PKX series 201/301/401 201H 201ST/301ST 201T/301T/401T 210/310 220/320 220ST/320ST ISSUE EMD-PU7368 PRINTED IN JAPAN April 2012 9ZZ9990124 北米 SUBARU Pump
1 PKX201,301,401, 201H, 201ST, 301ST, 220ST, 320ST, 210, 310, 220, 320 5 1 6 4 2 3 1 1 7 3 2 2 1 18 9 17 16 2 3 15 19 5W 10 14 10W 20W Single grade 13 12 11 #20 20 #40 10W-30 Multi grade 21 Ambient temperature 22 23 2 4 10W-40 -20 -10 0 10 20 30 -4 14 32 50 68 86 104 F 40 C 4 24 PKX201T, 301T, 401T 5 3 #30 8 6 7 8 3 1 2 3 5 4 2 1 10 20 1 9 11 6 12 19 18 17 13 16 21 23 7 5 15 24 14 22 25 26
illust&WS us_PKX_EU7368 12.4.6 9:16 AM ページ1 6 5 6 1 1 PKX201,301,401, 201H, 201ST, 301ST, 220ST, 320ST, 210, 310, 220, 320 7 4 8 5 2 1 6 4 1 2 3 2 PKX201T, 301T, 401T 7 8 2 3 4 5 6 2 1 3 7 4 1 0.6 - 0.
illust&WS us_PKX_EU7368 12.4.
NOTICE FEDERAL EMISSION COMPONENT DEFECT WARRANTY and CALIFORNIA EMISSION CONTROL WARRANTY are applicable to only those engines/ generators complied with EPA (Environmental Protection Agency) and CARB (California Air Resources Board) emission regulations in the U.S.A. NOTICE To the engines/generators exported to and used in the countries other than the U.S.A.
FOREWORD Thank you very much for purchasing a SUBARU PUMP. ENGLISH This manual covers operation and maintenance of SUBARU PUMP. All information in this publication is based on the latest product information available at the time of approval for printing. Please read this manual carefully before operating. Please take a moment to familiarize yourself with the proper operation and maintenance procedures in order to maximize the safe and efficient use of this product.
1. SAFETY PRECAUTIONS ENGLISH Please make sure you review each precaution carefully. Pay special attention to statement preceded by the following words. WARNING “WARNING” indicates a strong possibility of severe personal injury or loss of life if instructions are not followed. CAUTION “CAUTION” indicates a possibility of personal injury or equipment damage if instructions are not followed. FRANÇAISE WARNING : EXHAUST PRECAUTIONS ■ Never inhale exhaust gasses.
Operate the pump on a stable, level surface. If the engine is tilted, fuel spillage may result. ENGLISH ■ NOTE Operating the pump at a steep incline may cause seizure due to improper lubrication even with a maximum oil level. ■ Do not transport the pump with fuel in tank or with fuel strainer valve open. ■ Keep the unit dry (do not operate it in rainy conditions). ■ Carefully check fuel hoses and joints for looseness and fuel leakage.
FRANÇAISE ENGLISH SYMBOLS Read manual. Shutt off fuel valve when the engine is not in use. Stay clear of the hot surface. Check for leakage from hose and fittings. Exhaust gas is poisonous. Do not operate in an unventilated room or enclosed area. Fire, open flame and smoking prohibited. Stop the engine before refueling. HOT, avoid touching the hot area. USA and CANADA only The engine emits toxic gas can kill you in minutes. Do not run in an enclosed area. Read INSTRUCTIONS FOR USE before use.
2. COMPONENTS (See Fig. 1) ENGLISH NOTE Please refer to the illustrations on the back page of the front cover or back cover for Fig. 1 to i indicated in the sentence.
3. PRE-OPERATION FOR STARTING ENGLISH (See Fig. 2) 4. CHECK FUEL (See Fig. 2-t) 1. CONNECT SUCTION HOSE q) (See Fig. 2-q Use a reinforced-wall or wire braided hose to prevent suction collapse. Since the pump self-priming time is directly proportional to hose length, a short hose is recommended. CAUTION FRANÇAISE Always use a strainer with the suction hose. Gravel or debris sucked into the pump will cause serious damage to the impeller and the pump casting.
