OPERATOR’S MANUAL GRIDIRON™ GRILL STG1050 LP GAS CYLINDER SOLD SEPARATELY FOR OUTDOOR USE ONLY Visit the STŌK® website at: www.stokgrills.com DANGER: DES IGN You WILL be KILLED or SERIOUSLY HURT if you do not follow the instructions in this operator’s manual. C ER TIFIE D NOTE TO INSTALLER/ASSEMBLER: Give this Operator’s Manual to the consumer so the consumer may retain it for future reference.
TABLE OF CONTENTS Introduction.......................................................................................................................................................................2 General Safety Rules..................................................................................................................................................... 3-4 Specific Safety Rules................................................................................................................
GENERAL SAFETY RULES The grill shall not be used under overhead combustible construction. WARNING: Read and understand all instructions. Failure to follow all instructions listed below, may result in electric shock, fire and/or serious personal injury. READ ALL INSTRUCTIONS This appliance must be installed in accordance with the latest local codes.
GENERAL SAFETY RULES If a leak is detected at any time, get away from the LP gas cylinder and call the fire department. This grill is not intended to be used on a boat, in an RV, camper trailer, or motor home. Do not use the grill until leak-tested. Periodically check and/or clean the burner/venturi tubes for insects and insect nests. A clogged tube can lead to a fire beneath the grill.
SYMBOLS The following signal words and meanings are intended to explain the levels of risk associated with this product. SYMBOL SIGNAL MEANING DANGER: Indicates an imminently hazardous situation, which, if not avoided, will result in death or serious injury. WARNING: Indicates a potentially hazardous situation, which, if not avoided, could result in death or serious injury. CAUTION: Indicates a potentially hazardous situation, which, if not avoided, may result in minor or moderate injury.
FEATURES PRODUCT SPECIFICATIONS Fuel source......................................Propane (not included) Natural gas convertible.................................................. No BTU rating................................................................ 15,000 Total grill surface................................................ 338 sq. in. Grilling surface height................................................. 31 in.
LOOSE PARTS C B AA CC A E DD BB DD D FF EE F G Fig. 3 A - Firebox handle........................................................... 1 B - Grease cup................................................................ 1 C - Grate insert................................................................ 1 D - Grate.......................................................................... 1 E - Wheel......................................................................... 2 F - Stand front handle............
ASSEMBLY UNPACKING This product requires assembly. Carefully lift grill from the carton and place it on a level work surface. WARNING: Do not use this product if any parts on the Loose Parts List are already assembled to your product when you unpack it. Parts on this list are not assembled to the product by the manufacturer and require customer installation. Use of a product that may have been improperly assembled could result in serious personal injury.
ASSEMBLY STEP 3: OPENING THE STAND See Figure 8 - 10. Grasp the stand front handle and raise the stand until it rests on the wheels and frame support. WARNING: Use the stand front handle to raise the stand. Do not raise by any part of the grill that is attached to the stand. Failure to heed this warning can result in possible injury and damage the grill. Step on the release lever and pull the stand front handle toward you at the same time.
ASSEMBLY STEP 4: ATTACHING FIREBOX HANDLE See Figures 11 - 12. Raise and open the stand. Lift the hood latch then raise firebox hood. Insert studs in firebox handle (A) through holes in firebox hood. Install wing nuts (AA) and tighten securely. FIREBOX HANDLE WING NUT STEP 5: INSTALLING THE GREASE CUP See Figure 13. Slide the grease cup (B) into the cup holders on the bottom of the grill. NOTE: Clean the grease cup after each use.
ASSEMBLY STEP 6: INSTALLING BATTERY IN IGNITOR See Figure 14. Turn the ignitor cap counterclockwise and lift cap from the control panel. Slide a AAA battery (CC), negative (—) end first, into the ignitor. Be sure spring is still in place inside the ignitor cap. Replace ignitor cap. STEP 7: CONNECTING THE LP GAS CYLINDER TO THE REGULATOR See Figure 15. Remove cap from LP gas cylinder. Hold the LP gas cylinder firmly and insert into the regulator.
