M U LT I - F U N C T I O N C O O K T O P I NSTALLATION I NSTRUCTIONS
As you follow these instructions, you will notice WARNING and CAUTION symbols. This blocked information is important for the safe and efficient installation of Wolf equipment. There are two types of potential hazards that may occur during installation. signals a situation where minor injury or product damage may occur if you do not follow instructions. states a hazard that may cause serious injury or death if precautions are not followed.
W O L F M U LT I - F U N C T I O N C O O K TO P I N S TA L L AT I O N R E Q U I R E M E N T S IMPORTANT NOTE: This installation must be completed by a qualified installer, service agency or gas supplier. IMPORTANT NOTE: Save these Installation Instructions for the local inspector’s use. Please read the entire Installation Instructions prior to installation. Installer: please retain these instructions for local inspector’s reference, then leave them with the homeowner.
W O L F M U LT I - F U N C T I O N C O O K TO P B E F O R E YO U S TA RT Proper installation is your responsibility. Have a qualified technician install this cooktop. You must also ensure that electrical installation is adequate and in compliance with all local codes and ordinances. The Wolf multi-function cooktop is manufactured for use with natural gas or LP gas. Please check the product rating plate for type of gas needed.
I N S TA L L AT I O N I N S T R U C T I O N S I N S TA L L AT I O N S P E C I F I C A T I O N S The illustrations below provide the overall dimensions, installation specifications and countertop cut-out for Model IM15/S. MODEL IM15/S DIMENSIONS If the cooktop is not installed above an oven, the gas service may be supplied through the floor.
W O L F M U LT I - F U N C T I O N C O O K TO P S I T E P R E PA R AT I O N L O C AT I O N R E Q U I R E M E N T S C O U N T E R T O P C U T- O U T D I M E N S I O N S The following minimum dimensions must be maintained when installing the Wolf gas multi-function cooktop, Refer to the Installation Specifications illustration on page 5. IMPORTANT NOTE: Countertop opening dimensions shown in the Installation Specifications illustration on page 5 must be used.
I N S TA L L AT I O N I N S T R U C T I O N S I N S TA L L AT I O N O P T I O N S M U LT I P L E C O O K T O P I N S TA L L AT I O N If the multi-function cooktop is to be used with any combination of additional cooktop units or modules with a filler strip, the cut-out width is calculated by adding the corresponding units' cut-out dimensions plus 1 1/4" (32) for each additional unit. Refer to the illustration below.
W O L F M U LT I - F U N C T I O N C O O K TO P G A S S U P P LY R E Q U I R E M E N T S EXPLOSION HAZARD — Use a new CSA approved gas supply line and install a gas shut-off valve. Securely tighten all gas connections. For LP gas, have a qualified technician make sure the gas pressure does not exceed 14" (34.9 mb) WC (water column). Failure to do so can result in explosion, fire or death. IMPORTANT NOTE: The gas multi-function cooktop must be connected to a regulated gas supply.
I N S TA L L AT I O N I N S T R U C T I O N S G A S S U P P LY R E Q U I R E M E N T S IMPORTANT NOTE: The supply line must be equipped with an approved external gas shut-off valve located near the cooktop in an accessible location. Do not block access to the shut-off valve. Refer to the illustration below. The inlet pressure to the regulator should be as follows for operation and checking the regulator setting: Natural Gas: Set pressure 5" (12.5 mb) WC, supply pressure 7–14" (17.5–34.9 mb) max.
W O L F M U LT I - F U N C T I O N C O O K TO P ELECTRICAL R E Q U I R E M E N T S ELECTRICAL SHOCK HAZARD — Plug into a grounded 3-prong electrical outlet. C O N TA C T I N F O R M AT I O N Copies of the standards listed may be obtained from: *National Fire Protection Association Batterymarch Park Quincy, Massachusetts 02269 **Canadian Standard Association 178 Rexdale Blvd. Etobicoke (Toronto), Ontario M9W 1R3 Do not remove ground prong. Do not use an adapter.
I N S TA L L AT I O N I N S T R U C T I O N S V E N T I L AT I O N O P T I O N S IMPORTANT NOTE: It is recommended that you operate the Wolf multi-function cooktop with either a Wolf cooktop ventilation hood, downdraft system or Pro ventilation hood. Contact your Wolf dealer for details. Cooktop Wall Hood – 30" (762) or 36" (914) widths in classic stainless steel. Cooktop Island Hood – 42" (1067) width in classic stainless steel.
W O L F M U LT I - F U N C T I O N C O O K TO P C O O K T O P I N S TA L L AT I O N Insert the cooktop into the countertop cut-out opening. Center the cooktop in the opening and make sure that the front edge of cooktop is parallel to the front edge of the countertop. Check that all required clearances are met. Use a pencil to outline the rear edge of the cooktop on the countertop. Remove the cooktop from the countertop opening.
I N S TA L L AT I O N I N S T R U C T I O N S S U R FAC E B U R N E R S GAS LEAK TESTING INITIAL LIGHTING Use a brush and liquid detergent to test all gas connections for leaks. Bubbles around connections will indicate a leak. If a leak appears, shut off gas valve controls and adjust connections. Then check connections again. Clean all the detergent solution from the cooktop. The cooktop burner uses an electronic igniter in place of a standing pilot.
W O L F M U LT I - F U N C T I O N C O O K TO P C O O K TO P R E M O V A L C O N TA C T I N F O R M AT I O N Wolf Customer Service: 800-332-9513 Website: wolfappliance.com If it is necessary to remove the multi-function cooktop for cleaning or service, shut off the gas supply. Disconnect the gas and electric supply. Remove the mounting brackets on the right and left side of the burner box and remove the cooktop. Reinstall in the reverse order and check the gas connection for leaks.
I N S TA L L AT I O N I N S T R U C T I O N S WIRING D I AG R A M SPARK MODULE WHITE N 1 A 2 RED 1 2 BLK WHITE 3 CONDUCTOR POWER CORD GRN RED RED BLACK WHITE WHITE BLACK Model IM15/S 8 15
W O L F A P P L I A N C E C O M PA N Y, L L C 807568 10 / 2005 P. O. B OX 4 4 8 4 8 MADISON, WI 53744 800-332-9513 W O L FA P P L I A N C E .
