Product Manual

ELECTRIC WINCH RATING*
5% 10% 20% 30% 50% 70%
(3°) (6°) (11°) (17°) (26°) (35°)
SA5000,
10,000 lbs. 7,500 lbs. 5,100 lbs. 3,900 lbs. 2,700 lbs. 2,200 lbs. 1,500 lbs.
SA5015
4,536 kg 3,402 kg 2,313 kg 1,769 kg 1,225 kg ,998 kg ,680 kg
SA7000,
14,600 lbs.11,000 lbs. 7,400 lbs. 5,700 lbs. 4,000 lbs. 3,300 lbs. 2,200 lbs.
SA7015
6,623 kg 4,990 kg 3,357 kg 2,586 kg 1,814 kg 1,497 kg ,998 kg
20,000 lbs.15,000 lbs.10,200 lbs. 7,700 lbs. 5,500 lbs. 4,500 lbs. 3,000 lbs.
9,072 kg 6,804 kg 4,627 kg 3,493 kg 2,495 kg 2,041 kg 1,361 kg
SA12000,
30,000 lbs. 22,600 lbs.15,200 lbs.11,600 lbs. 8,300 lbs. 6,800 lbs. 4,500 lbs.
SA12015
13,608 kg 10,251 kg 6,895 kg 5,262 kg 3,765 kg 3,084 kg 2,041 kg

12 Volt DC
E LECTRIC WINCHES
®
DOUBLE LINE OPERATION
Models SA7000, SA7015, SA12000 and SA12015
are factory equipped with a pulley block and hook
and 50' of cable for double line operation. This
increases the pulling capacity of the winch as
shown, however, care must be taken to allow ade-
quate motor cooling. Note that with double line, a
pull of 25' requires reeling in 50' of cable.
For intermittent use only. Ratings at left are based
on 10' pull. For longer pulls motor cooling periods
must be allowed.
CAUTION: CONTINUOUS RUNNING IN
EXCESS OF 4 MINUTES WILL DAMAGE WINCH
MOTOR.
GUIDE TO ROLLING LOAD CAPACITY**
Maximum weight in pounds and kilograms rolling load.
APPROXIMATE LOAD SPEED
(FT./MIN.)
MODEL PERCENT INCLINE
LOAD
CAPACITY*
(*) Load capacity (dead weight) is a measure of actual maximum force to which the
winch system may be subjected.
(**) All capacities shown are with 15' of cable on the reel and 10% rolling friction factor.
For full reel of cable adjust capacities according to graph above. Note 5% incline is
one-half foot rise in ten feet.
WINCH RATINGS
OWNER’S
MANUAL
5000
4500
4000
3500
3000
2500
2000
1500
1000
500
DEAD WEIGHT CAPACITY (LBS.)*
LENGTH OF CABLE ON REEL (FT.)
10 20 30 40 50
SA9
00
0
, SA9
0
0
5
, SA9
0
1
5
sin
gle
line
S
A
1
2
0
0
0
, S
A
1
2
0
1
5 d
o
u
b
l
e l
i
n
e
SA7000,
SA7
0
1
5
d
o
ubl
e
l
i
ne
S
A
5
0
0
0
,
S
A
5
0
1
5
sin
g
l
e
l
i
n
e
WARNING: NOT TO BE
USED AS A HOIST FOR
LIFTING, SUPPORTING OR
TRANSPORTING PEOPLE OR
LOADS OVER AREAS WHERE
PEOPLE COULD BE PRESENT!
NO LOAD FULL LOAD
Full Empty Full Empty
Reel Reel Reel Reel
33 12 84
16 6 4.5 3.5
11 542.5
9 2.5 2 1.5
WARNING:
READ INSTRUCTIONS CAREFULLY BEFORE
ATTEMPTING TO INSTALL, OPERATE OR SERVICE THE STRONGARM
ELECTRIC WINCH. FAILURE TO COMPLY WITH INSTRUCTIONS COULD RESULT
IN SERIOUS OR FATAL INJURY. RETAIN INSTRUCTIONS FOR FUTURE REFERENCE.
MODELS SA5000, SA5015, SA7000, SA7015,
SA9000, SA9005, SA9015, SA12000 & SA12015
SA9000,
SA9005,
SA9015
SA5000,
SA5015
SA7000,
SA7015
SA12000,
SA12015
SA9000, SA9005
SA9015