MODEL E X 1 3 D/ E X 1 7 D E X 2 1 D/ E X 2 7 D ISSUE EMD-EU1622 2ZZ9990063
WARNING The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. NOTICE FEDERAL EMISSION COMPONENT DEFECT WARRANTY and CALIFORNIA EMISSION CONTROL WARRANTY are applicable to only those engines complied with EPA (Environmental Protection Agency) and CARB (California Air Resources Board) emission regulations.
FEDERAL EMISSIONS COMPONENT DEFECT WARRANTY EMISSIONS COMPONENT DEFECT WARRANTY COVERAGE This emission warranty is applicable in all States, except the State of California. Fuji Heavy Industries Ltd. and Robin America Inc., Wood Dale Illinois, (herein “ROBIN AMERICA”) warrant(s) to the initial retail purchaser and each subsequent owner, that this Nonroad engine (herein “engine”) has been designed, built, and equipped to conform at the time of initial sale to all applicable regulations of the U.S.
CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board and Fuji Heavy Industries Ltd. (herein “FUJI”) are pleased to explain the emission control system warranty on your 2002 and later Small Off-Road engine (herein "engine"). In California, the engine must be designed, built and equipped to meet the State's stringent anti-smog standards.
When warranty repair is needed, the engine must be brought to an authorized service dealer or warranty station’s place of business during normal business hours. In all cases, a reasonable time, not to exceed 30 days, must be allowed for the warranty repair to be completed after the engine is received by the authorized service dealer or warranty station. G.
FOREWORD Thank you very much for purchasing a ROBIN ENGINE. Your ROBIN ENGINE can supply the power to operate various sorts of machines and equipment. Please take a moment to familiarize yourself with the proper operation and maintenance procedures in order to maximize the safe and efficient use of this product. Keep this owner’s manual at hand, so that you can refer to it at any time.
1. SAFETY PRECAUTIONS Please make sure you review each precaution carefully. Pay special attention to statement preceded by the following words. WARNING “WARNING” indicates a strong possibility of severe personal injury or loss of life if instructions are not followed. CAUTION “CAUTION” indicates a possibility of personal injury or equipment damage if instructions are not followed. WARNING : EXHAUST PRECAUTIONS ■ Never inhale exhaust gasses.
■ Do not touch the spark plug and ignition cable when starting and operating the engine. ■ Never make adjustments on the machinery while it is connected to the engine, without first removing the ignition cable from the spark plug. Turning the crankshaft by hand during adjusting or cleaning might start the engine, and cause serious injury to the operator. ■ Operate the engine on a stable, level surface. If the engine is tilted, fuel spillage may result.
SYMBOLS Read the owner's manual. Stay clear of the hot surface. Exhaust gas is poisonous. Do not operate in an unventilated area. Stop the engine before refueling. US Fire, open flame and smoking prohibited. On (Run) Plus ; Positive polarity Off (Stop) Battery Engine oil Engine start (Electric start) Add oil 2. COMPONENTS (See Fig. 1) NOTE Please refer to the illustrations on the back page of the front cover or back cover for Fig. 1 to !0 indicated in the sentence.
3. PRE-OPERATION CHECKS 4. ELECTRIC STARTER MODELS For electric starter operation, proper electric wiring NOTE Engine shipped from our factory is without oil. Before starting engine, fill with oil. Do not over-fill. arrangements are needed before normal engine operation. 1. BATTERY ■ Use a battery rated 12V-24AH or larger. 1. CHECK ENGINE OIL (See Fig. 2) WARNING Before checking or refilling engine oil, be sure the engine is ■ Battery electrolyte contains sulphuric acid.
5. OPERATING YOUR ENGINE 4. WIRING (See Fig. 4) MAGNETIC SWITCH 1. STARTING CABLE (1) Open the fuel cock. (See Fig.4-q) To KEY SWITCH (TERMINAL "ST") (2) Turn the STOP SWITCH to the position “ I ” (ON). (See Fig.4-w) (3) Set the speed control lever 1/3 of the way towards the high speed position. (See Fig.4-e) EARTH WIRE (4) Close the choke lever. (See Fig.4-r) BATTERY (1) Connect positive (+) terminal of the magnetic switch and positive (+) terminal of the battery with battery cable.
(3) Close the fuel cock. (See Fig.6-e) 2. PERIODIC INSPECTION (4) Pull the starter handle slowly and return the handle to its original position when resistance is felt. This operation is necessary to prevent outside moist air from intruding into the combustion chamber. (See Fig.6-r) Periodic maintenance is vital to the safe and efficient operation of your engine. Check the table below for periodic maintenance intervals.
3. INSPECTING THE SPARK PLUG 7-w w) (See Fig.7 (1) Clean off carbon deposits on the spark plug electrode using a plug cleaner or wire brush. (2) Check electrode gap. The gap should be 0.6 mm to 0.7 mm (0.02 inch.-0.03 inch.). Adjust the gap, if necessary, by carefully bending the side electrode. Recommended Spark Plug : NGK BR-6HS (CHAMPION RL86C) 6. CLEANING AIR CLEANER 7-y y,u u) (See Fig.
7. PREPATIONS FOR STORAGE 9. EASY TROUBLESHOOTING q) 8-q 1. DISCHARGE FUEL (See Fig.8 (See Fig. !0) WHEN ENGINE WILL NOT START : WARNING Flame Prohibited If you do not use the engine more than 1 month, discharge fuel to prevent gum in the fuel system and carburetor parts. ■ Remove the fuel cup, place it over a container and open the fuel cock to discharge fuel from the fuel tank. ■ Remove the drain screw of the carburetor float chamber and discharge fuel. 8-w w) 2. ENGINE OIL (See Fig.
10. SPECIFICATIONS MODEL EX13D Type EX17D Displacement mL (cc) 126 169 211 265 Continuous Output kW/rpm (HP/rpm) 2.2/3600 (3.0/3600) 2.9/3600 (4.0/3600) 3.7/3600 (5.0/3600) 5.1/3600 (7.0/3600) Maximum Output kW/rpm (HP/rpm) 3.2/4000 (4.3/4000) 4.2/4000 (5.7/4000) 5.1/4000 (7.0/4000) 6.6/4000 (9.0/4000) Counterclockwise, as Viewed from P.T.O. Shaft side Lubricant Oil Capacity Automotive detergent oil (API/ SE or higher grade, SAE/ 10W-30 etc.) Liter 0.
PRINTED IN JAPAN June 2002 CE-Y