Digital Power Inverter Owner’s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety precautions may result in serious personal injury.
Thank you very much for choosing a Strongway™ product! For future reference, please complete the owner’s record below: Serial Number/Lot Date Code: ________________________________ Purchase Date: ____________________________________________ Save the receipt, warranty, and this manual. It is important that you read the entire manual to become familiar with this product before you begin using it. This inverter is designed for certain applications only.
Table of Contents Intended Use .......................................................................................................................................... 4 Technical Specifications ...................................................................................................................... 4 Important Safety Information ............................................................................................................... 6 Specific Operation Warnings .......................
Intended Use The Strongway Digital Power Inverter is a high-performance solution for using household power while on the road. Connected to the 12 volt output power source, the inverter efficiently and reliably supplies 115V/60Hz AC power for a wide variety of loads like laptops, microwaves, and cellular phones with power consumption under the rated watts. With proper care and appropriate use, the inverter will give you years of dependable service in your car, truck, RV, or boat.
#53071 Property AC Power Output #53071 Specification AC Power Voltage Maximum AC Output Power Maximum AC Output Surge Power AC Output Frequency AC Output Waveform USB Power Output 115V 2000W 4000W 58Hz - 62Hz Modified Sine Wave DC Output Voltage DC Power 5V DC, 2100mA DC Input Voltage Range Battery Drain Without AC Load Low Battery Shut-Down Point (Nominal) 11V to 15V DC ≤ 0.65A (at a 12V input) 10.5 ± 0.3V DC High Battery Shut-Down Point (Nominal) Fuse Efficiency (Maximum) Physical 15.5 ± 0.
#53067 Property DC Power #53067 Specification DC Input Voltage Range Battery Drain Without AC Load Low Battery Shut-Down Point (Nominal) 11V to 15V DC ≤ 0.5A (at a 12V input) 10.5 ± 0.3V DC High Battery Shut-Down Point (Nominal) Efficiency (Maximum) Physical 15.5 ± 0.5V DC 85% Ambient Operating Temperature Range 32°F to 104°F Important Safety Information ⚠WARNING Read and understand all instructions. Failure to follow all instructions may result in serious injury or property damage.
children to handle it. ⚠WARNING PERSONAL SAFETY Stay alert, watch what you are doing, and use common sense when operating the tool. Do not use the inverter while you are tired or under the influence of drugs, alcohol, or medication. A moment of inattention while operating the tool may result in serious personal injury. Dress properly. Do not wear loose clothing, dangling objects, or jewelry. Keep your hair, clothing and gloves away from moving parts.
SHOCK HAZARD DO NOT expose the inverter to rain, snow, spray, or bilge water. Make sure the inverter wiring is of proper size and rating and in good condition. Operating the inverter with damaged wiring may void the warranty. DO NOT use the inverter if it has been dropped, hit, worn, broken, or damaged. DO NOT attempt to service or disassemble the inverter, it does not have serviceable parts.
batteries. The batteries may produce a short circuit current that can weld metals, thereby causing severe burns on skin. Make sure there is plenty of fresh water, soap, and baking soda near the work area. If a person’s skin or clothing accidentally comes into contact with battery acid, wash immediately with baking soda, soap, and water. If the acid enters the eye, wash immediately with cold, running water for a minimum of twenty minutes and get medical attention immediately.
17 Page 10 of 16
Reference 1 2 3 4 Subassembly Ventilation Opening Cooling Fan Remote Switch Port USB Port 5 6 7 8 9 10 Digital Display Power Switch Button Output Power Indicator (W) AC Outlet AC Outlet Overload Reset Circuit Input Indicator (V) 11 12 13 14 15 16 Output Power Indicator (kW) Positive DC Terminal Ground Terminal Negative DC Terminal Terminal Covers Cooling Fans 17 DC Cable Assembly Instructions 1. Make sure the power switch on the inverter is OFF. 2.
Before Each Use Before installing the inverter, make sure the location meets the following conditions. This inverter has a mounting bracket. To secure and fasten your inverter, please mount the inverter. Dry Don't drop or pour any liquid on the inverter. Cool Keep the inverter away from direct lighting. Ventilate Safe Protect from battery gases Leave at least 2" of clearance around the inverter for air flow. Make sure the ventilation openings are not obstructed.
Note: Most devices require an initial surge of power to start. Most devices can be started up with two times their power rating. Be aware of the start-up power of the device(s) you intend to use for the inverter. This inverter has the start-up capacity two times of rated power. The combined loads must not exceed the rated power. The less combined wattage used, the longer the inverter will operate before the battery needs to be recharged.
Parts List Reference Part Description Quantity 1 Inverter 1 2 DC Cable (red + black) 2 3 Owner’s Manual 1 Image Replacement Parts For replacement parts and technical questions, please call Customer Service at 1-800-222-5381. Not all product components are available for replacement. The illustrations provided are a convenient reference to the location and position of parts in the assembly sequence.
Limited Warranty Northern Tool and Equipment Company, Inc. ("We'' or "Us'') warrants to the original purchaser only ("You'' or ''Your'') that the Strongway product purchased will be free from material defects in both materials and workmanship, normal wear and tear excepted, for a period of one year from date of purchase. The foregoing warranty is valid only if the installation and use of the product is strictly in accordance with product instructions.
Distributed by: Northern Tool & Equipment Company, Inc. Burnsville, Minnesota 55306 www.northerntool.