Owner's manual

3
95 North Oak Street • Kendallville, IN 46755 • © 2014 Star Water Systems. All rights reserved.
SAFETY INFORMATION
DANGER
ELECTRICAL SHOCK HAZARD.
Always disconnect power source before performing any work on or near the motor or its
connected load. If the power disconnect point is out-of-sight, lock it in the open position
and tag it to prevent unexpected application of power. Failure to do so could result in
fatal electrical shock.
ELECTRICAL SHOCK HAZARD.
Do not handle the pump with wet hands or when standing in water as fatal electrical
shock could occur. Disconnect main power before handling unit for ANY REASON!
RISK OF ELECTRIC SHOCK.
These pumps have not been investigated for use in swimming pool areas.
ELECTRICAL SHOCK ALERT.
Follow all local electrical and safety codes, as well as the National Electrical Code (NEC) and
the Occupational Safety and Health Act (OSHA).
ELECTRICAL SHOCK ALERT.
Replace damaged or worn wiring cord immediately. Never use an extension cord.
ELECTRICAL SHOCK ALERT.
Do not kink power cable and never allow the cable to come in contact with oil, grease, hot
surfaces, or chemicals.
ELECTRICAL SHOCK ALERT.
Wire motor to correct supply voltage. See motor nameplate and wiring diagrams and check
voltage of power supply.
ELECTRICAL SHOCK ALERT.
Unit must be securely and adequately electrically grounded. This can be accomplished by
wiring the unit to a ground metal-clad raceway system or by using a separate ground wire
connected to the bare metal of the motor frame or other suitable means.
ELECTRICAL SHOCK ALERT.
Do not disassemble the motor housing. This pump has no repairable internal parts and
disassembling may cause leakage or dangerous electrical wiring issues.
ELECTRICAL SHOCK ALERT.
Make certain the electrical power source is adequate for the requirements of the pump.
ELECTRICAL SHOCK ALERT.
Never use an extension cord with this pump.
CHEMICAL ALERT.
This product contains chemicals known to the state of California to cause cancer and birth
defects or other reproductive harm.
HAZARDOUS PRESSURE ALERT.
Install pressure relief valve in discharge pipe. Release all pressure on system before working
on any component.
EXPLOSION ALERT
Do not use to pump ammable or explosive uids such as gasoline, fuel oil, kerosene, etc.
Do not use in ammable and/or explosive atmospheres.
WARNING