE 34 D9-GR0034 1 GREASE CABINET ASSY. 35 D9-GR0517 1 GREASE DRAWER ASSY 37 D9-GR0247 1 BASE BOTTOM - 14” 230V MODELS 38 2A-Z0314 4 FOOT, 4” GR14I, GR14IT, CG14I, CG14IT, CG14IGT, CG14ITGT 2A-Z1485 4 FOOT, 1” ADJUSTABLE 39 D9-GR0061 1 BODY ASSY.
46 39 40 41 42 43 38 (O ER OFF POW ) ON (I) ax -M Pro TIME START STOP 11 36 37 43A 10 STOP START TIME 31 (O ER OFF POW ) ON (I) 35 NO REPRODUCTION OR DISCLOSURE OF ITS CONTENTS IS PERMITTED. THIS DRAWING CONTAINS INFORMATION CONFIDENTIAL TO STAR MFG. INT'L. INC. MODEL:GR28I,CG28I,CG28IGT-240V 44 45 47 1A 1 2 2A 48 26 18 8 7 2B 3 25 o este N 32 not from Do Do hose in or water . let ION UT se 23 .
PARTS LIST MODEL Key Number Part Number Number Per Unit November 18, 2009, Rev D 28' TWO SIDED GRILLS Description 1 2M-Z2989 2 HANDLE, 14” 1A 2C-Z2992 4 BOLT 1/4" 20X1 PHP STL NP 2 2B-Z2987 4 ARM, 14” 2A 2C-Z2992 8 BOLT 1/4" 20X1 PHP STL NP 2B 2C-08-07-0262 8 WASHER 1/4" INT STL NP 2C 2C-08-07-0040 8 NUT 1/4"-20 ACHD STL NP 3 2M-Z2620 2 LABEL, CAUTION 4 2C-Z2820 4 PIN, TOP HOUSING 5 D9-Z2306 2 TOP HOUSING 14” 5A 2A-Z3827 2 CONDUIT STAMPING PLATE 6 D9-04-GR-0166 2 WIRE MOUNT 7 D9-GR007
PARTS LIST MODEL Key Number Part Number Number Per Unit November 18, 2009, Rev D 28' TWO SIDED GRILLS Description 30 D9-GR0114 1 FACE PLATE - RIGHT w/TIMER D9-GR0118 1 FACE PLATE - RIGHT w/PILOT LIGHT 31 D9-GR0099 1 FACE PLATE - LEFT w/TIMER D9-GR0119 1 FACE PLATE - LEFT w/PILOT LIGHT 32 2J-Z1836 2 TIMER CONTROL 33 2K-Z1971 8 SPACER 34 2E-Z6863 2 SWITCH, 3 POSITION, PS-GR0225 1 SWITCH KIT 35 2R-Z1854 2 KNOB - THERMOSTAT 36 2T-6447 2 THERMOSTAT 37 2A-Z3026
STAR MANUFACTURING GROUP Star - Holman - Lang - Wells - Bloomfield - Toastmaster 10 Sunnen Drive, St. Louis, MO 63143 U.S.A. (800) 807-9054 (314) 781-2777 Parts & Service (800) 807-9054 www.star-mfg.