Installation Instructions and Manual

6
INSTALLATION / GAS REQUIREMENTS
UNPACKING YOUR GRILL
Included with your ALTURI grill are the following
loose items:
Cooking Grates: ALT30(2), ALT36(3), ALT42(3)
Burner Covers: ALT30(2), ALT36(3), ALT42(3)
Warming Rack: ALT30(1), ALT36(1), ALT42(1)
Drip Tray: ALT30(1), ALT36(1), ALT42(1)
Heat Zone Separators: ALT30(1), ALT36(2), ALT42 (2)
Rotisserie Kit: ALT30 (1), ALT36 (1), ALT42 (1)
Combustible Overhead Construction:
Exhaust hood required.
Non-Combustible Overhead Construction:
Exhaust hood is highly recommended.
Conversion Kit:
• Set of orifices
• If grill is factory set LP, NG orifices will be
included
• If grill is factory set NG, LP orifices will be
included
• The drip tray will be at the boom of
the unit and will slide into the drip tray
support brackets.
• Above the heat shields are the Red Brass
Burners (already installed).
GAS REQUIREMENTS
NATURAL GAS AND LIQUID PROPANE
REQUIREMENTS
When using an exhaust hood, the area above
the cooking surface of the grill must be covered
with a hood larger than the cooking area of the
grill, AND with a minimum of 1200 CFM (cubic
feet per minute) for proper outdoor application
WARNING!
GAS LINES
Never connect a gas line directly to the grill.
A pressure regulator must be installed on
all gas equipment. Removing or failing to
install the pressure regulator can result in fire
and serious personal injury and will void the
warranty
MINIMUM PRESSURE REQUIREMENTS
Ensure the gas supplied meets the minimum
pressure requirements. See below table for gas
requirements measure in water column (w.c.)
pressure:
Gas Type Maximum Minimum
Natural Gas 7” w.c. 4” w.c.
Liquid Propane 14” w.c. 11” w.c.
The burner covers or briquee trays are above
the burners and aach to the mounting pegs
located inside the firebox.
The cooking grates are placed above the burner
covers and finally the warming rack is placed on
the mounting tabs
Both the regulator and burner orifices have
been tuned for the type of gas specified on
the rating plate. Converting to a different type
of gas requires a conversion kit. Conversion
kits are included with this grill and located with
the manual. Converting gases may require
additional parts not included with this grill. (See
Gas Conversion section for details).