ASSEMBLY “Growing” bubbles indicate a leak. Remove the LP gas cylinder and recap the bottle. NOTE: If leaks cannot be stopped, do not try to repair. Call for replacement parts. STAND FRONT HANDLE STEP 9: CLOSING STAND AND TRANSPORTING THE GRILL See Figures 17 - 18. Never close the stand or attempt to move the grill unless the grill is completely cool, the grease cup is empty, and the LP gas cylinder is removed.
OPERATION COOKING/GRILLING TIPS WARNING: Do not allow familiarity with grill to make you careless. Remember that a careless fraction of a second is sufficient to inflict severe injury. WARNING: Do not use any attachments or accessories not recommended by the manufacturer of this grill. The use of attachments or accessories not recommended can result in serious personal injury.
OPERATION IGNITING THE BURNER To ignite burner using match lighting: See Figures 19 - 20. Open the firebox hood. NOTE: Never lean over the grill while lighting burner. The first time you use your newly purchased grill, it is recommended the grill run on the highest setting for 15 - 20 minutes. Turn control knob to OFF ( O ). To ignite burner using the electric ignitor: Open the firebox hood. Turn the control knob on the side shelf to OFF ( O ).
OPERATION WARNING: Never use an accessory if the porcelain coating is damaged or chipped. Use with a damaged coating could result in serious personal injury if ingested. USING THE GRILL AND ACCESSORIES NOTE: When grilling fish, the meat is typically done when it flakes easily with a fork. If any part of the meat is glossy in appearance, it is not done. When finished cooking, turn the control knob off. NOTE: To lock the control knob in the off position, turn the control knob to LOCK ( ).
MAINTENANCE PORT SHIELD WARNING: When servicing, use only identical replacement parts. Use of any other parts could create a hazard or cause product damage. BURNER GENERAL MAINTENANCE When cleaning the inside of the firebox hood and grill bottom, use a strong solution of detergent and water with a scrub brush to clean. Rinse thoroughly and allow to air dry. NEVER use a caustic grill cleaner on painted or cooking surfaces.
MAINTENANCE Once burner tube is clear of debris, use a wire brush to remove food and dirt from the outer surface of the tubes. Check burner for damage. Normal wear and corrosion may cause some holes to enlarge. Replace burner if this happens. NOTE: Burner tube must reengage valve opening. n Verify that the gas valve orifice is correctly positioned inside burner inlet. Attach the electrode to the burner and carefully replace the burner. Slide burner into the grill and secure burner using wing nuts.
TROUBLESHOOTING PROBLEM Smell of gas CAUSE Regulator, or valve leaking. Flame flashback beneath control panel Fire in burner tube due to blockage. SOLUTION Remove LP cylinder immediately and check for damaged regulator or valve. Perform leak test, see Testing Valves and Regulator for Leaks in the Assembly section. See Cleaning Burner Assembly and Checking Venturi for Insects in the Maintenance section.
WARRANTY STŌŌK® GAS GRILL LIMITED WARRANTY Thank you for purchasing a STŌŌŌK® brand grill. Below is our limited gas grill product warranty. Before submitting a warranty claim, we suggest you read the Operator’s Manual that came with your grill. You may discover an easy and simple solution to your problem. If you cannot find the manual, a replacement can be obtained by calling the number below, or by downloading one from our web site at the address below.
OPERATOR’S MANUAL GRIDIRON™ GRILL STG1050 Customer Service Information: For parts or service, please call 1-800-847-5993 or visit us online at www.stokgrills.com. The model number and serial number of this grill is found on a label located on the leg stand. Please record the serial number in the space provided below. When ordering repair parts, always give the following information: Model No. Serial No. ONE WORLD TECHNOLOGIES, INC. 1428 Pearman Dairy Road, Anderson, SC 29625 Phone 1-800-847-5993 www.