4. OPERATING YOUR PUMP (2) Turn the STOP SWITCH to the position “ I ” (ON). (See Fig.3-w) (1) Set the speed control lever at the low speed position and allow the engine to run at low speed for 1 or 2 minutes before stopping. (See Fig.5-q) (3) Set the speed control lever 1/3 of the way towards the high speed position. (See Fig.3-e) (2) Turn the STOP SWITCH counterclockwise to the position “ ⃝ ” (OFF). (See Fig.5-w) (4) Close the choke lever. (See Fig.
2. PERIODIC INSPECTION CAUTION Periodic maintenance is vital to the safe and efficient operation of your pump. Replace rubber pipes for fuel passage every two years. If fuel leakage is found, replace the pipe immediately. ENGLISH Check the table below for periodic maintenance intervals. IT IS ALSO NECESSARY FOR THE USER OF THIS PUMP TO CONDUCT THE MAINTENANCE AND ADJUSTMENTS ON THE EMISSION-RELATED PARTS LISTED BELOW TO KEEP THE EMISSION CONTROL SYSTEM EFFECTIVE.
To prevent injury, pay attention to the hot oil. Make sure the fuel cap is tightly secured to avoid spillage. ■ For EX27/40 urethane foam, remove it from the paper element and wash it thoroughly with detergent. Then ■ For the paper element, clean by blowing on it with dry it before installing. (See Fig.7-y-w) compressed air from the inside or tapping on it gently to remove dirt. Change the paper element when doing (2) Re-install the drain plug before refilling oil. (See Fig.
6. PREPARATIONS FOR STORAGE 8. SPARK ARRESTER (OPTIONAL) q) 8-q 1. WATER (See Fig.8 1. SPARK ARRESTER ENGLISH Drain all water from the drain plug. CAUTION When retightening drain plug, be sure to clean the drain plug and the thread of casing. Otherwise, the thread may be damaged. 2. DISCONNECT THE DELIVERY HOSE Tilt the pump and drain all water from delivery hole. Severe damage to pump may result if water freezes in the pumping chamber. 8-e e thru r) 3. DISCHARGE FUEL (See Fig.
9. EASY TROUBLESHOOTING 2. PUMPING VOLUME IS SMALL. ■ Sucking air at suction side. (Check piping at suction side.) ■ Drop off engine output (Consult your nearest dealer.) ■ Breakage of mechanical seal. (Consult your nearest dealer.) ■ High suction lift (Lower.) ■ Suction hose is too long or thin. (Use a thick hose in minimum length.) ■ Leak of water from water passage. (Stop leaking.) ■ Clogging of foreign substance in impeller. (Disassemble and clean.) ■ Wear of impeller.
10. SPECIFICATIONS MODEL PKX201 PKX301 Total Head m(ft) Maximum Delivery Volume Liter(U.S.gal) / min Suction Head 80 x 80 (3 x 3) 100 x 100 (4 x 4) 50 x 50 (2 x 2) 31 (102) 27 (89) 30 (98) 28 (92) 600 (158) 970 (256) 1350 (356) 580 (153) 930 (246) Ceramic - carbon EX13 ENGINE Silicon - carbide EX17 EX27 EX13 EX17 Air - Cooled, 4 - cycle, OHC, Gasoline Engine Automotive detergent oil (API / SE or higher grade, SG, SH or SJ is recommended, SEA / 10W-30 etc.
PKX401T Self-priming, Trash pump Total Head 100 x 100 (4 x 4) Suction Head 1700 (449) 50 x 50 (2 x 2) 1100 (291) 80 x 80 (3 x 3) 30 (98) 28 (92) 580 (153) 930 (246) 8 (26) EX40 Ceramic - carbon EX16 Silicon - carbide EX17 EX16 EX17 Air - Cooled, 4 - cycle, OHC, Gasoline Engine Type Automotive detergent oil (API / SE or higher grade, SG, SH or SJ is recommended, SEA / 10W-30 etc.
PKX us_PU7368.pmd Page 14 12.4.6, 9:23 AM Adobe PageMaker 7.
PKX series 201/301/401 201H 201ST/301ST 201T/301T/401T 210/310 220/320 220ST/320ST ISSUE EMD-PU7368 PRINTED IN JAPAN April 2012 9ZZ9990124 北米 SUBARU Pump
