Installation Manual

2 | CK 15-20 E / CKT 15-20 E WWW.STIEBEL-ELTRON-USA.COM
CONTENTS | OPERATION
IMPORTANT INSTRUCTIONS
OPERATION
1. Important Instructions ���������������������������������������2
1.1 Document information ������������������������������������������ 2
1.2 Safety information ����������������������������������������������� 2
1.3 Other symbols in this document ������������������������������ 3
2. Safety ���������������������������������������������������������� 3
2.1 Intended use ������������������������������������������������������ 3
2.2 Safety information ����������������������������������������������� 3
2.3 Licences / certificates ������������������������������������������� 4
2.4 Test symbols ������������������������������������������������������ 4
3. Register your product ���������������������������������������4
4. Appliance description ���������������������������������������4
4.1 Control with external room temp. controller �������������� 4
5. Operation CK 15 E / CK 20 E ���������������������������������4
5.1 Starting heating �������������������������������������������������� 4
5.2 Stopping heating / frost protection �������������������������� 4
6. Operation CKT 15 E / CKT 20 E ������������������������������4
6.1 Starting heating �������������������������������������������������� 5
6.2 Adjusting the time switch �������������������������������������� 5
6.3 Stopping heating / frost protection �������������������������� 5
7. Cleaning, care and maintenance ���������������������������5
8. Storage ��������������������������������������������������������5
9. Troubleshooting ����������������������������������������������5
INSTALLATION
10. Safety ���������������������������������������������������������� 5
10.1 General safety information ������������������������������������ 5
10.2 Instructions, standards and regulations �������������������� 5
11. Appliance description ���������������������������������������5
11.1 Standard delivery ������������������������������������������������ 5
12. Installation ����������������������������������������������������5
13. Electrical connection �����������������������������������������6
13.1 Removing the front cover �������������������������������������� 6
13.2 Routing wire to the terminal block ��������������������������� 6
13.3 Terminal block ���������������������������������������������������� 6
14. Appliance handover ������������������������������������������6
15. Specification ��������������������������������������������������7
15.1 Dimensions �������������������������������������������������������� 7
15.2 Minimum clearances to hard surfaces ���������������������� 7
15.3 Specification table ����������������������������������������������� 8
15.4 Wiring diagram CK 15 E ���������������������������������������� 8
15.5 Wiring diagram CKT 15 E ��������������������������������������� 9
15.6 Wiring diagram CK 20 E ���������������������������������������� 9
15.7 Wiring diagram CKT 20 E �������������������������������������� 10
16. Warranty ���������������������������������������������������� 11
OPERATION
1. Important Instructions
SAVE THESE INSTRUCTIONS
When using electrical appliances, basic precautions should always
be followed to reduce the risk of fire, electric shock, and injury to
persons, including the following:
1. Read all instructions before installing or using this heater.
2. This heater is hot when in use. To avoid burns, do not let bare
skin touch hot surfaces. Keep combustible materials, such as fur-
niture, pillows, bedding, papers, clothes, etc. and curtains at least
3 feet (1 m) from the front of the heater and keep them at least 3
feet (1 m) away from the sides and rear.
3. Extreme caution is necessary when any heater is used by or
near children or invalids and whenever the heater is left operating
and unattended.
4. Do not operate any heater after it malfunctions. Disconnect
power at service panel and have heater inspected by a reputable
electrician before reusing.
1.1 Document information
The chapter Operation is intended for users and heating contrac-
tors.
The chapter Installation is intended for heating contractors.
Note
Read these instructions carefully before using the ap-
pliance and familiarize yourself with its functions. Keep
these instructions safe. Pass on the instructions to a new
user if required.
1.2 Safety information
1.2.1 Structure of safety information
KEYWORD Type of risk
Here, possible consequences are listed that may result
from not observing the safety information.
f Steps to prevent the risk are listed.